You are on page 1of 73

INOT MEASUREMENT!

. SENSmyE
MIL-STD-105E
10 MAY 1989

SUPERSEDING
MIL-STD-105D
29 APRIL 1963

MILITARY STANDARD
SAMPLING. PROCEDURES AND TABLES
FOR INSPECTION BY ATTRIBUTES

AMSC NIA AREA QCIC

PISJBIBUTION STATEMENT A, Approved for publlc release; distribution is unlimited.

www.ExpressCorp.com
MIL-STD-105E

DEPAR'.IMENT OF DEFENSE
Washington, oc 20301

SAME'LING PRCX:mURES AND TABLES FOR INSPE:CtICJN BY ATTRIBUTES

1. This military standard is approved for use by all Departrrents and Agencies
of the Departrrent of Defense.
2. Be."leficial �....�ts {rec...�.....idations, add.itior-'5, delet.ic.""s} &T"\rl �'1Y
pertinent data w'hich nay be of use in inproving this doc:urrent should be
addressed to:
Ccmnander
U.S. Army Armanent Research, Developrent and
Engineering Center
ATI'N: SM:AR�BAC-S/Bldg. 6
Picatinny Arsenal, NJ 07806-5000
by using the. self-addressed Standardization Docurrent Imprcvenent Proposal
(DD Form 1426) appearing at the end of this c:locurrent or letter.

ii
MIL-STD-lOSE

nus publication provides sanpl.l.ng procedures and reference taoles for use in
planning and conducting inspection by attributes. The sanpling concept is based
on the probabilistic reo.irrence of events ..tien a series of lots or batches are
prcxluced in a staole environrrent.

This publication should be used to guide the user in the devt:loµ,ent. of an


inspection strategy that provides a cost effec:r.ive approach to attaining
confidence in product cciiplianc:e with contractual tec."U'lical requirerents. The
user is 1oamed of the asSUlred risks relative to t.l;le chosen sanple size and
AQL.

Military specifications should not contain requirerents for use of specific


sanpling plans, nor should they provide AQL' s or LTPD' s as a requirerent.

Sarrpling plans for continuous, rather than lot inspection, are contained in
MIL-S'ID--1235, "Single and M.Jlti-I..evel c.ontinuous Sarrpling Procedures and Tables
for Inspection by Attributes".

iii
MIL-STD--105E

a:NI'ENI'S

Paragraph
1. SwPE .............................................. . 1
1.1 Purpose........................................... 1
1.2 Jq:plication....................................... 1
2. REFERENCED DCCUMENI'S ••.•..•••••..•.••••••••••••••••. 1
2.1 Not applicable....... _. ........................... . 1
3. DEFINITIONS ......................................... 1
3.1 Acceptable Quality Level (AOL) ................... . 2
3.2 Average Outgoing Quality (AD:!) ••••••••••••.••.•••• 2
3.3 Average Outgoing Quality Limit (AD:!L) •••••.••.•... 2
3.4 Classification of Defects ........................ . 2
3.5 Critical Defect................................... 2
3.6 Critical Defective........... : .................... 2
3.7 Defect....·......................................•. 2
3.8 Defective .......................................... 3
3.9 Defects Per Hundred Units......................... 3
3.10 Inspection.... : ................................... 3
3.11 Inspection by Attributes......................... . 3
3.12 Lot or Batch..................................... . 3
3.13 Lot or Batch Size................................. 3
3.14 Major Defect ..................................... . 3
3.15 Major Defective................................... 3
3.16 Minor Defect..................................... . 3
3.17 Minor Defective ................................... 3
3.18 Percent Defective................................
· . 4
3.19 Process Average ................................... 4
3.20 Sarrple............................................ .4
3.21 Sample Size Code Letter........................... 4
3.22 Sarrpling Plan..................................... 4
3.23 Unit of Product ................................... 4
4. GENERAL REQUIREMENrS ••••.••••••••••••••••.•••••.•••. 4
4.1 Written Procedures............................... . 4
4.2 Nonconformance................................... . 4
4.3 Formation and Identification of Lots or Batches... 5
4.4 AOL........................ ...................... . 5
4.4.1 AOL Use........................................... 5
4.4.2 Limitation........................................ 5
4.4.3 Oloosing AQLs •..•.•••••••••••.•.•••••••••••••••••• 5

iv
MIL-S'ltr105E

CCNI'ENI'S - Continued.

Paragraph
4.5 Sarrpling...........•..••......•......•........... 5
4.5.1 Representative Sarrpling•.••....•.• •...••....••... 5
4.5.2 Time of Sarrpling..••..•..........•............... 5
4.5.3 Double or l'ultiple 5anpling.......•.............. 5
4.6 Inspection Procedures.............•.........•.. :. 6
4.7 Switchirw;i PrQOedures •••••••••••.•••••••.••••••••• 6
4.7.1 Normal to Tightened..•.......••....•...•......... 6
4.7.2 Tightened to Normal...•..•....................... 6
4.7.3 Normal to Reduced••••••••••.•••••••••••••.••••••. 6
4.7.4 Reduced to No=.l ..•............................. 6
4.8 Discontinuation of Inspection.................... 7
4.9 Sanpling Plans................................... 7
4. 9.1 Inspect ion Level ......•.......................... 7
4.9.2 Code Letters .•................................... 7
4.9.3 Cbt:aining Sa!tpling Plan ......................... . 7
4. 9. 4 Types of Sa!tpling Plans........... ··············· 8
4.10 Determination of Acceptal:>lli ty.... , .• , •..•.....•. , 8
4.10.1 Percent Defective Inspection..................... 8
4.10.1.1 Single Sarrpli.ng Plan............................. 8
4.10.1.2 Double Sanpli.ng Plan............... , , ... , ..... , .. 8
4.10.1.3 H.Jltiple 5arrpling Plan........................... 8
4.10.1.4 Special Procediire for Reduced Inspection.•....... 8
4.10.2 Defects Per Hundred llnits Inspection.......... .... 9
4.11 Limiting O\Jal.ity Protection.........•............ ,9
4.12 Curves••..••••••••••.••••.•..••••.••••••••••••••• 9
4.12.1 Cperating Olaracteristic CUrves.••••••••••••••••• 9
4.12.2 Average Sallple Size CUrves. :.................... . 9

.,. T�......••.•....•.....••....•.......•....•••..... 11

Table
I. Sarrple Size Code Letters......................... 13
II-A. Single Sarrpli.ng Plans for Normal
InSpection CM3ster table) ...................... 14
II-B. Single Sarrpling Plans for Tight.ened
InSpection (M3.ster table) ...................... 15
II-C. Single Sa!rpling Plans for Reduced
Inspection (Master table) ...................... 16
III-A. Double Sanpli.ng Plans for Normal
InSpection CM.3Ster table) ..................... . 17
III-B. Double Sa!rpling Plans for Tightened
InSpection (Master table) ...................... 18
III-C. Double Sa!rpli.ng Plans for Reduced
Inspection <Master table) ..........•........... 19

V
MIL-S'ID-105E

. CXNI'ENTS - Continued.

Table
N-A. M..lltiple Sarrpling Plans for Normal
Inspection (Master table) ...................... 20
N-B. M..lltiple Sarrpling Plans for Tightened
Inspection (Master table) ...................... 22
N--C. M..lltiple Sarrpling Plans for Reduced
Inspection (Master table) ..........•........... 24
V-A. Average Outgoing Quality Limit Factors for
No:anal Inspect.ion (Single Sarrpling) ............ 26
V-B. Average Outgoing Quality Limit Factors for
Tightened Inspection (Single Sanpling) ......... 27
VI-A. L:iJniting Q.lality (in Percent Defective) for
which a Pa = 10% (for Normal Inspection,
Single Sarrpling) ............................... 28
VI-B. Limiting Quality (in Defects per Hundred
Units) for which the Pa = 10% (for Normal
Inspection, Single Sanpling) .................. . 29
VII-A. Limiting Q.lality (in Percent Defective) for /
which the Pa = 5% (for Normal Inspection,
Single Sanpling) ............................... 30
VII-B. Limiting Q.lality (in Defects per Hundred.
Units) for which the Pa = 5% (for No:anal ''
Inspection, Single Sarrpling) ..................
· . 31
VIII. Limit Numbers for Reduced Inspection............. 32
IX. Average Sample Size Curves for Double and
Multiple Sanpling.............................. 33
Sampling Plans and Operating Olaracteristic
Curves (and Data) for:
X-A. Sarrple Size Code letter A........................ 34
X-B. Sarrple Size Code letter B....................... . 36
X--C. Sanple Size Code letter C. .• : •.•..•••..•.•...•..• 38
X-D. Sanple Size Code letter D........................ 40
X-E. Sanple Size Code letter E........................ 42
X-F. Sanple Size Code letter F ........................ 44
X-G. Sanple Size Code letter G........................ -46
X-H. Sanple Size Code letter H••..••••.•••••...••.•••• 48
X-J. Sanple Size Code letter J ........................ 50
X-K. Sanple Size Code letter K ........................ 52
X-L. Sanple Size Code letter L •....................... 54
X-M. Sarrple Size Code letter M ........................ 56
X-N. Sanple Size Code letter N....................... . 58
X-P. Sanple Size Code letter P ........................ 60
X-Q. Sarrple Size Code letter Q•..••••••••••••••••••••• 62
X-R. Sanple Size Code letter R ........................ 64

vi
MIL-S'ID--105E

c::cmwrs - COncinued.

x-s. 66
Paragraph
6. !UIES•.•.•..•...•.••..••.••••.•••.•••••••..•..•.. 67
6.1 Intended Use •.•.••••••••••••••••.•••• • · · • · · · • · · 67
6.2 Subjece Te:an (key word) Liscing.•...•••....••.. 67
6.3 01anges fran Previous Issue . • ................. .
. 67
CXN:UJDIN:; �-····························· 68

vii
MIL-S'llrlOSE

1. SCOPE
1.1 Purpose. nus publication establishes lot or batch sanpling plans and
procedures for inspection by attributes. 'nl.is plblication shall not be ·inter­
preted to supercede or conflict with any contractual requirenents. The words
"accept", "aocepcanoe", "ao:::eptable", etc, refer only to the contractor's use of
the sairpling plans contained in this standard and do not i.rrply an agree1e1t by
the Governtrent to accept any product. Determination of acceptability by the
Goverr,-:ent shall be as described in contractual dooJtrents. The sanpling plans
described in this st.andarcl are i!R)licable to J\OL' s of . 01 percent or higher and
are therefore not suitable for i!R)lications where qualit:y levels in the defective
parts per milliot1 range can be realized.
1.2 J>.a?lication. Sarrpling plans designated in this publication are applicable,
but not: limited, to inspection of the following:
a. End items.
b. Carponents and raw mat:erials.
c. Operations or services.
d. Materials in process.
e. Supplies in storage.
f. Maintenance operations.

g. Data or records.
h. Aani.nistrative procedures.
These plans are intended primarily to be used for a continuing series of lot:S
or batches. nie plans may also be used for the inspection of isolated lots or
bat:ches, but, in this latter case, the user is cautioned to consult the operating
characteristic o.irves to find a plan which will yield the desired protect.ion
(See 4.11).

2. REFEREN:ED lXX:l.MNl'S
2.1 Not i!R)licable.
3. DEFINITICNS

l
MIL-S'ItrlOSE

3.1 Acceptable 0-la].ity Level (l\QL). When a continuous series of lots is


considered, the AQL is the quality level which, for the purposes of sarcpling
inspection, is the limit of a satisfactory process average (See 3 .19) .
NOTE: A sanpling plan and an AQL are chosen in a=rdance with the risk assurrecl.
Use of a value of AQL for a certain defect or group of defects indicates that the
sarrpling plan will accept the great rrajority of the lots or batches provided · the
process average level of percent defective (or defects per hundred units) in these
lots or batches be no greater than the designated value of AQL. Thus, the AQL is
a designated value of percent defective (or defects per hundred units) for which
lots will be accepted IrOst of the tirre by the sarcpling procedure being used. The
sampling plans provided herein are so arranged that the probability of acceptance
at the designated AQL value depends upon the sample size, being generally higher
for large samples than for SIM.11 ones, for a given AQL. The AQL alone does not
identify the chances of accepting or rejecting individual lots or batches but rrore
directly relates to what might be expected frcrn a series of lots or batches,
provided the steps indicated in this publication are taken. It is necessary to
refer to the operating characteristic curve of the plan to determine the relative
risks.
3. 2 Average Outgoing Quality (AOO) • For a particular process average, the AOQ is
the average quality of oi.--t.going product including all accepted lots or batches,
plus all rejected lots or batches after the rejected· lots or batches have been
effectively 100 percent inspected and all defectives replaced by non-defectives.
3. 3 Average Outgoing Quality Limit (AOQL) . The -AOQL is the maximum AOQ for a
given acceptance sarcpling plan. Factors for ccmputing AOQL values are given in
Table V-A for each of the single sampling plans for norrral inspection and in
Table V-B for each of the single sanpling plans for tightened inspection.
3.4 Classification of Defects. A classification of defects is the enurreration of
possible defects of the unit of product classified according to their seriousness.
3. 5 Critical Defect. A critical defect is a defect that judgerrent and experience
indicate would result in hazardous or unsafe conditions for individuals using,
rraintaining, or depending upon the product, or a defect that judgarent and
experience indicate is likely to prevent perforrrance of the tactical function of a
rrajor end item such as a ship, aircraft, tank, missile, or space vehicle.
3.6 Critical Defective. A critical defective is a unit of product which
contains one or IrOre critical defects and rray also contain rrajor and/or minor
defects.

3. 7 Defect. A defect is any nonconforrrance of the unit of product with


specified requirerents.

2
MIL-STD-l0SE

3.8 Defective. A defective is a unit of produce which contains one or m:>re


defects.

3.9 Defects per Hundred units. The rn.mcer of defeces per hundred units of any
given quantity of units of product. is one hundred tines .the rnmber of defects
cont:ained therein (one or m:>re defeces being possible in any unit of product)
divided by the total nU!l0er of units of produce, i.e.:

Defects per = Number of defects x 100


hundred units Nuritier of units inspected

3.10 �ion. Inspection is the process of rreasuring, examining, testing,


or otherwise COTparing the unit of product with the requirerrent:s.

3.11 I.npection by Attributes. Inspection by attributes is inspection whereby


either the unit of product is classified sinply as defeceive or non-defective, or
the rn.trri:ler of defects in the unit of produce is counted, with respect to a given
requirerrent or set or requireients.

3. 12 Lot or Batch. The tenn lot or batch shall rrean "inspection lot• or
"inspection batch", i.e., a collection of units of product from which a sa.,ple ·
is to be drawn and ir.spected and may differ from a collection of units designated
as a lot or batch for other p.irposes (e.g., production, ship,-ern:, etc.).

3.13 Lot or Batch Size. Tile lot or batch size is the number of units of product
in a lot or batcli.

3.14 Major Defect. A major defect is a defect, other than critical, that is
likely to result in failure, or to reduce materially the usability of the unit
of product for its intended p.irpose.

3.15 l>'.ajor Defective. A major defective is a unit of product which contains one
or rrore major defects, and may also contain minor defects but contains no critical
defect.

3 .16 Minor Defect. A mi.nor defect is a defect that is not likely to reduce
materially the usability of the unit of product for its intended purpose, or is a
departure fran established standards having little bearing on the effective use or
operation of the unit.

3.11 Minor Defective. A minor defective is a unit of product which contains one
or m:>re minor defects but contains no critical or major defect.

3
MIL-STI>-105E

3.18 Percent Defective: The percent defective of any given quantity of units
of product is one hundred tirres the number of defective units of product contained
therein divided by the total number of units of product, i.e.:
Percent Defective = Number of defectives x 100
Number of units inspected
3 .19 Process Average. The process average is the average percent defective or
average number of defects per hundred units (.ihichever is applicable) of product
sul:rnitted by the supplier for original inspection. Original inspection is the
first inspection of a particular quantity of product as distinguished frcm the
inspection of product .ihich has been resul:rnitted after prior rejection.
3. 20 Sarrple. A sarrple consists of one or more units of product drawn frcm a lot
or batch, the units of the sarrple being selected at random without regard to their.
quality. The number of units of product in the sarrple is the sarrple size.
3. 21 Sarrple Size Code Letter. . The sanple size code letter is a device used
along with the AQL for locating a sarrpling plan on a table of sarrpling plans.
3. 22 Sarrpling Plan. A sarrpling plan indicates the number of units of product
fran each lot or batch .ihich are to be inspected (sample size or series of
sarrple sizes) and the criteria for determining the acceptability of the lot or
batch (acceptance and rejection nurnbers).
3. 23 Unit of Product. The unit of product is the thing inspected in order to
determine its classification as defective or non-defective or to count the n1,llllber
of defects. It may be a single article, a pair, a set, a length, an area, an
operation, a volurre, a carponent of an end product, or the end product itself.
The unit of product may or may not be the sane as the unit of purchase, supply,
production, or ship-rent.
4. GENERAL RE:QlJIREMNTS

4 .1 Written Procedures. Written procedures are ordinarily developed and made


available for the Government representative's review, upon request. When the
written procedures indicate use of this standard, they shall CCJTply with the
requirelent:s of this standard and reference appropriate parts as necessary.
4 . 2 Nonconformance. The extent of nonconforrnance of product shall be expressed
either in teDllS of percent defective ·or in teDllS of defects per hundred units.

4
MIL-Sit>-lOSE

4.3 Fo:orat.ion and Ident.ificat.ion of Lots or Batches. The product shall be


assarbled into identifiable lot:s, sublets, batches, or in such other manner as
may be presa-ibed. · Each lot or bat.ch shall, as far as is practicable, consist
of units of product. of a single t.ype, grade, class, si2.e, and cmposit.ion,
manufactured under essentially the 5alle oonditions, and at. essentially the smre
tine. The lets or batches shall be identified by the o:mt.ract.Or and shall be kept
int.act in adequate and suit:able storage space.
4.4 AQL.
4 • 4 • 1 AOL use. The AOL, together wit:h the Sanple Si2.e Code let:t.er, is used for
L-idex.i.ng the Scmpling plans provided here.in.
!
4.4.2 Limitation. The selection or use of an AOL shall not. iJrply t.hat the
cont.ractor has the right. t.o suwly any defect.ive· unit of product.
4. 4. 3 01oosing 'AQLs. Different AQLs may be chosen for groups of defects
considered collective�y, or for individual defects. An AOL for a group of defects
may be chosen in addition to AQLs for individual defects, or sul:groups, within
that group. AOL values of 10.0 or less rray be expressed eit.her in percent
defeaJ.ve mo in CPfects pP-1' hl....rrd...red uri..its; t.n�se CJVP-r 10.0 s..h.�,, be e.�_ssec! Lr,
defects per hundred units only.
4 . 5 Sanpli.ng .
4,5.1 RepreSent.ative iStratified} Sa!tp.1.inq. When appropriat.e, t.he nuniler of
units in the sanple shall be selecteclin proport.ion to the si2.e of sublot:s or
sub-batches, or partS of the lot or batch, identified by sare rational criterion.
When representative san-pling is used, the \JI\its fran each sublet, sub-batch or
part of the lot or batch shall be selected at randan.
4.5.2 Tirre of Sa!Tpling. A_sanple may be dra"'1'1 after all the unit.s c:aiprising
the lot or batch have been asserbled, or sanple unit.s may be drawn during assenbly
of the lot or batch, in which case the she of the lot. or bat.ch will be determined
�fnr,:.
----- Anu ---� """"""'""
c..::tn1r"'lllo ,,n;r-c. :1ro �-�
-•J -·r-- -.iw ... ••· Tf: t-1-,,,,ei,
...... r-�fflr'\,...., •""<r-�
-a- �•�•'- i:a..-.o. A.-:n..
-••1---i �,_ ....._u....... � • .-{.-. �•-.1.z
1.1 �-� !>.c-c-on,l>-,.11.,
of the lot or bat.ch, and if the rejection nurroer is reached before the lot u;
catpleted, that. portion of the lot already carpleted shall be rejected. The cause
of the defective product shall be det.ennined and corrective action taken, after
which a new lot or batch shall be begun.
4. 5. 3 Double or "'1.lltiple Sanplinq: When double or multiple sanpling is t.o be
used, each sanple shall be selected over the entire lot or bat.ch.

