Aviation World www.facebook.com/aviatorsworld JET ENGINE – FEB 2013 Jet Engine ( Feb 13 )
1. Jet Engine operates on
a) Otto cycle b) Close cycle c) Constant volume cycle d) Open cycle 2. Gas law is a) P1V1 = P2V2 b) PV = C c) 𝑷𝟏𝑽𝟏/𝑻𝟏 = 𝑷𝟐𝑽𝟐/𝑻𝟐 3. Identify diagram a ) Impulse B) Reaction C) Impulse-Reaction 4. Synthetic oil is used in GTE A) More viscous B) Can take high load C) Prevent coking and do not effect paint D) All 5. Compressor tip speed velocity formula a) V=πD rpm b) V=πD/rpm c) 𝑉 = 𝜋𝐷2 /rpm 6. Squeeze film bearing a) Dampens dynamic load b) Allows system to operate in dry condition 7. Annular duct a) Located in the front of fuselage b) Protudes in the lower side of fuselage 8. Rate of temperature rise detector a) Continous loop b) Thermocouple c) thermal switch 9. EGT is an indicator of a) TIT b) TOT 10. Which one have a variable area a) C-D b) Convergent c) divergent 11. Water injection in CC a)increase mass of air in whole engine b) decrease T and P in turbine and increase pressure in nozzle area 12. Wf = 700 gallons (6.5 lbs), Fn= 9000 lbs , find SFC? a) 0.5 lbs/hr b) 1 lbs/hr c) 2 lbs/hr 13. TSFC is a) directly proportional to efficiency b) directly proportional to compression ratio JET ENGINE – FEB 2013 c) Inversely proportional to compression 14. Thrust reverser a) should give 70% of forward thrust
b) Pre-exit is done by giving obstruction in exhaust
The Complete HVAC BIBLE for Beginners: The Most Practical & Updated Guide to Heating, Ventilation, and Air Conditioning Systems | Installation, Troubleshooting and Repair | Residential & Commercial
Power of Habit: The Ultimate Guide to Forming Positive Daily Habits, Learn How to Effectively Break Your Bad Habits For Good and Start Creating Good Ones