Professional Documents
Culture Documents
Oil Injectors
Series SL-42
Specifications:
Output Operating Pressure
Series
Min. Max. Min. Max. Typical Vent
.001 cu. in. .003 cu. in. 750 psig 1000 psig 850 psig 150 psig
SL-42
.016 cc .049 cc 52 bar 69 bar 59 bar 10 bar
11
Centro-Matic® Automated Lubrication Systems
Oil Injectors
Series SL-43
Specifications:
Output Operating Pressure
Series
Min. Max. Min. Max. Typical Vent
.001 cu. in. .008 cu. in. 750 psig 1000 psig 850 psig 150 psig
SL-43
.016 cc .131 cc 52 bar 69 bar 59 bar 10 bar
Notes:
1. Injectors, except replacement injectors for manifold, include compression nut and ferrule for tubing – 1⁄8" O.D. as standard.
Other outlet connectors for feed line optional.
2. Injectors with manifolds include two mounting clips and screws.
3. Standard injectors have Nitrile packings (200°F/93°C max.)
4. Heat Resistant injectors have Viton® packings (350°F/176°C max. depending on lubricant used) and Black Adjusting Cap.
5. Check packing compatibility with synthetic lubricants.
6. Output with indicator cap hand-tightened is .001 cu. in. Maximum output is achieved with five turns at .0014 cu. in./turn.
12
Centro-Matic® Automated Lubrication Systems
Oil Injectors
Series SL-41
• SL-41 series injectors are designed for use in high temperature applications up to 350°F (176°C), depending on lubricant.
• Available installed only in manifolds with 3⁄8" NPT female inlet.
• Injectors feature a tamper-resistant adjustment screw which does not incorporate a visual indicator.
• May be combined in a circuit of injectors SL-42, SL-43 and SL-44.
Specifications:
Output Operating Pressure
Series
Min. Max. Min. Max. Typical Vent
.008 cu. in. .080 cu. in. 750 psig 1000 psig 850 psig 150 psig
SL-41
.131 cc 1.31 cc 52 bar 69 bar 59 bar 10 bar
Notes:
1. Injector manifolds have 13⁄32" (10.3 mm) mounting holes for 3⁄8" bolt.
2. Minimum output (.008 cu. in.) is achieved by hand tightening the adjustment screw, then backing out 9 turns. Maximum output (.08 cu. in.) is
achieved by hand tightening the adjustment screw, then backing out 16 turns.
13
Centro-Matic® Automated Lubrication Systems
Oil Injectors
Series SL-44
Specifications:
Output Operating Pressure
Series
Min. Max. Min. Max. Typical Vent
.008 cu. in. .080 cu. in. 750 psig 1000 psig 850 psig 150 psig
SL-44
.131 cc 1.31 cc 52 bar 69 bar 59 bar 10 bar
Notes:
1. Injector manifolds have 13⁄32" mounting holes for 3⁄8" bolt.
2. Injectors have Viton® packings. Check packing compatibility with synthetic lubricants.
3. Injectors rated at 350°F (176°C) maximum ambient temperature, depending on lubricant used.
4. Output with adjustment screw hand-tightened is .009 cu. in. Maximum output is achieved with eight turns at .009 cu. in./turn.
14