5
MIL-STD-lOSE

4. 6 Inspection Procedures. Normal inspection will be used at the start of


inspection. Normal, tightened or reril.1n=<l inspection shall continue unchanged for
each class of defects or defectives on successive lots or batches except where the
switching procedures given below require change. The switching procedures shall
be applied to eac.>:i class of defects or defectives independently.
4. 7 Switching Procedures.
4. 7 .1 Normal to Tightened. When normal inspection is in effect, tightened
inspection shall be instituted when 2 out of 2, 3, 4, or 5 consecutive lots or
batches have been rejected on original inspection (i.e., ignoring resul::mitted lots
or batches for this procedure).
4. 7 .2 Tightened to Normal. When tightened inspection is in effect, normal
inspection shall be instituted when 5 consecutive lots or batches have been
considered acceptable on original inspection.
4. 7. 3 Normal to Reduced. When normal inspection is in effect, reduced inspection
shall be instituted provided that all of the following conditions are satisfied:
a. TI"'...e preced.in.g 10 lets or batches ·{or more, as inrlirArPri hy t-hP nnr_� to
Table VIII) have been on normal inspection and all have been accepted on original
inspection; and
b. The total number of defectives (or defects) in the sanples from the
preceding 10 lots or batches (or such other nurroer as was used for condition "a"
above) is equal to or: less than the applicable number given in Table VIII. If
double or multiple sanpling is in use, all sarrples inspected should be included,
not "first" sanples only; and

c. Production is at a steady rate; and


d. · Reduced inspection is considered desirable.
4. 7 .4 Reduced to Normal. When reduced inspection is in effect, normal inspection
shall be instituted if any of the following occur on original inspection:
a. A lot or batch is rejected; or
b. A lot or batch is considered acceptable under the procedures of
4.10,1.4, or
c. Production becorres irregular or delayed; or
d. Other conditions warrant that normal inspection shall be instituted.

6
MIL-S'ID-105E

4.8 Discontinuation of Inspection. If the curmulative nurroe.r of lots not


rc!lrhoc
.. ___ ,p;,,c
.,,,._, �ho �-wl
ac:c:epted in a sequence of c:onsecuti ve lots on original tightened inspection
::>��nr.::i. n� .._..,,,_o "'-f: ..-ft,(C! C!t-�nr\�T'l"'I
-� ____l""......... .-. t"4 .... ._.,••,� """- wl"-u.l� ...

Inspection under the provisions of this standard shall not be resurred until
eo'k:i.11
�-.. ..
\,-,o Mic-rnn��rn'tClin
...._ ----�·-·-·

corrective act.ion has been taken. Tigthened inspection shall then be used as if
4. 7 .1 had been invoked.
4.9 Sarrpiing Plans.
4 . 9 .1 Insoection level: The inspect.ion level determines the relationship bec-,,een
the lot or batch size and the sarrple size. 1lle inspection level to be used for
any particular requirerent will be as prescribed by the contractor' s written
p:::-ocedures. ntree inspection levels: I, II, and III, are given in Table I for
general use (see 4 .1). Normally, Inspection Level II is used. However,
Inspeccion Level I may be used when less discrimination is needed, or Level III
may be used for greater discrimination. Four additional special levels:
S= l, S= 2, S= 3, arid. S =4, a,...-e giVE.11 L1 u'--ie sai,e t.able and rr.ay be used ...-"here
relatively small sarrple sizes are necessary and large sarrpling risks can or must
be tolerated.
NO!E: In the selection of inspection levels S-1.to S-4, care must be exercised to
avoid AQLs inconsistent with these inspection levels. In· other words, the purpose
of the special inspection levels is to keep sarrples small when necessary. For
instance, the code letters under S-1 go no further than D, equivalent to a sin;)le
sarrple of size 8, but it is of no use to choose S-1 if the AOL is 0.10 percent for
which the minim.un sarrple is 125.
4. 9. 2 Code Letters. Sanple sizes are designated by-cede letters. Table I shall
be used to find the applicable code letter for the particular lot or batch size
and the prescribed inspection level.

4.9.3 Obcaining Sarrpli.ng Plan. The J\QL and the code letter shall be used to
obtain the sanpling plan fran Tables II, III, or rv. � no sanpling plan is
available for a given c:ali:>ination of AOL and code letter, the tables direct the
user to a different letter. The sairple size to be used is given by the new code
letter, not by the original letter. If this procedu� leads co different smrple
sizes for different classes of defects, the code letter co� to the
largest sanple size derived may be used for all classes of defects. As an
alternative to a single sanpling plan with an ac:cepcance nurroer of O, the plan
with an st...1.1.::pt.a.n.ce ro,.m,h=ar of 1 wit..11 its corret
__c:pondingly la.rgP-r sa.nple size for a
desigrµit:.ed AOL (where available>, may be used.

7
MIL-S'ID-105E

4.9.4 Types of Sampling Plans. TI1ree types of sanpling plans: Single, Double,
and lliltiple, are given in Tables II, III, and JV, respectively. When several
�._,...,.. .... � .... 1.,,, ...... --.� 0.YCL.J-.1..U"'-".&.'1,;;;
.,,,,.r-,,,..; l ::11hl,,,. �,.. ... g,... ,...4 .. ,.,,.... �,l,J
1\.r"\T QJ.1\,,1,
.,,,.....,,4 �
,...rv4,,,,. l o.+-+-o.T"" ::11n1, r,no ft'l:a\l rv::i,.
L.:f,t-"'=-> V-L ,t,".LQJ.lo.;) �'I; ._...,.,,_ �•V�I ..L.l;;.1,.,1,.,'-'..1,./ ...... 1:J
._.,._ •._ ••-:J ..,._ 11c::M
--•
A decision as to type of plan, either single, double, or multiple, when available
for a given AOL and code letter, will usually be based upon the cariparison bet-1
the aaninistrative difficulty and the average sarrple sizes of the available plans.
The average sarrple size of multiple plans is less than for double (except iri. the
case corresponding to single acceptance number 1) and both of these are always
less than a single sample size (see Table IX). Usually the administrative
difficulty for single sarrpling and the cost per unit of the sample are less than
for double or multiple.
4. 10 Determination of Acceptability.
4.10.1 Percent Defective Inse;ction. To determine acceptability of a lot or
batch under percent defective inspection, the applicable sanpling plan shall be
used in a=rdance with 4.10.1.1, 4.10.1.2, 4.10.1.3, and 4.10.1.4.
4.10.1.1 Single Sampling Plan. The number of sanple·units inspected shall be
equal to the sarrple size given by the plan. If the number of defectives found in
the sarrple is equal to or less than the acceptance number, the lot or batc;h shall
be considered acceptable. If the number of defectives is equal to or greater than
the rejection number, the lot or batch shall be rejected.
4.10.1.2 Double Sampling Plan. A nurroer of sample units equal to the first
sanple size given by the plan shall be inspected. If the number of defectives
found in the first sample is equal to or less than the first acceptance number,
the lot or batch shall be considered acceptable. If the m.unber of defectives
found in the first sample is equal to or greater than the first reject.ion number,
the lot or batch shall be rejected. If the number of defectives found in the
first sarrple is between the first acceptance and rejection numbers; a second
sample of the same size shall be inspected. The rn.m1ber of defectives found in
the first and second sanples shall be accumulated. · If the cumulative number of.
defectives is equal to or less than the second acceptance number, the lot or batch
shall be considered acceptable. If the cumulative number of defectives i.s equal
to or greater than the second rejection number, the lot or batch shall be
rejected.
4 .10 .1. 3 1'1.lltiple Sanple Plan. Under multiple sa.npling, the procedure shall be
similar to that specified in 4.10.l.2, except that the number of successive
sanples required to reach a decision may be as many as seven.

4 .10. 1. 4 Special Procedure for Reduced Inspection. Under reduced inspection, the
sarrq:,ling procedure may terminate without either acceptance or rejection =iteria
having been rret. In these circumstances, the lot or batch will be considered
acceptable, but normal inspection will be reinstated starting with the next lot or
batch (see 4.7.4.b).

B
MIL-S'lt>-lOSE

4.10.2 Defects per Hundred Uni � aooept:ability of a


�ion. To dete:cmine _
lot: or bat:ch under defect:s per units inspect.ion, t:he procedure specified
for percent defective .inspect:ion above shall be used, except: Chat the wom
"defects" shall be subst:itut:ed for "defectives".

4 .11 Limiting Qua.lit Prot:ection. 'l'he sanpling plans and associated procedures
Ll:
given .in this publica on were designed for use where the units of product: are
produced in a continuing series of lots or batches over a period of tine. ·However,
if the lot: or batch is of an isolated nature, it is desirable to limit the
selection of sanpling plans to those, associated with a designated AOL value, that
pr=ide not less than a specified limiting quality prot:ection. 5alrpling plans for
this purpose can be selected by choosing a Limiting Quality (LO) and a c:onsurrer' s
risk to be associated with it. Tables VI and VII give values of LO for the
the 0.1m01u.y used consurrer' s risks of 10 percent and 5 percent respectively. If a
different value of c:cnsuner' s risk is required, the o.c. curves and their tabu­
lated values may be used. n-.e concept: of LO may also be useful in specifying the
AOL and Inspection' Levels for a· series of lots or batches, thus fixing miniJTum
sarrple size where there is sore reason for avoiding (with 11Dre than a given
c:onsurrer' s risk) 110re than a limiting proportion of defectives (or defects) in any
single lot or batch.

4.12 CUrves.

4.12.1 Operat.:09 Olaracteristic CUrves. 'l'he operating c:haracceristic o.irves for


normal inspection, shown in Table x, indicate the percentage of .lots or batches
i.ru.ch nay be expected to be accepted under the various sanpling plans for a given
process quality. The o.irves shown are for single sanpling; curves for double and
multiple sanpling are matc:hecl as closely as practicable. The o.c. o.irves shown
for J\QLs greater than 10.0 are based on the Poisson distribution and are appli­
cable for defects per hundred units inspeci:ion; those for AOLs of 10.0 or less and
sanple sizes of 80 or less are based on the bincrni.al distribution and are
a,:plicable for percent defective inspection; those for J\QLs of 10.0 or less and
sanple sizes larger than 80 are based the Poisson distribution and are applicable
either for defects per hundred units inspect.ion, or for percent defective
inspect.ion (the Poisson distribution being an adequate approximation to the
bincrni.al distribution under these conditions). Tabulated values, corresponding to
selected values or probabilities of aa:eptanc:e (Pa, in percent) are given for each
of the rurves shown, and, in addition, for tightened inspection, and for defects
per hundred units for J\QLs of 10.0 or less and sanple sizes of 80 or less.

4. 12. 2 Average Sanple Size curves. Average sarrple size curves for double and
multiple sampling are in Table IX. These show the average sanple sizes wch may
be expected to occur under the various sarrpling plans for given levels of process
quality. The curves assune no curtailrrent of inspection and are awroximate to
the extent that they are based upon the Poisson distribution, and that the sairple
sizes for double and multiple sampling are ass.ured to be 0.631n and 0.25n
respectively, where n is the equivalent sanple size.

9
MIL-S'ID-lOSE

11
TABLE l'-Sample siu code letters
(sec 4.9.l and 4.9.2)

Special in�c,Jon Jr1'e1a Genr.ral inarectioD levela

Loi o, batcb ah:e


. S-1 S-2 S-l S-4 I II Ill

,.
,.
IO 8 A A A A A 0
9 IS 0 C
,.
IO A A A A
16 IO 25 A IJ 0 B .c 0

26 • to so A 0 0 C C 0 E
51 IO !lO B 0 C C C E F
91 lo 150 B 0 C 0 I) F G

151 to 280 e C 0 E E G II

:: 281
501
lo
lo
500
1200
B
C C
C D
E
E
F
F
G
II
J
J

1201 lo 3200 C I) t: G II K L
3201 lo 10000 C u F G J L ll
IOOOI to 35000 C 0 F II K M N

35001 lo 150000 I} E G J L N r
150001 lo 500000 I} E G J l! p 0
500001 and over I} E II K N IJ fl

....
m
�n
mO
::,i:,o
Vtm
Z !!! TABLE II-A-Single sampling plans for normal impection (Master table)
oz
{see 4,9,3 and 4,9.4)
� �
)>m

.... •-�
,-
..
..
Att�•hl• Qulh1 Lo,1• f...,tl lu,-.clio,,J

,,�
""'
S-plr
s..., 1.
0.011) uns om 9.10 G.lS O.ZI 0.40 • <S ... 1.5 2.5 ,.. .., ,. II ZI lS IOI ISO ,so '"' '50 100!


liu

,, "'
....
"' ,, " ,, " ,,
.
,,

!]
-
l.ttr,
n, ,c "" Ac R, Ac R" 4c R, ,\C Rt Ac A, 4c: Re

••I • •I" "I" "I" •I• "I•....• Is,!


Ac At R, Ac tt. A.c R, Ac n, ,\c "" Ac R, Aic R, • o\c Re , Ac R, le n, le R,

-
J1
,\c

• '' •
At At

• ' ' I
-.l1 .-c,. ,fl.. '·
..
◊ 0 I

l l 1 I 10 II H IS 21 " ., JI
, l l
I
--l),,-
I I H) 11 U IS 21 ZI ., )I

-0-1 , •I I• l•I • ••I '•


0 I I 7

� I ; I ; I 111 111 111 11111 I 11 I 11 1111111 11 I 111<->I Q• I+o•I


" ,......,_ .....;
l
◊ ...0- I I•.
1 I 10 II 14 IS 21 " ., JI

•'
5 I 7 ;,.
C

D ' D I
◊◊ I 2 2 l l 4
'
5
.. "
I 10 II U IS 21 " JI) 31

◊ --0-
• s •
"'
I I I l l 4 I 10 II 14 15 21 " JO JI I.---,_ 0
' •
D I
,. ,-0,. ◊ I '
E ll
f I•�!,,- D I I s 1 I \0 ll H \S II '2 1....-,.. 1/;,. I•�,_ I,!

1....__� • ' • •
'' •• s' ' ,.,,.
'◊ ..0,. I I l 5 1 I 10 11 II IS " Z2 /;,.
'
l2 J

<>
G
1"'7 ◊ I l 8 10 II It I!, 21
'
D I J "';,,.
H
, ...._,.,.
so
-0- ◊ D I I 2 ' J l 5 I Ht II 14 15 21 72 ..
;,.

I, • '◊ ..0,. I ' I


J ID

"' • ' •
••
K
'-- l l 1 I 10 II 14 IS 21 % I/>.

""' '◊ ◊ I I I l l 5 • 1 I 10 II II 15 21 "I•;.


,..__,. '◊ --0- I I ' l J •
L D ��!,,-

• "' D I 1 I 10 11 14 IS 21 27 .--:,..
D •◊ .l), I ' '

1
" • ' '
' /s.
SOD ·�!,,- J J I I 10 II 14 15 21 2,

--0- I ' ' l J • ' I ! I


p IOI I•.>' D
'◊ ◊ I I • 5 • 1J J ' 10 II H 15 II 17

-
II 10 II 15 21 17

1f IT
1250 O I

1f IT
Q

' ' • '


-
R 200) I l I I 1 I 10 II 14 15 21 "
� .. �

•lu, ,.,_ 100 pn't' l'111 l11■,.c11....


� • U• (ln1 1--,liq pl• Mkra __.., If ••..,I• ,lu "P•I•. • ucHD, lot o, .,_,,.
� • UN n,-1 H-,liaf ,. .. aba"' .,.,,.,
Ac • Acc•,.••r• ...... ,
Ra • ftsjKII• .......
MII,-S'JD-lOSE

.... i II :: •
;
"'
....
JI ;; '; ....
.
'§..,

,!
=:;;:
=!!ft
!! ft u
'
.
-- -- --
JI
::
". .
,!
!
"' II
JI
•=:
. -�=
d!
; y

:: .
II
.... C

··= ;

== :: .
:

-.." - ...
II ,

=• === :•
,!
� -•:
"--
JI
-.. �

-··
i

-.. -- =• = -""." - .
JI

== '. '
s

-. -• ==•
,!

- = ---
JI
,!

.....
JI
d! == == ••
= ¢""- " -- -. •-
• = :
••
II

-�-...:: = c::;>: -- -- -.
d!
-- =• ==
= = - - - - - =•
JI

�= --- ---- ---


== (: .
..• ¢:� -- -- -. -- -
:

·-...::
,l
I

:j
} .
,l

.• =• == =' .i
!!
< -• =• ==
JI

..:::,-�-..
:: l c::;>: -
i I

,.i .,- " � � - .


0

-... .
,!

- == == ¢=
�-( -. -• =• I
l

!!
) � - -- -- -. -•
0

j
•- = : ¢:i .4l
,!
::! I

= -- -- -•
; /I 0

...:: l �
•l s .
,!
):I
-
� - ==
• - = =
-. -• =• == ---
I
j J

) �
- - i:
d!

-
I

� - - - - -
0 0

·-::
I>() s
0 .
"'
,!
C
I�
- -
.. � - - - - •- - . - :: 0 .
I

t
"
-- -- -. •-
II

... =" = •. •- �
JI 0

1'
- - -- .-
,!

=" "
0

·-::
=
• � -- --
,!

•• -
CIC

ii-
0

•. �
•• - � --
,!
I JI 0

'-
••• - � --
CQ I ,!

tl •JI
0 JI 0

.• - ¢:i
0 0

;; ,!

.• -
CQ
0 JI 0

,
,!
s "
0

--- - = -
0
JI

-1-a 2 R � II !! I! ;; § II � n �

.. -
;;

jijj
C C, U 0 w .. .. = - - .. • .. C 0

SINGLE
15 TIGHTENED
MIIrS'ID-lOSE

I � ;;;; ;;;; t===============


.
"'
C=============
� � �
...
-,

l � � ;:: •
§

= = � ;:'::·================�
� r: ;; ;; 'I
] § :.
.., i! � =: .. : ;:; \i
"' = ; tC:===============::i
t::. .. •

==,t·===========�

""
I = ....... .. -
l .. • 2
� J - ... .... 2 :. ..
2 :: ..
,
.;-
-
� ..,
.
.. . =
-a

ti !l l
-" "
��= ::: ::: ;
V
.
� N N ...

: ... ... .. "J. .. - ::


Ill :_ - - - .. ... on '

·-
;, ,,:

·-..,
;,
-
]
2

.,,�
¢: :

.l

.. - < <
..
"'Ii }
l
0

- - .,, � ::
!

!
"=

.. ••
0

! ! c=:;> : ¢19 ::: ::: --


..-
:'.!

-
2
l
- -
';
... & 2
'
;,
t• === = - "

.I
I

! C• = � : ¢3�: : : : i1
::,
i
"
lll .,,

·-
.:i 0

. -
t>o ,a � "
===v .:/ C::I

.,, i
E Ill

.. .,,
-- --
.. .
;.
".. .,, =
...
- - ·
N

' : ¢it;> 0 N
t• •&
- -

=��
I :<?-
.' ¢i<>: --
N

V � 0

ii" 0

:> . -
N

1-i l!J 0
.J
• ¢==::,
.,,
-
0
� • I I n n I

'
- - =
0
0 �

l� .!. N N N .,, 2 II 5l & !! I! � � �

J•i 1 C m u =�� " : - � .., a "' .. 0 C

SINGLE
REDUCED 16
MII.rSl'D-lOSE
.,. ..
i
-· ..
,! =: ==

. ="
:

.. ="'= "
��
..,.
a,
13
i
: = ::.,
.
C ;!I

!I
!
• == "'= ;: � :,
.. ..
. . -- --=,:-. --. .--
� C;!I
t"

.
i I::
M
l!
"' :
•• . . "
..,. -- .
C ;!I

-- = ,: �

.--·=" -- - === ,: ... " .


!l

-.;- - • . -. --
,! :<. !! r.
!!
• . -- --. - --. " -. == - - .• " •

'• -...
,! :,
,a

... . ..-- ..- . -• =- ="'= :; =·.


:,:

t • . -••.
9

" - . .. -· . " . =
"
:
..
• � ·-
..•• .... .... ---- ·=. " .= ..= :A
.• -. .
-=,:
--·- -·-. .- -. ... - -- -• -. " - . •• " •
,!

·-
C
0 !!
,!
: �
..·- -·-. -... ... - -- -- -. -. = •
:,

= ..= = ,: •.
,:
j
�i
•• . ¢::, .. ·-- . -. -. .. -. .. -
-- -- .. = -·
.: ;;

·-
,!
: �
. i
•• - . . . .... -- -". -..-- =- .- ==:::' " (
,! :. ;:;
j : (=i
0

·- ..-- -- .. 1
� � 0 - t:
,t
E !i ••. : . - -- -
- -. ·-
l

I
l!
i
-. .. ... -• -..
¢:, I

¢=, c;) - -
� �
! - • <--. -

i!
I
•. • - . . == =- r.:. .: ;;
I
.ji .iJ
..
� - -- - . .. - . ·= - =

...
• . ¢=,
.
0 0

1 - ••

I
i!

.·-- -• -. -... .. -. -- -. .. .= =- ,:. ¢::,


- = --. -.-
t
.•
0
I J
l
0

• •
: l

. . - . .. . - - - ... . -
i!
::I
¢::, c;)
i!
� � - -- - . . • - -
:,<:

• • . '
•'
- -. .- .. ... - .... .. --
9 i! :,

·- "•
• . ¢::, � .. ·- . 1
.... ..
,!
•'
.. . . . . - --
¢::, c;) ·- •. .- -- -.
• •
,: ! . ;
i


-. .. ... =
c;) • - ·-
., .
!
• • i:
!

