Professional Documents
Culture Documents
Procedure of Coupling Installation: 1.clean The Shaft by Using Sand Paper
Procedure of Coupling Installation: 1.clean The Shaft by Using Sand Paper
4.Tighten the sample coupling by using Allen key to determine the missalignment.
5.Loosen key hole on both side of the clamp.
8.Loosen the both side of the bolt and then tighten it by using hand only.
9.Install the laser shaft alignment on both shaft make sure as ‘S’ symbol on static shaft
(Pump) and symbol ‘M’ on move shaft(Motor).
10.Equip the chain on the both shaft v-bracket and install at the both shaft.
11.Tighten the chain to fix it to the shaft to enable it move when shaft v-brackets is fixed.
19. The metal is entered under the motor and fix the motor position to correct the alignment.
20.The display unit shows the result after the correction has been made.