Professional Documents
Culture Documents
09 - Engine, 3.6L / Cylinder Head / ASSEMBLY, Variable Valve Timing, Phaser / Oil
Control Valve / Removal
LEFT
Special Tools: Click to display a list of tools used in this procedure
3. Mount Dial Indicator Set C-3339A (1) to a
stationary point on the engine, such as the
number three cylinder ignition coil mount.
Position the indicator probe into the number
one cylinder, rotate the crankshaft clockwise
(as viewed from the front) to place the
number one cylinder piston at top-dead-
center on the exhaust stroke and set the
indicator dial to zero.
4. The left side cam phaser SCRIBE LINES (3)
should face away from each other and the
ARROWS (1) should point toward each other
and be parallel to the cylinder head cover
mounting surface (2) when the number one
cylinder piston is positioned at top-dead-
center on the exhaust stroke.
5. There should be twelve chain pins (2) BETWEEN the exhaust cam phaser triangle marking (3) and the
intake cam phaser circle marking (1) as viewed from either the front or rear of the cam phasers.
6. Mark both sides of the cam chain at the phaser timing marks (1 and 3) using a paint pen or equivalent
to aid in reassembly.
7. Install the Lock, Camshaft/Phaser, Left Side
10202-2 (1) against the cylinder head cover
mounting surface with the tool number facing
up.
8. Loosen, but do not remove, the exhaust oil
control valve (2) and the intake oil control
valve (3).
9. Remove the Lock, Camshaft/Phaser, Left
Side 10202-2 (1).
10. Using Pin 10200-3 (2), lift the pawl off of the
rack (3). While holding the pawl off of the
rack, push Holder, Timing Chain, Left Side
10200-1 (1) into place between the cylinder
head and the cam chain guide to force the
rack and piston back into the tensioner body.
The holder remains in place while the
phasers are removed (Refer to 09 -
Engine/Valve Timing - Standard Procedure) .
11. Remove the oil control valve (4) and pull the
left side exhaust cam phaser off of the
camshaft.
12. Remove the oil control valve (3) and pull the
left side intake cam phaser off of the
camshaft.