.. ¢::, ¢::i !
!!

.·-- -... -- .. t
ii•
.. - . •l
·- .... , ... r
;: i! .i
: c;)
.
0
ll ¢=,
. (=i ·- ff�if
,!

I
-
: V �
.
ll•
..:. •
.• . <
,!

...• 11 !I I

,!
:iA•i! I
•..

:
i! .• . ¢=,
' I I I


!--. !ill
:
.. -· - = " = " , !! a !l � l! § .- :5 It �s ¢¢: i!

.. .. . . - - - - = �, a a !: !! i i! .. I !I Ii
• !! :, 29 ! ��

1i ll II A :; ;; ��

!J ! - J !J .,
1 . l ! i - l ' •. il
1 !l !l
l .1 •
l J .. ! 1 il ! J ! 1�! l
l
•I
:: �

1..!...1 i . = u = "' .. :., • . � � • , � :, =


DOUBLE
17 NORMAL
Mll-S'ID-lOSE

... : ,..-;. •
... ·" ===============::::i

..;_ �(;:::

"' ;
! ;. ·.:

=
"" �

.. - ...
=:-; ... - ,.� J


!i > ., ., "
M
"' � > = ., ... •
...
.. I .
.
s ! P. ... J

� ,
¼ -�
-"

..
:: �;:!: ::"; A
::I
>
t • • •

<! ... .
'-

• ¾

..
I:
-�
!

.. .- ..."' '=;:::;
. •
"
"'
I: e
• >. . ::: '"
·...-
I: ·'
T �• !

=:• -. =' ""' '


1'
� o-

'l '
=. ""'
'
l

. •
0
i
tl e�

-�..
"


} �

.ig
: :::
' ..
.= "'"
;

'

=•
;'} I

r . " = • �� ¢:,



... . = ""' 1
==> ·-
!


I: =,
= ;
• y
.
===:> •- • = -•·=�
,:: l t
=
,Q. !

,·, =
·-
'
;

c:==;> • "=
i-
�-
= , !
.' -·
., o- 0

t
V
..• �

.. =
,
- -- -� i II •
.
=
E

•= :i � f
0 �

..
� ;
:t ;
., . > ... I i•
.! •
>• f '
� �
1= 1; '1' l
,
I .
-
.. ;
l" f i
-
II:)

=
= = .,
� J � 'i =
n
;

i..i •0 ,! . I
..,J
II:)
• : V
◊◊• ,!

-oq::
f-. nt�
""
w - • -

-: � .,, .,, • ii
,.
1- �
.1 ,l
�J i! .)
} :>;
,. ; t.:.
= = • • , =

DOUBLE
TIGHTENED 18
�lOSE
... g . ..�
•I
"'
... � . . . ..
I.

! • . . . =• C,'
:
:A

•: . . -:
I
"" =• .,'
" " .'
:A
M
"' !!
., •: . . . -!I :s- -· !!

. . -- -" -=
!
..... e: ,
. I

--
= . -·-- -.-- .-=:s- • j
II.

- ·=
� !
. . .
'

1
,I!

. . . -. -- . - -: ..
.. --- . -·-- -- -- -s:-
I. II ::

a " . . . -- . .
J

. - -- .. -- -. -- -- -- "-
,I. A
.i
��- . .. -. -:: .• " '
J
i
. .. .. - - - -
:s "
::
.2
.. --. .--- -·-- -. -- .. -=·= . .

. f
... j . -
: ��
. - - -
•• -- . - - .
-- ---- -- -- ·=·= '!! = . 1
-- ••.. ---- .---
!: : j
I
l : : ¢ . ¢i � ••
: �
-=-= .. �j
.. --. ...
0 0

1
!

i :? : � . ¢:i � -- .. •• --
·- - - ..
- .
- - -. .- -- -- ..- . -=-=
� I •
i ...
., j
jI

.. �- i
•J

. - .. ...
.
,I!
I !!
!i :! : � . � ¢ ..
- . ..

. . - - - . -=
. - -.
- . .. .. (


a:

ct .. .,
I.

. 6. c;> -��-
I i

•• •: ·- .. . - . . - •.=
- - ---. ·=--... :: .-="
.l,j
I -
-..- .. -- -- .--. -.
J -l,
?!
: . :

) . . ¢:i s>
@♦ �
11
.. .--- .. -- -. .- .. -=
---- ..
L J

1 if
t !

---·
,i
I

. ¢:i
o-

...
s•
.
... . -- .. ·- .. - -
,l

". •
:
•• ·- .. -. -·

�J
o• I •
.;

.. --.-
-; • . . s> - - ....- - ... --- ..
¢::i c::!) t

It
'iJ
• .
..
I - 0
I

. • ¢::J. .. .- -- .·-- -- ... --- =1


!1�l
� }
� 00

.. J"
!I
ii
.. ••- - .. --

•2
a
= • ¢:i
•. . .... . i1
il
. . • ¢:i. q .. ..- -

-
I I I

I
,I

. . ¢:i. " . - . l. I lrl�


l'i

-.. •"
II ,I
: � J,1-!I�
. • .
0

. •
;
aJ l•
' ,!J51.!,;
" " . . ¢=i • • I I I I

- . -· -= ·=
}

:; " s !! &! � II
¢¢1 •· -
!11� A, �! �9
- - - - - - . - �: =• ss E� -- Ii
: II 11§

11 RR II Ii ll ll ;::; ;;:

i •1
!l J- 1.l ! l !·] !1 -J 1.l !l 11
(i .1
!] l]
- - ..
!l - .l � .l

!HJ • C ., .. • u • . • • L � •

DOUBLE
PriPft.l 1,rft
KtUUl..tU
19
-
er
MIL--S'ID-lOSE

"'
...
]
t ,•
.
M

...
a,

�i:.,;::iis=
3 •::.t:,'i:1:1H:
-:::-;;.,7;:-;,; :.:.1.::u1� i
•::i:.;in:;:i
••:IQl.::l"
--�:t,::;i;;
•:::,:.1;i111t:
!:�t;.t;S��
•:::::Jl(g:l
J
.•
-:.:::.2:;i,: •:.�13�::;�
!
• : t

• ,•
! 7

t t
... •-::::::.
..,.. ____ --•::::.;-;n P•-=���� .!'
-i ·••::::: ""•:==2==� -:2:-::2;11: I

..... _.., .....


a __ ... .,_!!= .... •-=:� --•:::::;,;:ri f
·- .. -..... ---- __ ..... -�= :
,'
. ---- ••
Il ,• -.,
..
==� -::::::
...

--s..
> -:::::: ..................... -..... -
,--1\
\
,
••
!

l
==;> ·::::::
I! �
i.
-00-Po .. W • •- ... -•.

"° � ,
l- •
, ,
!

. •
I!

• •,
; V

_..
-�
! "l
•,
; '

-..,'
I .
-
; .,

·- ,••
.... \
I I I I I I '

i .!,i1.!
I.: ' ..
P•"" ....... N N
-------
_______ ...,
i
;

MULiiPLE
NORMAL
20
... MII,-S'ID-105E

...
M
� ••
� �'
C,

'• '
� •'
!
•:

• ••• �
• " ,

•. :
-;

•.
C

� ••
•• """!==•�=.. .
•:t.11 ....... .
.. -::.n::�
!
I
•' ........ - =:: - l
•:!.A4::•
'
-··:::;
•i
··--::,:::n: '
•=:n��•
... •' --
-::::::

........
-==11.1a
-== == .. ·==-.r.=• .
-··::?:r.-, ¢:

.. -::Q::

•- •' ..
! -::: �.: !
...... -.
-·•1::::

·••: - - ... - -----


---::=::t: --::n=: .
: : -•-:::s:;"1 --:Evia: •·
1
........ =
...... - l!: :.
.
.. . ... . -- .... -- •• ·••1:=== ..
i

.- •' ..................
... - .. s . -!::e::r. •:t11c.=.•
o•••:::

............. ......... .. -----!::


!!
! •=et:4:.�

�• • .....
-::::A;;ol:

... .... .. .. ·-
::::::
I

. --- ... -.. ... �=


1 --••::: -••::::n --:!\1=-= i.
.......
.. . ...... .. . ... -..........
.......-... .- ------� --·-=== t
•..,.•..,••II · ••e:::

-!:::r.:.tl
...... .. ....... .. .
-•:::::.: •:?tllt�•

. • . ------ ...................... ..- ..··----· · ·-====


.; :
.. .. . -••::r.rJ ··-::1r:i::t:

.. - ....... - .. ........ - : .... - : =: -


�-:::::: -:.:::1t.:A
• •
..
I
. . ... - ........... ·----·: . . :: :::
I
r.G
"' •• '
� . .... ·- -- ............
···------- .. .... .......... . - - -...... .- .. . ·--·-===�
-- ....... ..........
-:..
:e
... ... -�=::.: ....�:::::�

-• • <
.;
• ==> . _____ ,.. ...-....... . . --.... ·---- - -· . � •- .......... �=
---• ... !!:

--. . ......··--- .. ... .. ... - .. -- ...


e ...
- ..... .-------
............. ... ...........
·-�::::::
I

. '. >
....


!
¢=== -·· .. - - .. ..
...
.... ... .......
... .. ... ... .
-...-
,

> . . -... -- ---


I

) .
.. . ..
I
• • I
� I c:: ···--··
.......
...........

........... .... ........- ...


=-->
,
I . -.•
e. '
l
I . < I I � . . ....... ..... .. ................
..
. <
,

� •
I � · ••·---
;
.. •• . . < .,
. .
:::::J

. •
P1• -:: 1 '�!:r, 'l!OU -•H�HJ �11:l';H Alia;;! -�:��n. H�BSH
- .................. .u;;;u
... l . I

11 !::r:.r�::�:r �,,,:,,, illiiii !!!!2���:.: 1. H HJ. J. =•=:;11:;::;


-
l 'l .... d .l
l 1 �• " l l lj•,i !lll!ll !li!!H! !J!l!l!
l
,l1i,1i !}liid
.
:!J .. j, !J .. __ .,,
tn1 . ..
- _,.,a,I

� • , a

MULTIPLE
. NORMAL
21
.,. MIL-S'ID-lOSE
"'
.,.

M
"'
•:: ' ' '
.
••
••: ...�::::::::ss
•:::�,:u;::i
-•::uu;ti
•�,::::e::t: ,
::.::;;:=.�:
... !!::::eis"J •
! ••=�:2n •==n�c::i • !
�- ••

•::::su:�� _. t

---=�s:n:;� "
.' l•
J

= •• -.------�
,._ .. .,..., __ ----·==
--•:::::: 1
1
••:
... ... - .... -- ... "'. - - .. !!:
�I
.. ..,,._,.. .. .,, --· ===-
••
.
.
. ... .................. .............. ... ... ..... ____ ........... : 1

., •:: . •. • .................. ........ - - ......


.. ..... __ .. ..____
I

•• • ..... .., ............,..,


..
• •
l
•• . .•
•• ..
•• .•

••
•• ..
• .
•• •
0

:
.
•'

0

..
l
: •
"• •
111111

-------
.....................
·',­
1 -,11 ..1-=--=-l -,i'l1'.=:-=.! -,1,·,
.: .,.. -=... ._Ji �... .,- '• ,:_ ,... ......
.• 1 .1,·1.,1 -•
,:_.,,
· ·1·
!Ji ... ';;; :. ,• ...... ,; .... ,
-
' ... ... ., ,
f .. ..
'-
": • • ... .i::::: . t _; .:: ::

= •
MULTIPLE
TIGHTENED
Milr-S'ID-lOSE
.,.
"'
.,.
]
,., • ..
"'
.,.
I
''
:
.
••
� '
.. -
..... § a
' .
.
z
•:
: .
!
•• .
!
•• .
• ..
-- •• .
·- i
•• .
• •:::cc�: ..
•••
I

t 1
-•::;:;;::.

i
-- : ....--·===-::.
-==== •t::,u::1t:::
••t::i:::RA
-•::a::. .

-! --
I
!
•:
•: ----·-·
........
--•==ai... •=:c.:i.=
-------
••=�::IC

... ·-·-·== .. ..... -�=.i--- .


-•::n;;A
. •
• '
·---·-· • 1
' --
••:::: :: !
•• .....·---- ---
......... ---==== ·::1,u;�� .
� ....... !!::;::: -•:::a;Q

·------·
------1
----•::=
••::;::2A

... . ...... ... ...


iJ
-.
...... -......... -�----- - - ==--
··----- ·· --·· ·------ -----·� ---2=== -...
·--11::=

___ ........... .....-.......... ............. ----·==


-•:.!:ACtz -i
;
• ... __ j
.-•r fi
"
'
,--·:i ..;

•• . ------ ·...... ·------ ...·------


(
-•::c;:;A I

..... .................
J:

- -----
·-•::.::: ••;::::.ii;;:

.............
-.; .....1 .......
:I
•. ) ........... ···---- ------- ·------ ---••:::
•• q
•·-e::i: -•::=::;:.a
-----•.1: ..................
·-·••:::

-
••:::::a.:

............ ...---
I

•' ------ ........___.................


I .

". ··-------
I
H
. .................
··-·--... ................. •r
---:::;:

____ ..,,.._. ---·•=:


·•:: ·-�:::::: 'i
•• .......... �... ----= l
. . ···---. .._____
•1
.". ___ ....... ._ ............ 1·_,"!'l
............... ______ .,..., --------
. •: . ....... ..·---- -·...
.,._ J�

•••
� . _____ ... ___
. ····---. .............
................ ........... . l�j"J•
• I
.
.,. Is
. . ''

111iihl}1tl
i

.I
.
.
. ..... ---
. -------
• . ··••---
fl

!

•• .
.
. ·-·----
.s
ii
••
. .
. ..
�:!!i!
. •
. I III I I

M'!!f.,._ -
,uun :nsnn
--rv- - - -
P1•
I.- ,! • I
=�ar,:i:1;-
---A S!!IZH 8 !!5VU �2s,s21; IUI��! llH�HB

11 QtUUUHrt:I ,:u1,,,s 911:UIIII !:!!!:5!:95 UUUD .....................


=====.::.;;: �UUH ,nnu
l !l!HH
1 • •
.!J111
11 1 ...111 i;1i
, ........
. , .. ...... , •
�, ...i 1 l1. ul ..i1J 1t•�i
... ii ..1 J J1..........
,1r·--�1 i 1J........
� .. ?.i.a !l .. 1�..i.a ,,.,J
i.ta.i!

1 ' .. .
1
... i: .. l
•11 J . 0 •
MULTIPLE
TIGHTENED
23
=�
,c;-­ TAllLE IV-C-Mul1ipl'e samptfo,g plans j'or red11ced inspectwn (Mast1� table)
m ::5�
·o c:

-...... . - ......... -,....


C: .--
n (see 4.9.3 and 4.9.4)

·- . .... .. ."" ... ....,. . . .. .. ,,..,..........."' ... ..".. . ".. " ...... ..".. .. .. . ".. ..".. "'.."" .. .."' ..... ."' .,,,......."' .,. ....... .,....
m -,:,
0 r--
n, lrcoo,,...• 0-•l�IJ �••I• I...,_.., l,..,"11.. 1 t
C-·

..... 11110

,
UIS

,
O II

.-
o.n
,,. n.
II

, '
. . . . .. . ..
jR
.... 11,.l• 11, ... b flu



I

.n. .n.
11 "tr - - - -. - - - - -. - • > . -0
-0-
.£l.

- - - -. • •-• •- '- - - -
� -0-

.
D
"()'- ..[!,

1]
.
.
I• ,._
i]'- ..0,.
, ��.. 1 I I

' • ' '. '' • • ' ' •' ' '• • • • • I I ) l I •

'• ' ' •• :'


'"" I

'
) I S I I 1 I

.,_,.,.. '
1 1 I I I II

--·""'""'' '.
'

1 I , J to II I II
I

,.
It

' ' ' '.


• •
"
) 0 I J I I II 1 tJ II II

11.1
...... ; I ', 111111111111111 I II I I I I II I ·. I◊I o H' ':. ':I :.. j' : .,j'' : ;• ::I, '':I ,•' :I' ,;-I• 11 I 111111111 111111
I

"
I II I I I , 1 n 10 IS II

I • c;-1
I I I 1 9 II IJ n "
C t'lnl ) I I I • • 0 I
'
,_, ' " ;
) I ) I I I I
r,;., l

' ' •• ' ' ' '


' '" I I I I I I I I I 11

'. 1f . ' ' . • ' . "' "' •


) II ) I I J ID I II
··,r,,
..... ' ' • I I I II 1 IJ II 11

.
\,11, II I I I I J II ID U " JO

i
)

. ' ' •' '' • ' "'' ' . ' : .


'
" ,. ....
\,. JI I I I u n II D

---· '
)

...... ' """


I I I ) ) O I

"'
I I I I I I
,_,
) )
I ) I I 0 • II

' " , ' ''


..Ji ''
I ) I I J I I IS

""·
)

' ' '


.
nr,•

.
I I I I II I II II II

........ " '"


..
JO I I 1 II It IS II JO


I f
" 1

' '
....... ''' ..,,•" . '
I I I I I I II IJ If II 11
• '
,·- ' ' •'' ' ' "' ' '
I r,,., I I 0 I
' ' '
)
� I ) I I I )

,..., ' ..
I I I I I 'l • II

.. 1f Ji

."
0 I I I I I 11 Ill

• '
)
I

t
1,11• 0 ) I I ) I II I II II 11

' '
. . . .
0 ) I I I 1 1: " 15 II ,o

. .
.,_._,L I C ) I I I i, ll \l 11 ;::

' ...... . '. ' '. • ' ' • ' • '


• • ' ' ' ". "' ' "
n",

IJ II


I I ) ) I I 0 I

,,,_,.
IJ I J 0 I I I I ' I I l o
'
"
........, " " .
IJ �
• I I o II

-� Ji ' • '' • • . "


11,i,1 ) ) .

•' l 0 I I I I I I II

..
)
IJ II J 0 .• I 'I ) 11 11

1-Hol• "
IJ
It
" <. , -1.. I
J
J
I I I
I I
I )
I I IO
I 11 ID 15 II �
IJ u II :!

-0, • u.. r,,. ,....,., ,1,. 1,,i... -•I"''"• •••..••I• J ,.w, • f•U..i-, ....,, •"-• •.,. .....,t • ._.. si1• _.1., • •-""• '- • ..._.. 1i• . ._ 1•,-- 1.-,,.c,_.,
-0- - ,,.. � ......... ;,........ -·
h ::I ... ..,._.,,_....
Ito - ... ..,,_ _...
i,.. .._.,......, 1l•rl• ...,.., ,fn l•••l--'l-ly, •• •.l1il'lo ....,L-, ,..., ""'-· ...._ ••oil.W,I.
ll• ,.._._._, ....,., n-.,lo•1 ,-1-■ to• ,r,,,,..,1 .. 1,, , .. -111,., ...................... , •"''" •••hWd.
•H ... •••- ........11-•11oi10••••0>•,

t .. 11 . ...,.. ,. h.i •�•-'- .... '""" .......,uoo� ...... "°'�, r... ••�"""....," �.. - _..., ....w.•u.. ,.., ... i.., ..,...... __.I•-•*�- ,.10.r.,f}
..,.
"' ; � . MII.r-SIO-lOSE
..,.
..
: '
c
� :
M
"'
§ • ..
,I

i
..

..,. II :
!!
c
= .. ..
2

i 1

li
!! :
,. ,! .
• ..
:
t c

., . !
" •: ..
:,
i

·-
l


I:: j
,! . l
: .•• I
.
·- - • - ... - - =: = 1•
� �

-- : ...--------
� ::e::AD

� .... ==== ·---=== ••:::::AS:

- : __ ............ ...
,! I
I

.... - • =.: = ..
! ;
i ·••!!:::: ••:::o:AQ l I

- -___....... -___.. = ....._ •........s:...::.:


-•:::::::.
i !!

.
__ ..,..,..,!::

-.. ·.::
N

-,.._. ....·- ._...... -·-=== .


.. . .. -
... --::::::c:: ••::::i::AR
,!
;
... �
......
- �: ..... .......... ···•===
-

:!, __ ...... -:-�=


,,. .... :::::=::
.,.
I
............. ---... -== . ..... --- <
0

;) � 1 _ .. ...... - - ... -
••=�::AD jI • l
,. • .......···---
.......... ...............
::
·••s:::: ........ ====
..
0
; Jr
I

........... . ---·-· -----!!!: ----===


5 �

... .. - - . �
1..
::: ••:::?:RA
,! ..... -- - - !!!
l
..... "" ........... .... .......... ............. -. ..........
.................
J
s • . .. -·====
.. ··-- ..
:, •I
0

• .. ···•-- ... ......... -- -·------


. . ... .. ..........
- C)

·-.,,, .....
·••!!!:�:
•- -•-e= i ,!
.. ..

., •• . ------ . ····-- . ••- ..... - ............. ......... .,. ....


.... --···---
\..)

.
-- .................. .i •
0

......... -•-e::::
i
...... - - - ... - -- - _.,. ....... - . ... ·---
·----•!
�;
0

" • ,! ..................
) ------ ·-·---- - . . ··- _.,. .... _ ....... ...-...... -.
!t
:L
.i
l
0

" �• ( ......·····-
.. .. - ...... ...... - - -
. . ···-- ............ ..... .............
...... .... ...···-- - ............ =' li 1I
l• I• 0 •

·- ...... . . .. ... . ·- i1 = t
)
.. ................... ... ... ..... -
I I

. ···•-- ......-·••--
,;
l . .

i • . . ··•--
-< 0

ll • al
. (
..............
. . ·····- ... -····-- ........... ...
....... il ��
: I : }

..............
,,
.
I I I •

·•·- 1. 1'.1i 1•••


� 1
ll =
0

I . . �j
-
� .
,!
(
.. .
I I •o
I l:
�!= �==
0

• .
• 11
l .!• S-'I.,!
..-:i:•
.• .
0

d
ll


( I
I I I I I I

¢¢�, .•
i !i: 11'11111!!!!! ��•!!!:5 ll!!!!!!!U� II !l!!l§!j !H�Ci;�; i!§§���,
� ! -.
., .!

,.l!. lllllllURII iuuu:::::u:r llllllllllllll 111111111111 :::::!:SES :�§l!l!�A


i 1
11.,l • • ,1,1-·i
; 1 11·•=
..1 J ... �r,,.;J.I !J:.:.;!,Li !JE .. �.i.i � ' !1,. ___i� JI,d !lll�li ! 1
Jii!l
.. .. ..
J .: ; - lo.:.: .1J

1111 • • •
MULTIPLE
REDUCED
25
z
00
)> TABLE V-A-Average Or1tgoing Qr1ality Limit Factors for Normal Inspection (Single sampling) •
::OD
3: ,­ (see 3. 3)
)>
Acceptable Qu11i17 LeHI
Code s.mp-1.1!
Lener Size
0.010 0.015 0.025 lo.010 0.065 0.10 0.15 0.25 0.10 0.65 1.0 I. S 2.5 1.0 6.5 10 IS 25 10 65 100 150 250 400 650 1000

A 2 18 12 69 97 160 220 330 170 7:11 1100


D 3 12 28 16 65 110 150 220 310 190 731 1100
C s 7.1 17 'l1 39 63 90 130 190 290 Ul �
"'
"' I--

D a 1.6 II 17 21 10 56 82 131 180 'l10 110

E 13 2.8 6.5 II IS 24 ll so 72 110 170 250


0
F 20 1.8 ,.2 6.9 9.1 16 22 ]J 17 73 I.Jo

.__
t,1

G 32 I. 2 2.6 I.J 6.1 9.9 14 21 29 16

H so 0.71 1.7 2.7 J.9 6.3 9.0 13 19 29

J 00
-
0.16 I.I 1.7 2.1 ,.o 5.6 8.2 12 18

K 125 0.29 0.67 l.l l.6 2.5 J.6 5.2 7.5 12

L
M
200
JIS 0.12
'-
0.18
0.27
0.12 0.69 0.97 1.6
0.0 0.62 1.00 1.1
2.2
2.1
J.J
J.O
1.7
1.7
7.J
.
N 500 0.071 0.17 0.27 0.39 0.6J 0.90 I.J 1.9 2.9

p 800 O.N6 0.11 0.17 0.21 o.w 0.56 0.82 1.2 1.8

1250 0.029 0.067 0.11 0.16 0.25 0.36 0.52 0.7: 1.2
Q

R 2000 O.Ot2 0.069 0.097 0.16 0.22 0.33 0.17 0.73

• No1e1 r.. th■ uecl AOOL..... u .. ....... mHI ••••111,11.,11 ., ( I • £..1.,


s...611d1
,t. •lH )
11■-
KIL-S'l'D-lOSE

.....,.
!J ll !J �
I 1a1 11
IIEII !II
!!UI !!
-::
!l

II
= === :s::i
-
••
.I II •

II IIQ llll ■ II A

,�-�-
:: =
!I -.. • •

•., = . ., -:
.... -
••
l : ., .
f •.. ,.;:

1 =
J;

-......
:!
-i
:I

. £

-•- -.. s. -s
I
- s:
=..
.1

=- - -
0

:II :II I
..
• !I
•••
a II ;
••
..
II •..
.. ••• ..
--
:,

..
:: t: 'JI

..
!I •
u•
" ! ••
.. - :,

- .!
! ..I•

g
••• •=• :iaa !!11£ Ill@

31 .. R

AOQL
27 TIGHTENED
- r-
!=> 0 TABLE VI-A-Limiting Quality (in percent defective) /or which Pa = IO Percent

,o 0
(for Normal lnspectior,, Single sampling)
O'- "T1
m (see 4 .11)
,...,
m
-4 Acceptoble Quality Level
<
Code Sample
leuer size
m
V,
0.0IO 0.015 0.025 0.040 0.065 O.IO 0.15 0.25 0.40 0.65 1.0 1.5 2.5 4.0 6.5 10

A 2 68
D 3 54
C s 37 58

D
E 13
8
16
25 " 54 ....,...:.:
27 36 44
F 20 II 18 25 30 42
N
00

G 32 6.9 12 16 20 27
,.,,0
34
JI so 4.5 7.6 JO 13 18 22 29
J RO 2.8 4.8 6.5 8.2 11 14 19 24
K 125 1.8 3.1 4.3 5.4 7.4 9.4 12 16 23
L 200 1.2 2.0 2.7 3.3 4.6 5.9 7.7 IO 14
It 315 0.73 1.2 1.7 2.1 2.9 3.7 4.9 6.4 9.0

N 500 0.46 0.78 I.I 1.3 1.9 2.4 3.1 4.0 5.6
I' 800 0.29 0.49 0.67 0.84 1.2 1.5 1.9 2.5 3.5
I,) 1250 0.18 0.JI 0.4J 0.53 0.74 0.94 1.2 1.6 2.3

II 2000 0.20 0.27 0.33 0.46 0.59 0.77 1.0 1.4


TABLE Vl-8-Limitiug Q1111/ity (in defects per lnmdred units) for which P0 = JO Perce11t
(for Normal lmpection, Si11gle sampli11g)
(see 4,11)

.
.\ccrpuLlt> C,,-•li•r Lurt
Cod• S.-,le
!�H� !!!!
I0.040 250 400 650 1000
.

0,065 0.10 0 15 0.75 0.10 D.65 1.0 1.5 2.5 1.0 6.5 10 15 25 40 65 100 150
0.010 0.015 0,025

120 200 270 JlO l60 S90 770 1000 1400 19\IO
A 2

..
u 3 77 IJO IIO 220 310 390 510 670 910 IJOO 1800

C 5
- 18 110 IJO 190 240 JID 400 SW 710 1100

..
a 29 49 61 B4 120 150 190 Z50 350 480 610
D
18 JO SI II 91 120 160 220 JOO 410
F. 13
r 20
-
12 20 21 lJ 46 S9 11 100 140

l.2 12 ·11 21 29 JI 18 6J 88
G )1
so 1.6 7.B II 13 19 21 31 40 56

-
II
I IO 2.9 u 6.7 8.1 12 15 19 25 JS

...
ID
K
L
125
200 1.2
I.B
2.0
3.1
2.7
0
J.3
5.1
u
7.4
5.9
9,1
1.1 10
12 16
I&
23
....0
� Jl5 0.JJ 1.2 I.I 2.1 u J.J u 6.4 9.0

� 500 0.46
I-
0.1B I.I 1.3 1.9 2.4 J.I "° 5.6

I' 800 0.29 0 49 0,67 0.84 1.2 1.5 1.9 2.5 J.5

V 1250 0.18 0,31 00 0.SJ 0,14 0.94 1.2 1.6 2.J

. H i!w G,20 G.7i G.33 G.'6 G.S9


...
u.u i.G i.1

_. ,-
o0
'#.-m
"Tl

(""'\
-4
TABLE V/1-A-umiting Quality (in percent defective) for whieh P0 .,. 5 Percent
V, ...
. 0 (for Normal Inspection, Single sampling) (see 4.11)
0
,o-
0'- 0
m
-., Acceptable Quality Level

-
Code Sample
letter $ite
0.015 0.025 0.040 0.06.5 O.IO 0.15 0.25 0.40 0.6.5 1.0 1.5 2.5 ,.o 6.5 10
0.010

78
A 2
63
B 3
45 66
C 5

...
31 47 60
D 8
:..:
21 32 41 50 ,...
E 13

-"'
14 22 28 34 46
F 20
'"' 14 18 23 30 37
0
G 32
8.9
2� 25 32
"'
5.8 9.1 12 15
H 50
9.4 13 16 20 26
3.7 5.e 7.7
J 80
3.8 5.0 6.2 8.4 11 14 18 24
2.4
K 125
6.6 8.5 II IS
1.5 2.4 3.2 3.9 5.3
L 200 9.6
1.5 2.0 2.5 3.3 4.2 5.4 7.0
0.95
M 315
1.6 2.1 2.6 3.4 4.4 6.1
0,60 0.95 1.3
N 500
0,79 0.97 1.3 I.6 2.1 2.7 3.8
0.38 0.59
p 800
,a 0.84 !.! !.4 !.B 2.4
Q '"""
•-ft ft ft•
u. .e;•
n
u,..,u
n �n
u.-.,u 0.62

0.32 0.39 0.53 0.66 0.85 I.I J.5


R 2000 0.24
TABLE Vll-8-Umiting Quality (i11 defects per hu11dred units) for whicb Pa =5 Percent
(for Normal Inspection, Sitigle sampling)
(see 4 .11 l

Aetf1Jtabl, Q.1lily Ln,I


Code S1aple
l,uer tlu
0.010 0.015 0.025 0.010 0.065 0.10 0,15 0.25 0.10 0.65 1.0 l.S 2.5 1.0 6.5 10 IS 25 10 65 100 150 Z50 400 650 IIXX>

A 2 ISO· 210 320 390 S30 6611 B50 1100 1500 2l)IJO

3SO uo

B 3 100 160 210 260 510 7JO 1000 1100 1900
C

D
5

8 31
---
611

59
95

19
130

97
160

130
210

160
260

110
J40

210 380
610

510
810 1100

710
E 13 23 37 '8 60 81 100 130 110 230 310 uo
...
C
20

32 9.1
-15

15
21

2D
32

Zt
39

33
SJ

41
66

53
BS

68
110

95
150

II 50 6.0 9.5 IJ 16 21 Z6 3' u 61


I 80 3.B u 7,9 9.7 ll 16 21 Zl 38
I-

w K IZS 2.1 u 5.0 6.2 8.1 II II IB 24


.... L 200 1.5 2.1 3.2 3.9 5.3 6.6 8.5 II 15
II

N
315

500 0.60
---
0.95 1.5

0.95 1.3
2.0

1.6
2.5

2.1
].J

2.6
1,2

u u
5.1 7.0

6.1
9.6

p 800 O.JB 0.59 0.79 0.97 I.J 1.6 2.1 2.7 J.8
Q IZSO 0.21 0.38 0.50 0.6i 0.114 I.I I.I 1.8 2.1

I• 2l)IJO 0.21 0.32 0.39 O.SJ 0.66 0.115 I.I 1.5

?fl.
V, ,-
D

...,
m
m
("'\
-4
V\
MIL-S'ID-lOSE

I ;; lo
§ =., !: iii
2� - i: !
- ii -
§

ll ,. ;

� A "I ; !l i:: -

-
- I.

= :z
-
:::: 8

.-�
§

--= = - s - ;;
� :, R N N

·­- --
N
9

= s
-- -
l<l
N
¥19 � ;;
"
--: =
:, ::i !l
:;: !i
"-
0
s;

" 8 :z

- - = :::
.

' -
0 0 N

., . 0 0 N
IQ :"
'i - ..
0 0 0 N . •== 9 :z -
-

--= ="
&
" � ...
---
f lil
0 0 N

- -- " ;
,; 2

.. . 0 0
:, :::: �

... .. - -:" :z "


-
0 0 0 N
9

::: ... ... 0 0 N - :: IQ::: : "' l!


... ... . -• ==" -
0

- -= w-
8 0 0 N

"! ... ... ..


... ... - - - :::
0 0 N
;:; N

...
0

,; 0 0
:, "I

.. . . ... ... . - - :: =
... ... - -
0 0 N

i ... ..
--
0 ON

! ... ... ... ...


-
0 0 N

.. ... ... ... .


0

...
o_ 0 0 N

... ... ... ..


0

;; 0

... ...
0

... ... ...


0

.
0 0
0

! 1� i !S !E . !"� :-- (
.
!E
It :� ;:; � ( ( =!E ,;
-I • .J
• I'•
z• l
•-J
ll � Iii il 15 I! !! I!!;i �� "
Iii
�� � I�
LIMIT
NUMBERS 32
MIL-STD-lOSE

-.,. -
"
:, ll

.
N
N
A

"
.,

"
0 0

...

;:
"
!:.. " �

.',:-
- II

=
s 0 0 0

.......:: =
.. - i-
9
� -� " ..,
-a -
" I = ii
I
"

t-
:: �
��
.:: - j
i-
A
� "
�� " �

A
•C
... -"
A
"
;: � C
::,
C

� -�
0 0
-:::
::i

...:: �::
.. ..
i� =
E E "
"� .....
� Q

0
,__.,_.,_L---1-_J 0


I :

-

.. " .

.. "" -l• i• l
I.ti
"
l
i ; .:
• ••
I •

iii5, 1
..J


l
!I

·­
f,.. "
-• -• .., ill ..

---• • "'=•
C
C
Ji
': �
Ji

C
� � �

.!!
A
a
C "'
AVERAGE
33 SAMPLE SIZE
> TABLE X-A-Tables for sample size code letter: ,1

l'I U l"\T llf I.IIT!'o


CHART A • IJ'[RATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING PLANS
I \l't cn.n TO Ill

-�[IDllJJtilllt�-
IC:1"t1 lot do.bl, aid 11uhiplr 1■-1plin,.. •� ••tchrd II dotrly "pnclinbl�I

mN.. -
""
,1.cu-rr.o '"•'

.... 111�,� \,I\JN.Jh, Ji.


I l'l. I F",d I I I-
1' �+-l+ 1-t+ H-+-1 •t--t-, -,- I --1-1-1-1--1-1-1--1-,-

r1;1
., :j : I . 1· : I I I r--' . . .,.:.j� -l+H-1-+l I I I I I I 1-1

.
:0
I ' -1' _,__

.. �•·· ' ' ,,, - ' �-- �


- ...�-
I : I
. . _ _

,:H'�

'I
. , l::t:
-
; I I , 1 -, : • - • • • __ • •_ _ �
� ' .
. . . --. .

I ,.;
. -- "
, . I . I ..
- -- - - · ';llttLtt!..t:l
. .. . . · · - I
_ __ -···
_
.., B
• • 1
.... H
• ,I•
I UIJ1·j I 1 "°, I

, ... ....
"' N-.1.IJ.Ll:.LL: _, H- .1-1 ...... H-
i .1- rt+.+..L.JJ=._
..., om ,.. ,., 400 !.OD IOQ HIii 10C1 ll;IQ 1101 IIIXI Uno
U1'/ll,II \ IIF �1 111111 rl'Ell l,flTS Ip. i" rttrrnl d,.frr1i"" !,., -\l)l.'1 � 10: i11 drfrc11 ,..., hun,f,..,I uni1t for .\Ul.'1
ltm tom 1-.00 IIOO
> 10}
, .. ...
..... , n,-•• - c••··.,. ,-, ...... u. 0,.,11,, I ••••• 4l(M.'•I 1.. ·-' , .. ,...,,...

TABLE X·A·I TABULATED VALUES FOR OPERATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING PLANS

"· . ••
-'cctftl■hl"' 01111hr 1.,..,rh l1t<>rm1I ioP"l"li!tlll

X X ,oo X X

"'
_, ,5 25 65 100 150 :;!'.',O 650 1000

.,,
p lin rcrc,nt d.. rtcti•rl p On ,1,-fM'.n rwr hund�d •ni11)

,,.
.. ' m m
... 0 O.SDI O.!,OJ 7.4,1 ,1-2 19 ] 115 175 J05 517 R59 977

,._' ,,.
,so 2.53 2.56 17.8 68] Ill 199 2J5 ]OIi ]81 4'2 145 9'15 1122

"'
900 5.IJ 5.21 2"-6 55 I 91 .� 158 2JJ 212 351 '32 515 613' 812 107] 121)6
75 0 IJ.I '" 4R.I 127 211 ]42 "' 521 612 795 9!1 J:'14 135<

'"
. . .
...,
'>O 0 "J Jl.7 OJ 9 11, :\BJ ,IJJ 5Jl 6]) 7]] •ll IORJ 1.1111 15.ll

250

100
50.D
"'
69.l IJi
'"
2.17
190\

266
]15 ""
lJ4... ""
2S.i J1I

526 657
540

,so
722
6SI

...
770
m
761

'"'
,...
170
1006
IDOi

12J8
IJJj
....
12,e

. 1512
15611
1748
1862
1728
1q16
20]5
5.0 77.6 150
m
"
Io, 90.0 !JD ,10 502 6S5 ,oo 870 1007 1141 1272 1529 1718 20ll8 WO

X X 65 100 150 X 250 X ,oo X 650 X 1000 X


. Arrf'r1•bl" t,)ulhy 1,,-• .,.h hi1t.1 .... ,d lnl""'clinnt

11•., .......1 "-u..&- __, ._ ,__ 6.1_1._ .......•-I P•- ho .. ,.,...,-, ...... •I•••
MIL-S'ID-105E

. ..
. • 1·
I.!: •
u- -
N

;::;
X
-

X
-

§ ;;

X •
,c
!I = •
X
X !!
.. = X
••

! X , •..

.
lt��!!!Jl��•i�-l=�=- .,�=t==���-==� =
j X -.
:a • - == =====;·_========1�:�
.ia.s±
..•• .. ±t�=;==�:a
,l!
2 � !J �
I ,l! �
,..
• N

- .. ' a
!
153 ..


I
:::, 1. a ;

1!
• : I:

!• 1•
.. :
,l!
:5 u

X ; -
• •
:5 ]] .. i=
! :

. X .. I :
-:

;
.§• .::E•

• -•.
0

=• - - � I
I ..:
t> t> t>
J ii.i11
-!!

. ·1�
.,

�• .:11: .

-
u-• •
:
••I.! -• : ;•.I �
c
j
: f E �: ,.

.. .
;;:.!:� :,
• 1,1 ·-

.. .

• • • • •
"l-a
-a .I :

35
A
CCI TABLE X-B-Tables fo,, sample size code letter: B

CHART B • <P£RATING CHARACTERISTIC CURVES FOR SINGL£ SAMPLING PIANS


(Corn■ Jor do.tilt md ■1hlpl1 1uipll11 are •111chd u dotelJ u pHCliceble)
��_B'�

..•
ACccnr.01 ... 1
1•
- -
.

,.
..•

"
" •• • " .. •"
� -u, .. .,. " '
1...

..
-
-

w
en
• ,.,

...
I
.. .,. .. .., ... .. .. ·-
11

""
t
1 ..
I
, ...
QUALITY Of' SUBMITTF.O I.OTS (p, I� Pf'f'Cll'III ddPCtin fm AQI.', 10: 111 drf«i, ptr h,ridrcd -■It■ far AQL'•
,.,. ·- >,.. ID)
, ...
I I
'
·- 1•

...... n..,.. - ·- - "-.,. ..... Oo•ll•r �.. IAQl.'•I ,__, ...,_......


....
0
TABULAT£D VALUES FOR <PERATING CHARACT£RISTIC CURVES FOR SINGU SAMPLING PLANS U1
TAUL£ X·0-1

.. ...
Ac:ci:pt■blt Qu•lilJ L1ul1 (1-■l ln1ptt1loe)

r, ,.o ,.o IS 25 65 100 X 150- X 250 X X 650 X 1000

"' m
p fl■ pe,'Cf'II dtfN:1h·1d p (11 ilef�11 pn �Hdrt-d ahtl

99.0 0.ll4
1. 10
O.JJS
I.II
,.,n
11.9
U.5

,..,
!7,J
27.4
45.5
59.5
17.l
9'.9
Ill
111
157
159
206
'"
m
,OJ
256 !OIi ...
·419 511
663 "'
651
1065
947 1029
1152

...
'5.0

..., ,,. ,., '" ... ""


,00 l.45 J.51 11.1 511.2 11)5 155 Ill 2JI 2M 4S6 SU 716 804 1131 1222

''" m , ...
150 9.14 9.59 32.0 57.6 141 199 5JO 62J ,OJ 1249

..., ,...
500 20.6 2J.I 55.9 119.1 122 189 256 2119. JS6 422 722 922 1022 u•9

,,.,
'" ,.,
..."' .... "'...
JI 0 46.2 Ill 170 247 J2J 36<> UI 507 SRO 121 Rl2 104! 1152 ISJ9
.,.
25 0

..., '"
10.0 Sl.6 76.11 1.10 177 l92 OJ Sil 671 1165 1271 IW

,,.
,..,
5.0 63.2 1511 2!0 251 150 565 IJ/J I ... 1241 1]56 171] I"'

1.0 71.5 154 221 2'0 m Ill SJ] SRO 611 761 1019 IIIS IJ92 15IJ 19�1

6.5 ,., 25 ,o 65 100 X I'° X 250 X 400 X 450 X 1000 X


Acnpt•ble OnlhJ Lr-"I• hi1h1�11NI iu�ctiMI

.... , fll-lal il.ut... l.. -4 f• ,-e•_, hlHtlH H•,...M'- J"•i.- r., .. ,................11•.

!
TABLE X·B·2 • SAMPLING PLANS FOR SAMPLE SIZE CODE LffiER: B

Attrpubf,. QulitJ l.n•I• (a-•I la1pe-c1i-J


c•••. r_....
r,..o1 l•tiu Lt-otbu
,.o X ,o 65 X 150 X :50 X ,oo X 650 X 1000
hli•e

....., .__.
uapli•11 6.5 10 15 25 100
u,nplt ,o 1asiple
•h• ,he
Ac 11, Ac He Ac Re Ac ftf' -'r lie Ac lie Ac 01! Ac Re Ac llr; Ac R Ac Oe Ac tt.. A.c n,. Ac Re Ac II, Ac lh: Ar. Rt: ,c Rr Ac Rt .\c Rr

si.,,.. 3 " 0 I I 2 2 3 3 ' 5 6 1 I B 9 10 II 12 13 U 15 he 19 21 22 27 28 30 31 II 42 �. '5 3

u.. u.. u..


. ... . . .. . I 4 . ,. . . .
• J ' 5 6 10 7 II 9 U .. 16 IS 20 1122 2J 29 25 J;
'
Q
V

''
Nd,

'
J J
cw,. <ode
V V

lloabl, l•ue, Ltue, Leuer


I 2 J 5 6 1 8 9 II 12 12 13 15 16 IB 19 i3 2, 26 27 3< 35 37 38 52 SJ 56 57

A II C

� I I I I I I I I I I I I I I I I I I I I I I I I;
llfuhiple 'ii . -++ -++ - +► -++ .... ++ ..... .... ... ++ ..... .... ..... ++ '

Lr.111bH
65 6.5 X 10 15' 25 ,o 65 100 X 150 X 250 >< >< <00 650 >< 1000 X
Accrp41bh: ()inlitp l.f'••h ltij\htuird l■tpl"ctlo•I

v
•c
lie
..=
=
Uu M'ii n:h1!i'f1•"'" U"'f"i" ,i,,. cod• ieurr iot •itich 1ccrpt11tct ud 19!jt:ctiun 11umi,Prs ,,.. auihbie,
,cc"P"tte" 91Ull\fwr
ll,j,.c1in• ••...t.,.,

ca - =
=
1:u sin-:1" ""'l'i•• ,,1 .., 11,rn,, (tr 11ttrul1"11111 COO. t,n,r l)
I:,, dnut,lt um,.lin• plu 11.n•• (tr ,1t.,Nth11,. IIH Codi htttr O)
I'"'"'\ TABLE X-C-TableJ for Jample Jize code letter: C

CHART C • a>ERATING CHARACITRISTIC CURVES FOR SINGLE SAMPLING PLANS


(C-• for dolblr ind 1111lt!plr 11mplln1 In! 11111r:bd II clu1d7 u pnctle1bfrJ
PUCll'fT or LOTS
�\��18� Urt:Clto TO 9£
,.,
....
ACClPTtD IP .1
'"'
ACttnl:D lf'11

..
>-t-
'� ,.

....
,. - . H·+-t+

" I I I I I I I I H-t-i\t+H

.."' ,. I I I I I I I I IIH+t+l+H I 11 I I I 1\1 I I I I I I 11 I N I I I I I I I I I I I I

.. , I I ltmra�
'
- -.
.. I
H II 1111 I\
� t-+f--H �-•- H·H, 1+1-1 H-H-1-H+'l+H-
"
,o
., '·' " I>
' � 11 l·H t:Vi

" �- -"41\
.. .. ...
"l+IT-H+•-•-
... .. ... ..
�It.,._ I
�. -1 ,.. ""' - . x.. �- -t--.b--
"' ""
I I i I N:, I I / I r::t:-d,..,,. I
100 l!,,O
I 17
.,. , ,., ..,
·1 !
""' , ""' , ""' ,.,,,
QUALITY OF �UIUIITTF.O LOTS Ip, it1 P"n:"'' dt"fl"Cthi!! for AQL'• � 10; in ifrfl"<:11,.., hn�d anio 101 AOL'•) ro,
� ,..,., rlrwn - r-• •• An ..,,...,,. _o-i.,, Lu•I• IAQt.'•I let u-•I l■-,,ull••·

,_.
0
TABLE X·C·l TABULATED VALUES FOR a>ERATING CHARACITRISTIC CURVES FOR SINGLE SAMPLING PLANS
Acupublt ()11•lily l.r•t"I■ lnor.,,1 i1111.,.-rdnn)

"· 2.S 10 2.5 10 IS 25 40 l>S X 100 X 150 X 250 X 400 X 650

r (h1 ('f'rtf'nt df-frr1iwl p (i11 Jrlrcu Pl'' hundl?d uai111

...o n.n m
""
0.201 J.27 0.201 !.97 16.S JI.! SO.I JO.I 95.1 122 150 207 251 l'll S68 611
9S.0 1.02 7.64 I.OJ 1, II 16.4 21.) 52.) 1'1.6 9J.9 12] 154 1115 249 Joe '49 "19 60I
90.0 2.00 11.2 t. II 10.6 :!2.0 34.9 r.J.0 9J,J 109 HO· 11J 206 27J 325 429 482 619 lJJ
50.1 eu 119 1)1 172 208 s,z
""
TH> 5.59 19.4 5.75 19.2 J4.5 245 JIB J74 4115 149 806

... ,.. ..,


173 :,SJ m
,,.
50.0 12.9 JU IJ.9 Jl,6 5:1.S 7U Ill 15] 21J 29) UJ 55) 61) 89)
,S.0 R2 ,s., 11.1 5J.9 78.4 102 216 260 JOI 348 OS 621 92] 9116

10.0 16.9 511.4 16.1 n.a 106 Ill Ill m 2611 J08 356 40J 195 564 111'1 766 1010 1076
65.7 m
""·' "'
5.0 4S.I 59.9 94,9 126 ISS 210 26J 289 J)9 389 4)8 534 605 BU 1064 IIJI
1.0 77.B 92.I I .. 201 )20 1'8 ,OJ 456 500 612 9.J5 908 1171 12U

><
l]J 6117

4.0 ,.o IS 2S 40 l>S X 100 X 150 X '50 X 400 X "50 X


Ac-cP1!11blp Q.11i1, LP•rh {lil(htn.,d it1•r,-t"lin11J

'"•01 Di-lal ,1••u.11.. _,.a.,...._"''"''"'••�..,...,._.,.. ,..._ ,., ,.,..... ..- ._...., _.._
MIL-S'.ID-lOSB
: .!
..,_ i
• 11 .I -.s .. " ..
"!
j ., ;
d:
i .
a
..
::,

X
C =i ;;;


:s ., :II

X • r.
..
:I
t
N

!! !::!

;

§
;

;;

"
!::
Ill

� t X
u X ;
;:: =:
5l I!!
.:: t §

iii ;

R

=
;: =
I:
1l t X
X •• := ; :

= =

R t iii
... X
0
u � t
•: : :
� j
.,.. X •• == .. = : I
N
2
t
::?
1il .!

.. ==

::?
t X i. (

X •
§

*
2

.
� :a
� = !!
.,
u D

X 6•
� •
.... .... •
� �
t
D
13 � "
j
.! D

; �

• ..
'a i lS i
' •
" - • t s •u
=
'
' " "
..

" * 1

•.
=
N 0

"'' - - ;
N

.... : :!
0

I! 2 ..f. i...
�b


Q

..
.!!

X..
Ii!
;!:
:! &! ., • t

--
8.3 ::. ::.
••

Ii

• -
:
a t! "' X t t

...,
::,

: 0
. • 0

: I• �
:J ,e .. : [> [> I> : :C
.l�.

· .
�i
'-'-
s-; .. " ..
l' •
.. Ir
!:
.. 'IL
i"'
) ..
'.! n a a a a

39
C, TABLE X-D-Tab/es for sample sire code letter: D

CHART D • C.-ERATINC CHARACT£RISTIC CURVES F� SINGU SAMPLING. PLANS


CCiinii fur .duiiWi: •ii .iahipli ■iiipliii irw iiiichid •• cluHIJ ii pneikililcl

rtlC(JIT or LOU f:IP'[CTl:D PJ:IICCIIT 01· 1.on l:lP'[CTl:D


10 Pt Atct.rn.n ''"•, to nr. .\Cc:1:n1:o 1r.1
'" ,.,
.. ....
..,. '
,.
.... "
....
....
"

.. .." .. ,.. ..
.. ., " " n " , ,
ID

• IO IO » IO kl 1G PD 10 tO 100 110 uo IJO lta ISO ,.. no


ID

, .. ,.. ,., ... ... .,, ,.,


Ql1'LITY OF SUBli(ITTEO Wn (p, I■ P"l'l:en1 ddKlin f� AQL'• ( 10; In d,r"ct1 � hnlftd 1nil1 for AQL'• ) 10}
lllot•• nil"""' - ...,... •• Att.,. ..I• 0,..111, l•"'• UOL'•I r- •-11_,..,._,

TABLE X·D-1 TABUIAT£0 VALUES FOR G'ERATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING PLANS
An-rplable O,aality u,.,.1, lnomal in-.pcr.lim,)

P, 1.5 65 10 1.5 6.5 10 IS 25 ,o X 65 X 100 XI ISO X 250 XI IIJO


p Un percent ddtc1i,d p On ddeco per hundrd oniu)

9'l.0 0.116 I 1.97 e.oa 1 0.1!6 I 1.116 I s.u I 10.l I 2'1.J I 36.J I u.a I so.6 I 16.2 I 9J.5 I 129 I 151 215 :l44 JS5 J86
9S.O 0.6l9 -4,64 I I.I 0,641 4.44 10.2 11.1 32.7 49.8 58.7 17.1 96.1 JJ6 156 186 249 281 m 432
I
90.0 I.JI J 6.88 I 14.1 J I.JI I 665 I IJ8 21.8 I JU I SB.2 I 61.0 I 818 I 108 129 171 20J 268 JOI I 124 I 458

,..
15.0 J.SJ I 12.1 I 22.1 I Joo I 12.0 I 21.6 JI.I I 52.1 I 14.5 I 85.5 I 108 I IJO ISJ I 19'l I 2J4 JO] JJ9 I u.e I 504
so.o 8.J0 I 21).1 I JI.I f 8.66 I 21.0 I JJ.4 15.9 f 70.9 f 95. 9 I 100 I Ill I 158 1BJ I m I m JBJ I 521 I 558

25.0 IS.• I JO.J I 41.J I 11.J I JJ.7 I 40.0 6J.9 I 92.8 I 121 I IJS I 163 I 190 m 1m1m 392 m1m1m
10.0 25.0 I 40.6 I s,.a I 21.8 I 48.6 I 66.S Bl.5 I 116 I 141 I 162 I 19J I 222 252 • I 309 J.52 <J7 419 I 6ll I 672

5.0 Jl.2 I 41.I I ...0 I 37,4 I 59.J I 18.7 .... I Ill I ,.. I 180 I 212 I 2<J 214 m 378 465 so, I 665 I 1.01
1.0 1J.a J !9.0 / 10."! I 51.6 I uo I 10s 126 I 164 I 200 I 2 19 I 252 I 285 JIB 382 429 522 )611 I m I 716

2.5 f 10 IXj '-' j ID I i5 2S I 40 IXI � I X I 100 X 150 X 250 XI ,oo IX


Acc�p1abl, Qu•litJ Le•••• hig!,1,ned ln,ptttioa J

II••• la.-i.l ·l•w1',..._ -· I- ..... - 1•'-d .. ....,-t••t-•: P'•I- I• "°MW,- � uN.


Mllr-S'ro-105E

i .; t
.! .. "' .. . .. .. ::: --
.
u.: •• ll g

"'
<l
- .... ....- X
<l <l
....•
�§

..-=-
��

§
'!I .,
lO :11 ..
:: I.
::
l!;
p:
!!:
!I
:,i

...
::l
:s
:a
X :I!
:
It; :;;
..
:a lil ;ll ':t
..-
:s �
§
.. -
A ll :!I :I! :,; !!: :; ,:
a :!!
J;I
::;
11!
i:i
::
Iii :::
-
!!:

..::-
I.
!!: ..ii !I

.. .,-
:II ,a
:J.
:;; X
X ..•. - a
N

11 l'J l-1 lil g ::. ., !!:

..
;:;
...
i:: :a
=::
ii
-::
g
=::: = :: ::; 0

..... X
'iii

.• -
i:i
..-
!!! t:; lO ,: :::i Iii
:
0:

;; ;:;

..- ..
N
lO

X "'...
ll!
::. s:
:::
- ll: I:!

-..-
!!: lQ
C: N
ii!
.. ...,-
A :!I l:i l:t

..:: :::a
!! i;;

1. !! ..
::: !!: g ::: :: Ii! ;:i 1l
X •
:: ::
1.:
u

...... .. :::
::: ;;
!!

X
lQ
::
... -
g :!! lil

=
,!! I::
l !!

X .
::: ::: g .:: !!

.... •-
0
;;

]. :a ..•
.! !I
.! :::
• -
=:::
:a

..•.. ..
g !!: t
!! ::: ... :: !!
j •J
0

X .,•. =.. - ..-.. ...,- .... ..=


,i ::: .:: ::: .;

..
r ., :a
!:: :: t 11
.... -..
.3 0

i ..• .. X 6.
� .3 ·;
'i
::: :: �

.. ..- .. ..
g
.,
..
0:
� g ::: s 5
..-
0

.. ..... .... ....


"' •
:i
!-.
Iii
:.
d!
-.,
"'
.. -- "'..
... ...
g

!.
!I
1! i
- - ,., - ..
.... ...
: :a ... ... .! .!
., - ., - - "' .,.,
a:
.,
lO

...
...... .,... ...-
r ...
!I 0

.. .. -...
.!:.

r. ..
..- ..• . :
<I! t �
g
'! t:
-
.,
.. ..••
N 0 0 0
&!
- - .
:
.
.i
.
N N N

..
"! g
i
= !
0 0 0 N


tE � �

=.
!•
:
0

..-
..;
:, ... .l
X .,.
:}• :li•
M
1:
:I!
.:5 ti ... .! .!
!
. !
• .l

..• X


0:

- :, 1! u j
1= . !. t

d!
. ..:
:'.l :
. 1-: f ...• il
-! • �
oi

..
0

=-
t
-:!-,
:
t> t>
J-
.: l.
if i. i• ....... I•
:N ;

.. .. - ..
� l
i ! i .! • •
i• i• .!.. ..•
u� : •
g g :: ¥ ¥

" ..• :
;

..!'J.,i..
•;
• I

.. . i
&!
i •• • •
:,

;ii ,.• h II

<l I> J;I :I! • •

41
D
m TABLE X-E-Tables for sample she �ode letter: E

CHART E OPERATING CHARACTIRISTIC CURVES FOR SINGLE SAMPLING PLANS

.. ..
1•1·•n·,1111· 1 n1:­
Lu•1n1 •11T1111 ir:.,.... Irr ,n.bt.. .,.if •n1lti1•I• u�lln,r •rt ,,.. 1c.lted u r.l1h•lr •• p,•riiulill')
.,01•1111,,.••
, ,
., .,'
"'Ill 1\1 I\ I td I I I I I I I I I I 11 11 I .,
,. IV I \I N I N I I I I I l+tt:Ji-1:t:1-
'

,.'
.. ....
-
-
.. I'
vi Ill I I'.. I I\ I 1•.111 I I I I I I I I Ii
..'
.. ""+ ··•--1--N·'•l-N'", .,'

� 11111 r1mtw�m1mu111 �H�mwntttti


- - - - tooe
IS JS:· � '\ \1� - + - '\'�
- -\"'/

� t0 n JO .'!o JO D ao u sa u 1G - - - - - ,.
'°' Af)L'• > IOI
""
tJl',\ LIT\' or !-l'OIIITTEh LOTS (p, In ,....r1:ot ,trlrclh• In, AQI.' • � 10: In ,l.,f.,rt• ,..., hurtdrT.t Ut1hJ1
,I>. lllau1 r1,-u N c••n •• 4,..,.,,, ...1. (/1,•lllp l.•�•l• IAl,l. '•IS. --11•.,..., ....

TABLE X·E-1 TABULATID VALUES FOR a>ERATING CHARACTIRISTIC CURVES. FOR SINGLE SAMPLING PLANS
Acc�t■blr ()u1li1,- le•eh (nonn.l huP"'Ctlon)

r, 1.0 ••• 6.S 10 1.0 ,.o 6.S 10 IS 2S X io X 115 X 100 X ISO X 250

...
r Ci11 rrrr•111 d,,fttlh••I p (in drf�t• J'f'f hunJ,'14 uni11I

...0 0.077 I.II ) 6.7� 0.0111 I.IS J.JS 6.]J IJ. 7 22., n.o 36. 7 46.9 51.l 79.6 96.7 IJ2 ISO 219 2.111

9S.O o.m 2.01 6.110 11.J 0.195 VJ 6.29 10.S 20.I J0.6 ]6.1 n.s SQ.2 II.I 95.7 115 Ill IIJ lt6 266

90.0 O.IU7 4,11 e.eo 14.2 o.a10 4.09 e.,e 11., 2,.2 15.0 u.e s,.o 66.5
....
19.2 116 125 1115
"'"
1115 261 2B2

, ..
15.0 2.19 I.II 1).4 19,9 t.11 7.)9 IJ.l 19.S 32.S ,s.e 52.6 66.J 80.2 122 I« UI 200 JIO

'"
,..
50.0 5.19 12.6 20.0 27.S S.JJ 12.9 20.6 20.2 ◄l.6 59.0 66.7 82.1 97 ,4 Ill 21] 2.16 •J2I JU

m m
zs.o
'"
10.1 19.i . 'm.O J6. I 10.l 20.1 J0.2 ]9,J 57.1 14.5 BJ.I JOO Ill 167 192 241 lSS

,..
10.0 16.2 l6.I Jti.O u., 11.1 29,9 40,9 51.4 71.J 90.5 100 119 IJl ISS 190 211 269 295 JR8

s.o 20.6 ll.6 41.0 49.S 23.0 l6.S 48.4 59.6 eo.• 101 Ill IJO ISO 205 2Jl 2'6 JIJ ""' us
m
><
1.n 29.e 41.J S0.6 SI.I JS,4 SU 64.1 77.] IOI 12:J ll4 155 176 196 235 264 321 349 450

1.5 6.S 10 X 1.5 6.S 10 ,s 25 X ,o X 115 X 100 150 X 250 X


Accf'p4 ■bit- O,■lhy tJ'•ll'I■ (1iaht•n"' i111r--rticu1)

N•let l�.t Cl_._. _ __, 1w ,_... ..""'11- .............. ,._I••• I• t.1-•• ,- ._._. •lo•.

..
'

TABU X·E-2 • SAMPLING PLANS HJ!I SAMPU SIZE COD[ I.ETTER: E

Accepulif• Q1HUtr t..-.h (---1 ,.,.,.cd•J

,,.. .,
....,11,.
c---
� 1.0 1.5 2.S ,.o U 10 100 150
c....

... :•...:.i...
•lu
cRcR,cRAc
X
Re
IS

RrcR
ZI X 40 X 65 X X X Z50

n.
::::,-;•
.,._

Sbol• ll 'v -lo 1 1 111 111 •IS ,11 111 ,110 11111 '*' 1s111 11�1 Z2121 :mlJO ulu ul6t ul t:. ll

I
u-Ju-Ju,.j
I I I I I I I I I I I I z:duI I I I I
1 0 , 1 • 1 s J 1 1 1 s , , 11111 , u 11 11 11 z, 11 291:is lll-0 I
1
Doel•
"
V
• ,i::-..1.:=.li.'.:..lo I
1
2 3
,
I &
1
S 6
l
I I
1 1 , , l
9 11 II II ll IS 1J11 19 2l 112'1 �St :IS JI lSju SJjs.l SI 16

D ,
ll

J • , 1 , 1 , l,• ,,o • 0 ,,o s10 •I• 111 111 •I J 101, •�, 1s1, 161 A l
, , 1

"I
Q
6 • I 0 l 0 J I 5 I 6 I 1 I • 11 •I • 101 6 111 I "' 10 11111 "'" !Sill 11 6

... 9 0 I O l I • 2 6 l I ' ' 6 10 I II I ll II lljll II " ,., Tl 26 36 29 J9 '


, 1
o i 1 , 1 s i I s 10 , 11 • u 10 ts 12 11 , d" 25 2, 11 In lt JI u 4D " II
12
lld1t,I• ...
l,J

I l I 4 l 5 I I II 9 12 II IS l1 1111 lO 'Z2 25!25 21!:12 ll )l6 4Dl<9 UISl 51 15 0


IS

I J l S 6 6 I 9 10 12 11 U U II II lO I 2l ?I 29(JI JJl 40 U IU 11)61 6'165 61 II


II

1 >I , s I, 11 , 1011J 11111 1s1 11 111n 111�2 IJ(n lll 61 19 JSl s.112 llln 11 ll
21 ul!S

...�..
Lu•
I.S JXI 1.5 ,.o u 10 IS 15
XI '° IX' 65
XI 100
IXI 150 1>< 1 zso
I
...
X H,1so;
Aa:.,.,l,11 0-•ll•r 1.,,ch C'4',..-.l l,.,...,doel

A • U• •11 pcadl.. ••s'• 1lu,cad.1,np lo, wWd1 .:crpt■1n •• ,.lecd_, .-..... ..,.u.w•.
'(/ • U• Nd ......... 1-,11 1b1 CDdll lrt1r1 b wWr.11 KE.UN ..d ftiecd- ...... _.. 1ull.l1.
Ac • AouptHc■ •..t.,.
Ra • Reltctlo• 1911kt•
• U.• Uecle 1-,U• �- ... (1t 11ttrllilllfllJ ■u ctdl ltlhr I)
• • Ac� IIGf ,.,..cud a, tW■ ,..,, •h•.
-n TABLE X-F-Tables for sample sire code teller: F

CHART F OP£RATING CHARACITRISTIC CURV[S FOR SINGU SAMPLING PLANS


rr.11cr.�t or t.nn
'!f�f.1Wurn.�\ r. {C.unu to, do11bl• •nd 111,hiplt. un1rlln11 are 1111rh,d u daftly II prM:licabld

..., NtN:QfflJ�it=
IDO

-,�-!ffiiiiif-lffi •t-1-'-1-1-1-
..
OM
•I• t""'(-+ f°1"1-t•

=�..
.,�
H'l l·++�ftmEtE
I-
..
+H+f::LW-
..
�--=
t-·
" I- ..
.. lit N.'-'! 'Nl·� ,. .. !1 "-

.. .. .. .. .. .. .. ,..
to to
I
• t-t·
Ill ::0 ,. '" ,
>
1111
Qtl,UTY or 0:.1'11\\ITTF'.ll \.Hrs tr. \11 fl"rtr-11t da-lrc1\w,. for '11)I;■ -( ID; ln dd,ct.s per livnd"'d 11ul1 r"' At)L'■ 101
p,_.tl fla•,.• "r••u ••• 4u••·ko O,.,llrr l.a .. 1, f,tut,'■l 1• _, 1.. ,-�,IM,

TABLE X·F·I • TABULATED VALUES FOR OPERATING CHARACT[RISTIC CURVES FOR SINGLE SAMPLING PLANS

P, • 65 2.5 ' . 6,5

p li11 ,wrc:�111 �"l,.cti.,,)


10 0.65 2.5 , ..
Atcf'ruhlt> ()u■li1y L<"u·l 1 (n"m■I hu�tionl

65 ID 15 X
p (it, dtolrctt per hand� 1$11)
2S
X •• X 65

o.m
ua
...
2.18 U! 1,91 14.5 17.S 23.9 30,S 37 .t St.I 62.9
us
99.0 0.0!,01 0,1S9 2.11 'il.75 0.050]

9S.0 0.256 J.IJ ,.22 , .14 IC.O 0,256 I. 78 4.09 6,81 13.1 19.9 JO.I , 46.2 b2.2 74,5

, ...
90.D 0.525 2.69 5,64 9 OJ 16.6 0.527 2.66 5.51 8,71 15.8 2].J 27 .2 JS.I 43.2 51.S 6U 81.2

75.0 1.0 4.81 8.10 12 8 :?1.6 1.44 I 81 12.7 21.1 29.8 34.'l 43,\ 52.I til.2 1'.S 93,1

so.o 141 D.25 !J.! lD ! :!7,9 3.41 D J9 !3,4 H!.4 21!.4 J8.J 43.l 53.l 6.'.U 73,J 93.! 109
25,0
10.0
,.o
6.70
10.9
13.9
12,9
18.1
21.6
18.7

,._,
24.5
24.2
JO'
"-'
34.R
0,5
1'56
6.93
11.S
15.0
IJ.5
J9,4
23.1
19.6
26,6
ll.5
2S.5
JJ.4
38.8
....
l1.I

S2.6
.a.,
SB.9
6S.I
S<.O
65.0
12.2
65.1
77.0
H.11
76.1
18.9
97,2
101
109
87,0 109
12'
Ill
125
Ill
ISi

1.0 00.6 28 9 JS.I 41.1 SJ,! 23.0 JJ.2 '2.0 50.2 65.S 80,0 87.0 IOI 114 127 15) 172

1.0 ,.o 6.S 10 >< 1.0 ,.o 6.S 10 15


X 25
X "' X 65 X
Act.,Jhbl" Q-uH1, '-"""h, hi,i1111�� ia�r--ttiNil

"••• ■....&.I • ._._.___. .. �..._..,.,. ....,._.._IP.a- .. ,_...._,-.._.,_._._


TABLE X-f-2 • SAMPLING PLANS FOR SAMPLE SIZE CODE LETT£R: F

Accrp11tld• ()uUr, Lntl1 C_,..J i .. pt'·cdM)

.... ....,,. ....


Trpi ol c-- c,-.
l11i•• L... ,
X X X ,o X ••••
lhpt't l11in
•--ct••
..
•-,li•t 065 1.0 I.S 2.5 4.0 6.5 10 15 ZS 6S
0.6S 65

,,
olu 1hr
Ac R, 0c Ito Ac 11, Ac It, Ac H, ,, R, Ac Re ,, llf' Ac Rc Ac Rc Ac Ar Ac n. R, Ac 111 M R, Ac It, n,

'

---
S..I• 20 Q 0 I I 2 2 l l 5 6 1 I I 9 10 II II IJ It IS II 19 21 22 D. 20

u.. u.. u ..
ll V . 0 2 D ) I ' 2 s ) I ) ' s 9 6 ID I II ' " II ,. 6 ll
n.■ol,
26
Von Lrnn bun
I 2 ) ' '. s 6 I I ' II II 12 ll 15 16 II 19 2l 2' ,. 71 :,
E It C

s V . • 2 • 2 • • ' 0 ' 0 ' 0 s 0 • ' I I B 7 • 6 5

' ' ' "


)

ID • 2 D ) 0 ) I 5 I 6 2 1 ) I l ID 6 12 10

IS 0 2 0 J I ' 2 6 J a ' ' 6 10 l II I ll II II I) 19 15

'

...
0 J I 2 5 l l 5 10 6 II I ll 10 15 12 II 16 22 19 2S 20
'
V.hiplr 20

2S I l 2 ' l 6 5 I I II II II 15 " II ll 20 Z2 ZS ZS 79 ZS

• ""
0

JO I l l 5 ' 6 I ID 12 17 ll II 20 21 Zl 27 79 JI J) JD
U1
co

• '• "" 15 11

.....
J5 2 l I 5 10 IJ 19 21 27 ZS 26 12 )) JI l8 l5

lhs
1.0
I0 X I5 2.5 ,o 6.5 10 15 X ZS
X ,o X 65 X ••t.:·
,65 ..
Acupo�, ()111i1y IA••h hi�tued i11,-.clioa)

6 UM •••I pNC:"'1-, ••-.I• •!H te..i. l1tt1n r.. •l,lclr1 -.ccrpl 1t11:r ud wjtttlc,e ,...,.,. ,,,. , .. 11,1,1,.
'°' •hid ucrpc1..:1 ,ltd ffjrctio1 ,_,..u ,,., ■n1l1hlr.
D
t;J : U11 HII ,.t.n•••t 11.-plr tiu codr lrtttr
Ac G AccrpUIICP ,_._,
lte a llrjrctl.. ••*'
= U,, 1i1al1 uapl1ii1 pin ,bmf (or 11tu111&Mlr ... codt l1tt1r J)
..,., • • .\ccrp11111c. .01 ,,.,..1u1t4 11 thlt uapl• 1hr.
C"') TABLE X-G-Tahle1 for sample size code letter: G

CHART C OP[RATfNC CHARACTERISTIC CURVES FOR SINGU SAMPLING PlANS

....
..r-1\t-
rncuTor1on
,-,fi�itn- mur:b,t •• duel1 n pRctlc1,Wd
...
1:1rrcu:o mu: (Can,n lor rhsbl• •d 11t11hiplt

..
ACCU'1JC ''"•t

,
..
.... l:'1
..,.
'
' -

,.

=I
•. J=t
•. t-Y-t-

"
.,
.,
'

.
·o.��!.
''-lN�.FFFRl "
..
"'
i"._l
-
N-t· l�+ti
-•·J-+.U l-,..
.. .. .. .. ..
N-rTI-i

... " "


N-
" ... � ,
t
...
(1\
VU.\LITY OF .\llfnliTTfJl LOTS Ir. in rw:n:,.nt d.-fr...-1hi- frw ,\1JI.'" 10: i11 ,t,,r,.cs. �, h1rM�d v11i11 for AOL' !11 ) tO)
11.i.., flt•••""-• - Au,.,tdl• !Julto, Looi• !AOL'"' h,o ,..,._. k-,.elf-.
0

TABl£ X·G·I - TABUI.AT[I) VALUES FOR OPERATING C�RACTERISTIC CURVES FOO SINGLE SAMPLING PLANS

.• •.,
Ac-tf';tUhlt" ()litlhy t.-..•h fonnn•I inr,ttli"a}

p• (UU 1.5 2.5 ,.o •.s 10 (UD I.S 2.5 , 10 X IS X 25 X ••


p !in p-rHnl d.r..r,i-.d r (ift dtffi'.n pPT l11md,,-d wftittJ

99.0 0,0lJ4 G.411 l.40 Z.61 s.u 9.IJ 0.0314 0.461 1.16 2.51 s.sa 9.08 11.0 14.9 19.1 23.1 Jl.l ]IJ.J
95.0 0.150 1.11 l.60 4.Jil 8.SO 13.1 fU60 1.11 1.16 4.l] a.11 IU 14.1 19.J 24,0 28., le., lb.S
90.0 0.329 1.61 l.<9 5.56 10.2 IS.I 0.129 1.66 l.tt S.fS 9.115 14.6 17.0 21.9 %1.0 l2.2 t2.7 so.e
J:..O O.ffi J.01 s.,2 7.'!1 13,4 )9.0 D.!99 J.00 5.... 7.92 IJ.2 10.6 21.1 26.9 J2.6 J8.2 49,1 58"4

50.0 2.U 5.19 8.27 IU 17.S 23.1 2.11 S.21 1.36 11.5 17. 7 2,.0 27.1 JJ.l 39.6 45.8 58.l 67.7

.... ,.n 2J.2


25.0 t.24 8.1'> 11., IS.I 21.l 29.0 8.tl 12.J 16.0 30.J JJ.8 40. 7 47.6 54.4 61.9 18.0

.,..,
10.0 11.6 IS.8 19. 7 27.1 3'.I 1.20 n.2 )6.6 20.9 29.0 35.B t0.6 48.1 • 55.6 62.9 11.4 88.I

s.o B.94 lf.O te.t 22.S JO.I JU •.J6 14.B l'J.l 24,'2- l2.9 •u •s.1 5],0 IIO.B "1.1 BJ.,
H.t so.o
•••
J6.0 107

x.
1.0 Jl.4 19,0 fl.I 41.l 14.4 20.7 26.J ]1.4 41.0 5,4,4 "3.0 71.l IV.S '5.6

o.t,S 2S ,.o 6.S 10 X 0.65 2.5 6.5 ID 15 X 2!'. X ,o X


Att�rt•M� (}vality l,.�,ls hi,tliunr.t IM�1iru1J

� •--wt\__._. -- 1- ,,_- ....-.11.. ro•,••i... .. ,,_'-., ............... _..

-.......
TABLE X·C·2 • SAMPLING PLANS FOO SAMPLE SIZE COD[ lfll£R: C

-.,�..·
Act:qit.Wt 0-•li•r (Anh ,.,...a IHpectlo•)

........ ....
c.....
><
r,..o1 c-.-
,u,-
X X
l•h•
X
t.11 .. I
Le111111..
0.10 0.65 1.0 u 2.S 1.0 u 10 IS IS II) ••!·

..
O.IO

.. .. .. n, "" ..
pl,a oh•

•• n, •• n, R, ne Ac R, R, Ac n, Ac R• Rt At: II• Rr Ac Ill' Ac IV •• R, •• R, Ac Rc

....... -
51,.I• Jl 'v 0 I I 2 2 3 3 I s 6 1 I I 9 10 II 12 U II IS II 19 21 22 A 31

U• u. u..
20 V 0 2 0 3 I I 2 s I 1 3 1 s 9 10 1 II 9 II II 16 6.

.. •
Do,blo L•Uff L,.tur

4/) 2 3 I 5 6 1 I t II 12 12 13 15 16 II 19 23 21 26 27 II)

F I II

I V • ' t ' t ' 3 ' I 0 I 0 I 0 s 0 6 I 1 I I 2 9 b. I

' s ' I 3 ' 10 12 1 II 16

I • I;
3 3 I I 2 1 I 6

I I I I I • •I • • I • '• I • • I • • I '• • I • •I • "I • "I" " I" "I


16 2 0 0 9

-� I I • I21 0 2 0 3 I I 6 3 I 9 6 10 1 12 I I) II II I) 19 21

M,ltlph l2 0 I I I 2 s ) 1 5 10 6 II I ll 10 15 12 II 16 22 19 IS 12 ....
0

..
40 I ) 2 I 3 6 s I 1 II 9 12 II IS II II II 20 22 IS IS 29 10

..
II I I 3 5 I 6 1 9 10 12 12 II II 11 II 211 21 23 27 29 JI 33

56 2 I ' s 6 1 9 10 ll 1, IS IB 19 21 22 IS 26 32 33 11 31 56

t..u•••
o.65 us X 1.0 1,5 2.$ ,.o 6.S 10 X 15 X IS >< II) X
.,,�..,o..
At:ttpe.ble (Jrtia1li1r l•"''' (1i1lilrnrd la•pKtNd)

ucl rrjrc:IIM __..., .,.. noell1ltl•.


6 • u .. •" pnc•li., u""I• tlu n,dt lellH fa, -tr.icll uc�1uce
• UM ••• 1.bM.,_111 u119lt •h• coflt t,n" let •llkll .ccrpltau uid rrJHllo■ �fl .,, Htltablr.
V
•• • Accrpuac, ,lllhbtt,
R• • lltlutlN1......,,
• U• 1ingle ••IIJ!llllf pin dxnt (o, 1IUrN1t1,1l7 ue coll fltt1r 1)
C") • AccrflUfttt _. ,.,_luff ti 11111 1..,a1 llu,
:::C TABLE X•H-Tables for sample siu r:ode letter: H

CHART H - OPERATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING PLANS

..".. ,;'tr .
r
�\��t",i,g ,��i (C..-u f01 douWt ud •11hiple ..111pli■1 ■re m■trh.. d u do■tlJ ■1 practlubld
AC:CCP'Tf.Plr■1
,
- - -
. ..
',-r,.-� -- - �. 1- - · I" - -
"
.... -

.... ...
.. '·" ,.,
r-
u
. r•
13
,- 4.0--J...' .. " " ..
" -
• ,. " .. "
1)UAI.ITY OF Sl.fHtl TTf-'.IJ LOTS Ip. h1 r,ttet'11I rl�f,,cl"t for AOLI,
,. . :.e 10;
.. . ..
in rldrct.1 �t hulWl�d ■nit, for AOL"■)' I0J
" .. ..
� 1'•u f"lpl'H .. •-• - A"'•l"••I• O,.alflr L,...,J. fAQl.'•I r. ■-I t�•l"tll.,.,

TABLE X-H-1 - TABULATED VALUES FOR OPERATING CHARACTERISTIC CURVES FOR SINGII SAMPLING PLANS I::

Acr,.ruhl, l)v1lhy 1.�•"h (nnr,n11I i1111�ttiM\I

r, 0.25 1.0 1.5 2.5 ••• 6.5 X ID 0.25 1.0 1.5 ,.s ,.. 6.5 X 10 X IS X 25
J) (\11 l)tff ..1'\ �t("("liv,) p Ii• ddttu Pf:' hu111frtod •11111)

99.0 0.020) 0,)00 0.816 1.68 U9 &.01 1.Ja 10.1 0.0101 0.291 0.872 1.65 J.57 S.81 7.01 9.54 12.2 15.0 20.7 25.1
,S.0 0.10) 0.715 1.66 l, 19 5,36 821 9.11 12.9 O.IOJ 0.111 1.64 2.1J 5 2J 7.96 9.39 12.l IS.< 18.5 24,9 29.8
90.0 0 210 I 01 2.22 l.SJ 5.u 9.S4 11.2 14,5 0.211 I .C>I 1.2!1 J.49 I.JO 9.31 10.9 14.0 11.J ,0.6 27.3 JU
15.0 0.574 1.92 J.46 S.10 8.51 12.0 IJ 8 17.5 O.S15 192 l.45 5.(11 8.H 11.9 13.7 17 .2 2!1.8 24.5 ]1.8 37.4
500 L:111 J.)J 5.JI 1 .29 11.J IS.2 17.2 21.2 1.39 J,J6 5.35 7.34 11.l 15.J 11,J ll.J 25.J 293 )7.3 43.l
15.0 l,7l s. 19 1.69 10.0 14.5 Ill.El 21.0 25.2 2.)1 5.JIJ 1.84 10.2 IU 19., 21.6 26.0 JO.I JU 4J.S 4Q.9
10 0 4.50 1.56 10.J 12,9 17.8 22.4 24.7 29.1 4.61 7 .711 10.6 13.4 18.S 21.5 26.0 JO.S 15.6 40.l (IJ.5 56.,
50 5.82 9.14 12.1 u.a 19.9 24.7 21.0 Jl.6 s... 9.49 12.6 IS 5 21.0 26.J 28.9 33,Q JB.9 4J.8 SJ. 60.5
1.0 8,00 11.6 IS.I 11.1 14.l 2".I JU 36,J 9.21 ll.3 16.8 2tl I Z6.2 l?.O l<.8 ,o.3 456 50.9 61.Z t,8:1
0.40 I.S 2.S ••• 6.S X ID X 0.40 1.5 2.S ,o 6.S X 10 X IS X 25 X
Accrroblr t.}tl■lhr l,r'"'l1 hi_.,10:■...t in,P""clio11l

*••1 tl-i■I lt-lrlNllee ..... I• ,-.,01 l•IHlln r ...... ■1-1 P'•ie.- I• �•l•u• ,-. '-• ..... Hh•.
TABLE X·tt-2 • SAMPLING PLANS FOR SAMPLE SIZE CODE LETTER: H

,_. Aa:,pe•M• C,.,lhr l.oeh <-•I liu,wt:tlo•) c--·


h1i•e

,,..
Trpe al Hi,:llrr
••,u .. l,lio
.-,1111
ILrt•� ..
o.:zs 02S O.IO X 0.6S 1.0 I.S u 1.0 u X 10 X IS X :ZS lht•
:ZS
...p1,
•h•

"' "' "' "'


slH

Ac II, Ae Ac R" Ac "' Ac Ac R, 4c lie Ac R, Ac lie Ac Rt Ac Re Ac Ac Ac Ht Ac: n, Ac n, Ac n,

Si•sl• so V 0 I I 2 2 ) ) • s 6 1 • e 9 10 11 12 13 If IS II 19 21 27 b so

.. .......... ...
u.. u.. u..
J2 V . , 0 2 D l I • 2 s l 1 J 1 5 9 • 10 1 II 9 If II 16 A J2
llo.t,I, Lt!nn LAnn
I 2 ) •• s 6 1 I 9 II 12 11 13 IS 16 II 19 !l 1, 26 11 64

. • • •
C K I
IJ V • 2 • 2 • ) • 0 0 0 s 0 6 I I I I 2 9 t::. IJ

• 2 0 J I 5 I 6 1 1 J • 3 9 • 10 12 1 26

...
26 0 l 6 II

J9 0 2 o J I • 2 • ) I I •• 10 1 ll a 13 II ll IJ •• 19
IO
0 I • 2 5 1 5 10 II I IJ 10 15 11 II 16 n •• 2S .12
...
.
52 ) ) 6


W.hipl,
0
6S I ) l I 3 6 s. a 1 II U II IS II ll II 20 22 :ZS :ZS 29 IS U1

• • ,. �

..
1B I l s 1 9 10 n 12 II II 11 II to 21 23 11 29 JI ))

• • ""
)

91 2 J • s 1 10 IJ 15 II 21 22 :ZS ,. JZ J) J1 l8 91

11.u,,i...
0 10
0.10 X us· 1.0 I.S 2S •0 6.S X 10 X IS X :ZS X 'ZS
th{M'
..
Accrpobl, U-,li17 L,u•h tli111:�tu� i-■pu:1l-J

0 • U1• ■,u p,rtt.dl•t .. ..,.1, 1i1• cod. l,nirr fot •h1di ucrp1H1c1 111d FTjf'ctloa ■,.,,. '"' , .. iltblt,
'Q • Uu: •11 ••hHqHN uaplt: 1iu <:odt l,urr lor ai-llid ,cc,punc, ,!Id FTj«tioa ,wittn 1ft: n1i11lil1.
Ac , AtetJUM:1 ••hrr
ne • H•1«1i.,.. a■-.bfot

:c
• Utf' 1ii1cl• 11•plin1 plH ,boo(°' 11ltrnatln1r , .. uell t,u,r l)
1 ., Acc:tptHu IOI p,MDitttd ,1 1t.h 11111ple 1he
'-- TABLE X-J-Tables /or sample size code teller: J

- CHART J • OPERATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING' PLANS

....
,CIC[NT or LOTS
ttr'[CUD ro It (C■n,n ro, do.ble •d e11hiple n•pli•I-. ••tchcd II cluelr •• practlc1blt)
ACctnu,ir.,
,
..,. .'�- _,
-
.. '"' ' ..J'

.... ' '


' • .... -
.. ·-' ' .,..
" . "
. ,_, �,., J
' ,., •-• ,_, " II

" ' '


I
.. p... .-I•
.I
- - - -
• I I
J I I 6 1 I t IO II II U H U II 17 II It IO II JJ 11 U n • l'7 • tt IO U II U M IS 16 JJ U1 " .o
l,)UUITY OF SU8\IITTF.O LOTS Ip, In P"�ut ddtttlre fo1 AOl.'1 i 10: hi d,rrco �r ho11dt"f'd ..11, for AOL'• >10)
l.n Ill.Hr f'lrn• Mr_.. - Acup1 ...'9 O,.alll, L""'ol• U(Jl'•I I• •-•IJH,,_to.._,
0

TABLE X·J·l • TABULATED VALUES FOR !J'ERATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING PLANS

o\ccrrot.l, l)u11ity 1.,..,1, h1orm1I ln1J1tt1iolt)

P, 0.15 0.65 1.0 1.5 2.5 4,0 X 6.5 >< ID 0,15 0.6� 1.0 1.5 2.5 4,0 X 6,5 X ID X IS
p lin pNt'c■I �ftcli••J p (in df.f,cl■ �, h,..,trNI uni11J
99.D 0,0U5 o. 1117 O.SSO 1.04 z.za J.7J 4,SJ &.11 7 88 9.76 O.Oll6 0.186 0.545 I.OJ 2.23 J,6J 4.38 5,96 76
. 2 9.35 12.9 15.l
95.0 0.0641 0."6 I.OJ 1.7] 3.32 5.07 0.00 1.9] 9.89 11.9 0.0641 0.4U 1.02 1.71 J,27 '-98 S.87 7.71 9.61 11.6 ISO 18,6

90.D 0,132 0.M1 I.JV 2.20 l.P9· !.91 6.90 8,,S 11.0 13,2 o. uz 0,665 1.38 2.18 J.94 5.82 6.79 8.78 10,8 12.9 17.1 20,3
75,0 0.359 I.IOI 2.16 J.18 5.30 I.SD UI 109 13.2 15.5 0,360 1.20 2.16 3.11 5.27 HS 8.55 10.8 13.0 15.J 19.9 23,4
50,0 0.86) 2.09 J,JJ 4.57 7.06 9.55 10.8 13.3 15.8 18.3 0,866 2.10 33' 4.59 7.09 9.59 10.R IJ.J 15.8 18.J 21.3 27,1
25,0 1.n 3.33 4.IH ,.10 9.U 11.9 13.3 16,0 18.6 21.J l.7J J.J7 4 90 6.39 9.28 12.I IJ.S 16.J 19.0 Zl.7 27.2 31.2
10,0 2.84 4.78 6.52 8 16 11.J U.J 15.7 18. 6 21.4 24.2 2.88 4.86 • 65 8.35 11.6 14.7 16.2 19.3 22.2 25.2 30,9 J'.i.?
5.0 3,68 5.79 7,66 9.41 12.7 5
1 .8 17.3 20.3 21.2 26,0 l.14 5,9] 7.87 9.69 IJ.I 6
1 .4 18.D 21 .2 24.J 27.4 33.4 31 .e
1.0 5.59 8.0J 10.1 12 0 15.6. 18.9 20,5 21.6 t5.6 29.5 5.76 8.10 10.S 12.6 16.4 20,0 21.B 25.2 28,5 31.B 38,2 42.9

0.25 1.0 1.5 25 4,0


X 6,5
X 10
X 0,25 1.0 1.5 2.5 4,0
X 6,5
X 10
X IS X
Accrpubl" Qu•lllr Luria hl�h•u.-d iup!'ctlonl

..... , 11-•·· ......�.11- -· ·- ,....................._,..a.-;,•.._,_ ..... ,.,......... -"··


TABU X·J-Z • SAMPLING PlAINS fQI SAMPLE SIZE CODE LErnR: J

..... ,.
Autphbl• QHlltr L,r..t, ,..,..a lupectlN)
c.... c-�

,...
Tn,oJ tupa,
X X X
ladn
-,11., 11th•
umplti 0.15
0.15 0.25 X Q.IO 0.65 1.0 I.S I.S 4.0 6.5 10 IS QU
15 ,-,le
,In•
Ac Re Ac Re Ac Re Ac n. 4c R• Ac R1 Ac n. 4c Re Ac Re Ac Re Ac Re Ac Re "" Re 4c Re Ac Re "" Re Ac R,
11..

-

- - .......-
2 l 5 6 1 9 10 II 12 ll II 15 18 19 21 22 /::,. 80
Sl.,te 10 V 0 I I 2 l 8 8

u..
- • '
UN UN
!iO

UIII
V
...... i..,-
0

I I J
2 0 l

••
I

5
I
6
s
1 I
l 1

'
J

II U! 12
1' 5

IJ IS
6 10 1

16 II
II 9

1, I]
II II

II 16
16

71
A so
100

. • '
H K

L

IIO • I • 2 • l • 0 0 41 0 S 0 6 I 1 I I 2 /::,. 2ll

' '•
V

• 2 0 l 0 J I s I 2 11 J I s 10 6 12 1 It IO

• • ,, '
•IO

...
U'I
lblll,11
IIO 0 I 0 J


I • I 6 J I 10 1 12 l U II 11 IJ 19 f,()

'
IIO 0 l I I 5 J 1 5 10 6 111 I IJ 10 15 12 11 16 22 19 25 IO

100 I l I • l 6 5 8 I II UI II IS I& 11 II 20 22 2S ZS 2'i 100 '�

12ll I l J 5 • 6 1 9 10 II I ,,, 14 11 ta 2ll II Zl n 19 JI SJ 12ll

IIO I J • s 6 1 ' 10 u II • l!S II 19 II 22 25 16 U SJ Jl JII 110

X
Hi1Mr
1.a .. t1i ..
o.zs 0.25 X 0.IO 0.65 1.0 1.5 u 4.0 6.5 X 10 X IS X �':'
Actitpt.W. 011ll1r Luel• lt11fun.d lnpecdoe)

,1111 ftjec:tlol ......,........uc1,.


fl • u...... pNClidlq ...... Ii• � letur lot -•1111::" K�•an
att1p11.c1 e.d njrcdoa •.-brt• .,. uall.W•.
V • U• Nd ,.t:i,.,........,a. •h• codlo 1,tur f• •trik:11
Ac • Act:rpuaca 1111181bet
Ra • Ri:li:ciloe n•kt
• todl
'""-•
1:1 U• alaal• u1apllq pl• Dwt (• 1lhrm\h1l1 au litter fl)
• Accq,1 ..c, .ell s-ralued •• ••b ,..J:l• 1lu,
::,iii:; TABLE X-K-Tahles for sample size code letter: K

CHART K • OPERATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING PIANS


(C.net lo, Dbl• ud ••llipl• •u,plllf an ■-td1ed H clo•lr II pncth:1bl•J

...
P'l:IClt'IT or I.DU rUU.NT or lDT5
urtcn.o 10 11t urr.crr.n ro 111:
'"'
..•
ACCtP'T[D IP11

....
ACCCMl:D lr'11

.... "
... •
..,.
.. •
... ••• .... ,.. ..,. • ..• - .
..•
0.10 _
"' LI. u

"
.. ..

,.. •• ... •• ,.. • " )
> ID)
LO II D
,P,t,I.IH •w �1 1 11111 rrr.11 uir.; (r. I• Pffl'HI ftl"fttli•e For .\OL', ( 10; 111 dtltt•• �r h•llfftd .-.111 lot AVL"•

.,,
"-• n.-,., .. .-_.. •• Atup1,1oi. 0-•lhr t,....1,(AQL'•I t.-1 ......,,,..
0

TAetE X·K·l • TABUlATEO VALUES FOR CPERATING CHARACTERISTIC CURVES FOR SINGL! SAMPLING PLANS
Atcrpt,blr 0-■lllr Lt,,I, (.onn■I lupecll011)

P, 0.10 0.40 G.65 1.0 1.5 2.5


X ,.o X 6.5 X ID

p (111 �• ddtt1l,1 w dtfttu pu hvncfrt.d ■11111)

99.0 0.00!00 0.119 O.JH 0.659 1.0 I.JI 2.81 ].82 4.88 5.98 1.28 10.1
95.0 0.0410 0.214 0.654 1.09 2.09 J,11 ].76 4,91 6.IS 7.40 9.95 11.9
90.0 O.DBtJ 0.42! 0.882 uo 2.52 J.,r 1.15 5,62 6.9% 1.24 10.9 ll.O

15.0 0.2JO 0.769 1.382 2.0l J.Ja t.71 5.'1 6.90 1.34 9.79 12.7 14.9
50.0 o.m 1.34 2.14 2.H 4.54 6.14 6.\14 8.5] 10.1 11.1 14.9 11.J
25.0
10.0
I.II
1.14
z.n
l.11
3.14
4.26
•-�
I.J41
5.94
7.12
1.15
9.42
1.64
10.4
104
12.J
12.Z
14.2
IJ.9
16.I
17.4
19.1
lO.O
22.5
5.0 Z.40 J.IO 5.04 6.lO D.41 10.5 11.5 13.6 IS.6 17.S 21.4 2,.2
1.0 l.61 5.JI e.11 1.04 10.5 12.1 11.l 16.1 IIU l0.4 24.5 77.S

O.IS 0.65 1.0 1.5 2,5 X ,.o X 6.5 X 10 X


Acc,p11bl■ Quality Lu,h. ltl1h1H.d ln1p,ecli011)

ll-1• A!l ..t- ,1- .. ...._ IAM• ,.... ,._._ .,_._._ • • .,....-i- • ._ .......i,
TABlI X·K·2 • SAMPLING PLANS FOR SAMPLE SIZE CODE l£ITTR: K

Acn,.,bl, t)Hlhr l,.uh h10•111al l■1prctlosJ

... ....,.
c--
.�-·_,.,
T,,. al c-,.

X X
""
X X mt
l11iu hti ..
0.10 0� 0.40 0.65 1.5 Z.5
l.f,ulhu
Hapli .. 0.15 1.0 1.0 6.5 10
plu 0.10 10
aiu
Ac l1e Ac Ile Ac R, Ac Ile Ac R Ac R, Ac Re Ac R, Ac n, .tc It, Ac R, Ac R, Ac n, .te Rt Ac H• Ac ltr Ac R,

�.,,. llS 'v 0 I I z 2 l l • 5 6 1 I I 9 10 II 12 I) II 15 11 1 11 21


1
Z2 ll 125

. ,... ,... ,...


Uu u.. Uu

IO 'v 0 t 0 J I I 2 5 l I l l 5 9 6 10 I II 9 14 II 16 0 IIO
O,cbl, Ltttn L1at1 Uu,,
160 I 2 l I I 5 6 1 I 9 II 12 IZ ll 15 16 II .. , 16 21 IW

" Z)

.
I L
. • z • l • 0 0 I I I •
.
'v lZ

..
l2 2 I I I 0 5 0 6 1 2 {:,.

z 0 l 0 I I • I l •• 10

..
s
..
l 2 1 ) 6 12 1 II

• • '
64

,.
1

\II 0 2 0 lI I z 6 ) I 6 10 I 12 I IJ II 11 1 13
w
0 l I • 2 l 5 10 6 II I ll 10 15 12 n 16 :tz 19 Z5
I
1::0
...
Vshlpl1 171 5 1

160 I l 2 I J • s I 1 II • IZ II 15 II II 11 zo Z2 :!S ZS 29 160


I
0

192 I l J 5 • • 1 9 10 II 12 II II II II ZO II 71 :29 JI ll 19Z


I
\II
I
Isl


Z)

ZZI z l I 5 6 1 10 I) U 14 15 II 19 21 22 Z5 Z6 lZ ll ll la 224

�--····
0.15
0.15 X 0lS O.IO 0,65 1.0 1,5 2.5 X 1,0 X 6.5 >< 10 X ,..10..
H1,.,,

Attrpdilt ()nlilJ Loil, (ti1lll1iwd iu..,..cti011J

{:,. • u.. MU p1nffi•1 u,.le ,In cod• l111u le, •\k• acuptaau ,Gd ffjrc\loa a�n 1ft: ,uila�II!.
'v • UH HO ■•1tcp1a1 ,.,..t, iii• coct. lru•t Ir- ••i�• KUpUKI ,.ct rtitctlo. •-�,. v. ,uil■bh:,
Ac • AcetplHCI •....t.T
lie • Hrjttlioa ••bn
• Un 1i1111l1 , ..,pll•1 ph■ •bo•• COi' 1lur111t1111, n• coda 1,nar I)

� • Acctpll111t1 IOI ptAliUcd •• 1•h u-,t .. 1iu.


,-- TARU! X-L-TJ,l111 for samp/11 siz11 ,ou kltt1r: L

CHART L • Cl'ERATINC CHARACTERISTIC CURVES FOO SINGLE SAMPLING PIANS

·•": ffifflJfRHtrnEffl m ffRtl 11i 11 ltl fHfftl 11111111111 IJ 11111111111111111111l II


PRCPTOFLOl1
tll'KttO TO ltl
MXIJ'TlD 1,.1 (Can• lor ANW■ ud a.ttlpl1 --,llllf.,. •••c•.. 11 doclt H pncde■W■J

N
..


• ,
·�Iii#
.!, •·-•

.. ... ... ...


"
V,

u ... .. ..• ... ... ,..
QUALITY OF SUlNrnED WTS (p, I■ pernnl ddtt1l•1 fo, AOL"• ( 10: I• dsf«t11 ,e-r •..._.. •lt11 for AOL'•
11,1

> IOJ
ILO 14.f ..
, ....
ll-1 ,,._•---�toc,..lllr,t-�CAOL'->'---' .........

TABU X= L•I TABUl.ATED VALUES FOR CPERATING CK-\RACTERISiiC CU'R\'ES FOR SiNGlE SAAiPtiNC Pi.ANS
Acc:epenl, Qa1llr1 t..n.11 (_,...j la1Pf"l'llora)

P, o.� o.zs 0.40 0.15 1.0 1.5 X .


2.5 X ,.o X 6.5

p u, � .wwca.. o, '9f«t1 pw....., ....,


99.0 o.�J. 0.015 0.211 O.IU 0.193 I.IS 1.15 2.J9 l.05 J.71 5.17 6.29
'IS.O O.Ol51 0.111 0.11!9 0.68) 1.31 1.99 us I.Oil I.IC Ul 6.22 7.15

90.0 0.051;7 0.2'6 0.551 0.1171 I.SI Ul 1.12 J.!I uz 5.IS 6.11 1.12
75.0 O.ICC D.111 0.1161 1.21 lll UI UI UI 5.21 6.12 7.'IS 9.34

so.a O.Jlf O.ffl I.JC UC 2.111 J.14 Ul 5.ll l.ll 1.ll 9.Jl 10.1
zs.o 0.69:1 us l.'6 u, l.71 c.u 5.IO UI 7.61 1.70 10., 11.S
10.0 I.IS i,N 1.66 l.JC UC 5.119 6.SO uo 1.19 10.1 IU II.I
5.0 I.SO U! J.15 UI S.111 6.51 1.22 1.41 9.72 10., 11., IS.I
1.0 I.JO J.!2 ,.:io 5.02 1.55 I.II) 1.10 10.I 11., 11.1 15.J 11.Z
. 0.10 O.IO 0.15 1.0 1.5 X 1.5 X ,.a X 5.5 X
Accrpc.We Qnli17 t.."I■ hla\l�Md l1111�1ica)

... All..._al_ll ... 1111,.__._,..__......._ •• ......,..... ,._....,....,


TABLE X·L·2 • SAMPLING PLANS FOR SAMPLE SIZE CODE l£TT£R: L

c--· Acc,pubh• Q.11111 l.e•irh (Doni,I iuprc1lN, c--


.Trptof

•"·
uec,li•1 .....,
l1ti••
Leu 1111•
X X X ,.o X 6.S
lli,tw, h1i-,•

.,
0.OM 0,OM 0.10 0.15 0.25 O.<D 065 1.0 I.S 2.S 11111 11111plir
6.S

"'
1iu ,i..

Ac tic Ac R• Ac ti, Ac Re A, lie Ac n. Ac R, Ac R• Ac R, Ac R, Ac n, Ac R, Ac R, Ac Rit Ac n. n, R,

• s e

-
Siqle 200 '\} 0 I I 2 2 J J 6 l I P 10 It 12 IJ II IS ta 19 21 22 I::, 200

..
u.. u.. u.
125 , ,...
... ....... 0 2 0 J I • s J l J l s 9 6 10 l It 9 It 16 I::, l!S
D,,1,1, '\}
• Lann 1A11e-r
J ' • s 6 7 B 9 II 12 17 u IS 16 18 It 2J 2, :Ill 27 250

I 2


K N

so • • 2 • 2 • J • • 0 • 0 0 s 0 6 I 7 I a 2 9 I::, 50

• '
'\}

100 • 2 0 J 0 J I s I 6 2 1 J I J 10 6 If 1 II 100

• z ' a •
IM I;
ISO 0 7 0 J I a J 9 6 10 l 11 tJ It 17 13 19 150

� · 1 ..... I _ I 200 I I I I I •. I. •.I, ,I,


0 J s I ,I,s .. 1 ... 1 •... 1 .... 1 .... 1,. .1... 1
2 J ,7 10 6 ti IJ 10 IS 12 17 16 Z2 19 25 M

• •s
V•bipb

.. ..
250 I J 2 J I l It 9 12 It IS II 17 17 20 22 25 25 29 250

JOO I s •
J J 6 9 10 12 17 17 II 20 21 2J 21 29 JI JJ JOO

l50 2 • s
J 6 7 9 10 IJ II II IS II 19 21 Z2 2S Z6 JZ JJ JI la lSO

...... ,...
0.10 0.10 X 0.15 0.25 O.W 065 1.0 t.S X u X ,.o X ,.s X
...t.."
'
6.S
ffl

&ct,p1able ()ull1r l..t•d• blgtl1,,ed ln1pectlnJ

0 a U N t11■1 ,...udiq H•pl, lln coda l•n•• f• •hid, ,cu-,u•n ,..t ftjttlicM ,,-.,o .,. n1i!.bl•.
V 1111 Un M"l1 ..b111....-e-1 u•plir ,Ire cod., liruu lo, wliicll 1ccirp1..u u,d relKli- ,,,.i,.n.,.. 0111,blir.
Ac a AUl'pl•«• ..-tiirr
lie er ffrjrctiN 1...t.:r

r--
II Ute 1h11tl• ..,.,.... ,.,......... (or tltsr111th1ly IIH Codi ltUlt ,,
• •cup1u1u • penni11M 11 1h11 ,..p1, du.
TABLE X-M-Tables for sample size ,:ode letter: M

CHART M • OPERATING CHARACTIRISTIC CURVES FOR SINGL£ SAMPLING PLANS
��"1g\g�°l,P, (Cwn1 for do.bl, ud tHhlpl, 11aplin1 •e eiatchtd u clo1el1 ■■ pnicdnblr)

..
ACCtP'Tlnc,.,

..,.'' -
- -

....
.... ·'

.."' �
'

OtO O,IS .U -Cl.'° "'"us f\ ,.. � ,., '·' ..


"
.. ...
'
,.. ,.. ,. •• •• , .. '. ••
u,
0UAI.IT't' OF SUBMITTED LOTS (r. in J"l'l"t'"nt ddl'cti"" fnr AQL'• (: JO: in dl'f,ct• P"'' hu11ch-d uh1 fM AQL'1
l'lelor n,.,., •• n.-. .. •• An•,.alole Q-.!ltr L•�•I• IAQL'•l fer ..,_,I lu,..-11-■,
> IOJ
en

TABlE X·M·l • TABULATED VALUES FOR OPERATING CHARACTERS TIC CURVES FOR SINGlE SAMPLING PLANS

Acct'rt•bl, Q111lhr L.,.,.,.1, (n,.,,,.,I i111ptc1h.n)

P, 0.040 0.15 0,25 0.40 0.0\ 1.0' X l,S X 2.S X ,.o


p (in J)'!rtHt d,fN:tln or in drfKI, r"'' bnrl1td 11ni11I

99,0 0.00)19 O.OUI' 0.1311 0,261 0.561 0.91] I.II I.SI 1.94 I ,JI J.28 J,99

'·"
95.0 0.016] O.Jll 0.260 0.4]4 O.IIJO I :!6 1.49 1.96 2" 2.94 J,95 4.7)
90.0 o.om 0.169 0.]!,0 0.534 1.00 1.48 1.72 2.23 1.1, 3.27 5.16
75.0 0.09IJ 0.JOS 0.!149 o.eos 1.34 1.99 2.17 2.74 J.31 l.89 S,05 S.91
S0.0 0.Z20 0.5)) 0,849 1.17 I.DO 2.4J 2.75 J.39 4.02 4,66 S.9J 6,88

zs.o o.uo o.ass 1.24 1.62 2.36 3.07 3.43 UJ 4,BJ S.S2 6,90 7.92
10.0 0.731 1.23 1.69 2.12 2.94 3.7' UJ 4.89 �-" 6.J9 7,86 B.95
S.0 0.951 I.SI 2.00 2.46 3.34 4.17 ,.se S,JB 6.17 6,"5 e.o 9.60
1.0 1.46 2.11 261 3.19 4.16 S.08 5,52' 6.40 I ,14 8.08 ,.11 10.9

0,065 0.25 0.40 0.115 1.0 X I.S X 2,S X ,.o X


Acc,.r,t■bl" O,.■litr L"""I■ llightr""d ln,,..-c1in1)

.. _, All__,_ ..... i. .a.- '-le "'"-4 - �-1- ll.l...C... ._ .. • ...-•--'- M .._ aa-.1.
TABLE X·M·2 • SAMPLING PLANS FOR SAMPLE SIZE CODE LETTtR: M

.lcup1,ble Qulit7 L.,,h lnon..l lHpec:tlMJ


Tfl'Ool
....,u ..
c--
....,,.
latin LPII
11111111 0.0<0 0.11'.S X 0.10 0.1� i 0.2\ uo o:M 1.0 X I.S X 2.5 X ,.o ...4.C,.
ll111W,
....c-...-
..,-Pie
p .. ■he
A .....
U,\HU
aiu
Ac He IA,c n.1-1, Re Ac IU Ac n, Ac n, Ac R1 Ac llr Ac n. Ac he lAc R, Ac R" b Re Ac Rr Ac n. •• n, 4t II•

5,1.,1. 31S V 0 I 1 I 2 3 3 •. 5 6 1 I I 9 10 II 12 ll 14 15 II 19 21 22 Ci. Jl5

V .
u-
... u-...
, ,
u-
• ' ' • A
...
t..ner t..,1w, L,n,, t 0 ] I 2 5 3 1 J I 5 6 10 I II 14 II 16 ,00
Doal,
' ' n
"
<Oil I I 3 5 6 1 • 9 II 12 12 13 15 16 II 19 2J :to ?6

.
r
'
L
• • • • ' a
,..
Ill 'v I 2 J 0 ' 0 0 5 0 6 I 1 I I 2 9 00

• '
I ..·-·-. I r ,.. I
1611 ? 0 3 0 3 I 5 I 6 I 1 3 I 3 9 10 6 12 1 II

� I I I I I I • ·1 . ·1 ..• I . ·1 . ·1 '..• 1 . ,o T n.. I . .T ..


0 2 0 J ! ! 6 l ! 6 ! 8 13 !I H u I ·- I ;
1,0

J.'I) 0 3 I ' I 5 ] 1 5 10 6 II I 13 10 15 12 11 16 22 19 25 JIO

' '
V.t11j,I,
6 5 1 II 1: II 15 II ll II 20 22 Zi 25 19 ,oo
IOI) I ] 2 J 8
.
'80 1 3 J 5 ' 6 1 9 10 II I? 1, " 11 18 20 i,!1 2J 27 29 JI 33 <Ill

• • "' 32
..
500 2 3 5 6 1 10 I] " 14 15 18 19 21 Z2 Zi ll 31 JI 500


X X X
1111••·
11111,.
D."''
0.0<6 X 0.10 o.a5 0.25 o.,o 0,6,S" 1.0 1.5 X 1.5 ,.o 1hu1
I.D

Acc,piabie O,..ii1y LtniJ (1i1ilt•4 iasprttioai

A • u.. ■en p.c:.dla1 ••-.•• ,Tu cod. l,un br •Welt eccq,cnu •ad "'Intl- •---n - •••llabl,.

..
tt,
Q
-
-
- Uu MU ••bMqMII
Acupu•o•ambfl.
H,jtttlOII ••llittt.
••-.I•
■in cod• Int,, lot •hi.-la 11eupluce ••• ,.l.c:1io• -�" .,... n■lhble.

3:: UH .,.,1. •-pu .. ,.... abo•t (or 11t1rMlh1lr Ht Cldl 1■Ulf' 0)


Au,.,,._.. aot ,-Jaiu•d 11 1hh ....p1. 11u.
:z: T.1BLE X-N-Tables for sample size code ittter: N

rl:1'Ct.11T 0,- LOTS


CHART N ll'ERATING CHARACITRISTIC CURVES FOR SINGU SAMPLING PLANS
urcnco 1011:
ACctrt tD Ir•' (C■"H (or do■hl• ad -hlpl1 1aapll11 - ■1tdr..d ■■ clo1•lr II prac1lc1bl1)

..
'"

.,
'
.- -

..
,.

. - . - . . - .,.

....
"'

" .. � - �40�_1_� ·- ,_. f"' o·.1-. -


... u u ,.,
" '
.. '
I
" n., ,, '·"' !'! L';. �c �-� H; >.ii u u ...
1)1' ,u fl or !,.fllllll J'TEll LffT'S fr, i11 �rcHI -t..ln1in Int 41)L'1 ( 10; In rn'ftt1t p!'f hud�d vnh■ for AQL'1 ) 10)
l'h1u ri,..,... n •- •• Ai:r•,i••i. 0-,.111, l.. ,i. lA0l.',I I• •-I i..,--11-.

TABLE X·N-1 • TABULATED VALUES FOR OPERATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING Pl.ANS
Acc,ruble Qi,•li•, Ln,h (rionnal l111�ctio11)

P, 0.025 0,10 0.15 0.25 0,40 0,65 X 1.0 X LS X 25

p (in ptN:Phl d.f,c1ive o, in ddf'rll P"'' hindml llfliU)

...o 0,00201 0.0191 o.oa,z 0.165 O.JSl 0.501 0.701 0.9S4 1.22 I.SO 2.07 2.51
o.m
,...
95.0 O IJIOJ 0.111 0.164 0 523 0.196 0.9]9 1.23 1.54 1.85 2.'9 2.98

,...
900 0.0211 0.10,S 0.220 0.349 0610 0.9JI 1.()9 1.40 I. 7J 2.73 l.25

11.0 0.0515 0.191 0.345 0.501 0.844 1.19 I JI 1.72 2.45 J.18 l.H

50.0

!S. 0
O.IJ9

o.m
0.336

0.139

o.m
0.535

078'
o.n,
1.02
l.ll

1.,a
I.SJ

l.94
l.ll

2.16
2.IJ

2.60
2.Sl
3.04
:t.9]

l...
3.7]

4.JS ....
Ul

,...
10.0 0 461 1.06 1.34 1.85 2.JS 2.60 J.08 3.56 4.03 t.95 1.64

so
, ...
D 599 0.949 1.2'6 I.S5 2. IO 2.113 J.l9 J.119 U8 5.)4 6.05

1.0 0 921

0.0!0
I.JJ
!US
1.68

0 Z5 .··-..
2.01
...
2.62'

V,U,>
3.20

,,,....._,,...... '...
,.oJ
------
,,........ ..,
4.56 ·S.09
..._.,,,.
.,,,.......
6.12

2.5
6.87

,,........
Ac<�•ble ()ualhr L.. •tl• hl11ht•1mf iuP""t'tlonJ

II'••• All ••I-• .... , 1ia ..... 1 .. I• ... , - ,-.,._ ........ , .. M - -,,... 1-,1- •• 1M 11.._.J
-
.. _ - 111\�n

•r
J]
j I
11 !ll ... a
:? !! B I:; !ll 5 5l E
,!
<l <l <l !J.:i
.,�
� JI
= .... -= = n ..n � ::I
X
== - - =
s; Ill
,! A

n ..
:J Ill � ;:; I:;
JI ;;

X .. .. -- .. - = ::
l � N A ::I

=-
A ;;; �

X
!!!

== - -.. - =
:? 2 :I :: A A Ill

.. =
c! !!:
:
= !!!

.... ., ..- - = =
::
::
;; n

=-
z
X
2 � A A
c! :l
JI � 0 2 !!! ;:;

- = - -..... .....- -=.. ==.. ==


., = X
2 � :: !!:
"" l :I

..
0
2 !!!
1
-- =.. - .. - = = ==
0
JI

X
c!
• -- 0 =- i ::l
.!
"'•
-... ., ·- - ... -· - ... - = = X 1
C

} ::I"
I.
• 0
., .. -
.,
- .. 'E
"'•
- .. ..., -.. -..
..,• ..- ..., ...••
2 .!
s0 r ::I

.. -- .... .
0
11 ., .!I

- ..
JI
j•
.,.-= n
0
c!
JI .... -... -- .. ... ..
0 ..- -.. ., ., n
s
cS• 0
11

.... ..-
cS
.!
1L

0
,!

JI .... .. .... ..• 0


.. ..
0 0 -
... ... ! 0

- - ..

-
c!
-
0
0
� • •
..
0 0
J 0

g0
l
JI
! 1! 2
0

X c!
JI
I
:, 1! 0 g0

I0 c!
JI
I
:, 1] • X
=• • . I
0

..
0
J 0

.
I
�11
,!
I> I> I>
J1
•o
30

..
JI

i!j ft
u.!.-=
!ll ..
� a n B � !ll 5 � E

, :, I • •
!
..
1 'll. "'; j J a ■ n o oa
. .
<1 I> JI c!

N
59
-c, TABLE X-P-Tables for sample size code leller: P

rt:1n:r,n or 1.on CHART P OPERATING CHARACTERISTIC CURVES FOR SINGH SAMPLING PLANS
unr.n:nwo1:
,r.-.1•nu1r., (Ci,,.u for doulil, ind 111uhiph 11111plins ,re n1tchl!d II clo1,ly u puctinbld
""
... •N-t-
., �t-1'
,. H-•-
.,
�11,-
1\1.

•'H•
D.Dl!t).:;--��.tm.-1�-r't.-t.ts"
·f
-NftTN:T
-�� M�. , .. ,,
IO,
• '·' ,., ,.. ,.. u " ... ...
OIIALITY OF SU111UTTt:U LOTS (p 111 r,f'rtt■r ikfec1i"' r� AQL'• <
Ill In dcfeocll prr h.-itdm:t 1ah1 lor AOL'•> 10)
Cl\ Pf""•• r1,-u • �-• - �., .....j. 0-,,1111 l•..I• tA(/1..'•I a.. -11•,...c"--,
0

TABLE X-P-1 - TABULATED VALU£S FOR OPERATING CHARACTERISTIC CURV£S FOR SINGLE SAMPLING PLANS

Attep!ebll" 1)1Hlilf l."•"I• (naffll,I lnpr("ti11n)

P, 0015 0.065 0.10 0.15 0.25 0.40 X MS X 1.0 X 1.5

rlin �rc,nt 1IPfrcti•,. er d.-frcu r,r liuffl',d vni11)

99.0 0.001!6 0.0186 o.osu O.IOJ 0.22J 0.363 0.438 0.596 b.7S2 0.935 1.29 1.57

95.0 0,00641 0.0444 0.102 0.171 O.JZ! 0.498 0.587 0.771 0.961 1.16 1.56 1.96

,..,.
90,0 0.DIJZ 0.0665 0.138 0.218 0.3'14 0,582 0.679 0.878 I.OIi 1.29 1.71 2.0J
75.0 O,OJ<,CI 0.120 0.216 0,]17 0.571 0.715 0.1!55 1.08 I.JO I.SJ 2.34
50,0 0.0064 0.210 O.JJ4 0.4S9 0.1\19 0.959 1.00 1.Jl 1.58 l.&l 2.ll 2. 11

25,0 0.173 O.JJl 0,4q(J 0.639 0.'7.!11 1.21 I.JS 1.63 1.90 1' .11 2.72 J.12
l0.0 0.288 0.496 0.665 O.B15 1.16 1.47 1.62 1.93 2.22 2.S2 l.09 3.52

s.o 0.374 0.593 o.m1 0.969 I.JI 1.64 1.00 2.12 UJ 2. 74 J.l4 3.78
1.0 0.576 O,BJO I.OS 1.26 1.64 2.00 2.18 2.52 2.BS J.18 J.112 4.29

o.cus 0.10 0.15 0.25 0.40 X 0.6.I X 1.0 X 1.5 X


Accrr1•ble 0-•lilf Lu,.I, (1i�ht•11•d i11:'tpttlion)

,._, All,..._ 11- • ..... 1.W, '--' • �•..._ •.-1'-du - - .,,......,_ ... • .. 1-...,,
MlL-S'lt>-lOSE

i -E j .! § � � I:! § § � � � §

=�-
(,.l � • •

F.:
0:
!s.,,..,;
<l ti -=
..
"! <l <l

= ..- :- =:= =: X
<

... • A
=
:!! I. IQ � ::i 151

=
0:

=
<
• ;; IQ ;; s:;

..
==:
...
X
=: :
- =
rl! ;: i:s IQ IQ ::i

-= - == =
- - - = =
� R ,0
:!! i::: I. ::I

X

=
=:
0: Iii R 1l


== =.. .. = = =
.. - = :=
< ;; IQ

X == ==:

., -
.... :!! ,0 SI ::i

..
0:

g ;;

- ....- ..- -=• ==..


0

==
<

0
rl!
• =..
=
., 0
g
,0
== X =:

..- ==
<

.. : .i

i Xs - i
"'
N
rl! �

... - -.. .. ., =-
j
.. :
0

-..
0
u �
rl!
-.. .. -.... - ., ..• - -
g
=..=:= X 1·
N

1
.!
"'
N
0 •
<
0 �
:a
..- . - .. .. -• ..- s
rl! .,
! IQ
0 :i
-
.,
..• .. -- .... ....
N
0 •
.:s�

i1• ., =

.. .. -
..
.,
-- .. .. .. -- ..- -.,..., I'! ':i

.. - =
;; • 0
&
"'
< 0

:i
z
......,, �
0
;;
&!

:i .... 0

.. .... ..• .. .. .. ..
0 0

.. ..
0
1
..
<

!
rl!
- - . - -
0
z • •
0 0 0

! :i
:! t! 0 !
....'
N
X &!
<
I
:,
j!
.:s •

!
0:
I
!!
..
:,
z
<

q
0:
• . IQ
"• .
=

0 0
:a
I ,! ii
I> ,e§
I> I>
...
:o
0

i : .. =
<

-.
u'if-:
Ii � � � § !ll § � � �

"I ,!' I i j
!l� ;;i I I ■ ■

. .
■ ■

p
61
c::, TABLE X-Q-T11.bles for 111.mple sire �ode letter: Q

CHART Q • CJ>ERATING CHARACTERISTIC CURVES FOR SINCL£ SMIPLING PlANS


PEICVIT or lAffll
uncno ron (C.M1 '°' do.W, •-' ••hlpl• ••pllt11 .,. ■1tc� 11 doulr II pnclluW1J
,.,
MXl"t.DIP',I

.. ��-
..,. '
� f--�-
r,;

--
' -·-�."'-
" - "'

..
IO f-• -·

., ' ' ''


.. ...
.." D.010 0.10 O.H
"I
,. '·"' • , ..
I �
,,
I.I •., O.J O,t ,.s ,.. o.r O I IU 1.0 I.I 1,1 1,1 ,.. I.I I.I 1.7 I.I 1., 1.0 I.I LI 1,1 ,.. I.I
"',_., f}U.\LITY Of SUUVITTF.O LITTS (p, I■ pert't'•I de(,ttl" for AOL'• ( 10 ; I■ der
�1.1 per hndffil aah, for AOL'■ > ID)
lle1•1 n,- • � - -'"•,clDt. 0-,IIIJ' Le"h IAQL'•J '- -S la-,.,e,,_I

TABL£ X·IH TABU!ATED VALUES FOR CJ>ERATING CHARACTERISTIC CURVES FOR SINGLE SM\PLING PlANS

Accep11ble Qu,litr L,,,1, (■on.al i■1pttlion)

p• U.010 0.040 0.065' 0.10 0.15 0,%, X 0.40 X D.65 X 1,0

p (in J"f'l'Ctal def�lrt or dPftt11 � h,nd,.d tmill

99.D 0.000804 0.0119 0.0349 0.0651 0.1'3 0.2J2 0.281 O.J82 0.'88 0.5911 0.828 1.01

95.0 0.00410 0.0284 0.06S4 O.IOI 0.20'1 0.318 0.316 on• 0.615 0.740 o.m I.II

...
90.0
f.Jl,\I
0,0034J

0.02.JO
o.ous
0.07&9
0.0882
u,,.,., ·-·
0.140

U,.nl.J
o.zs:
•·=
o.m
o.n�
o.us
u.�,
0.562
0.6W
0.692
0.634
o.m
U.979
1.09
i.21
I. JO
i.49

50.0 0.05!! 0.134 0.214 0.291 0.4M 0.61' 0.6114 0.BSJ 1.01 1.17 1.19 1.13
%,,0 0.111 0.215 O.JI& O.C09 0.5114 0.115 9.1164 1,0< 1.22 1.39 1.74 2.00
10.0 O.IIM 0.111 0. 42' 0.SJ4 o.m 0.942 1.0< 1.23 1.42 1.61 I.OIi 2.25

5.0 0.240 0.380 ,0504 0.620 0.8'1 1.115 I.IS I.J6 1.56 1.75 2.H 2.42
1.0 0.J611 0.5lJ 0.672 O.II04 1.115 I. 28 I.J9 1.61 I.BJ 2.0< 2.<5 2.15

0.01S 0.065 0.10 0.15 0.25 X 0.10


X 0.65 X 1.0 X
. Acctr,l■bl, Ou■ll1y Luth hi!fh1eHd i111�1ion)

111..., 1UI ..a- p..,. ....... uWt ...... P.a.- lhll"lkl.. • • .,_........ ,i. 11....1
TABLE X-Cr2 - SAMPLING PIANS FOR SAMPLE S IZ[ COD£ L£rnR, Q

I ...,.,..
Tr,o el

p..
c-.
_,..
....
lotin
X
4c n,
0.010

4c R, 4c
0.015

n.
X
Ac R• Ac
0.02S O.OIO

n. Ac Re
Acc•alil• Qulh7 a....t. (...., tu,.ca.)

••
0.065 0,10

R, Ac ft• Ac
0.15

Re Ac R,
0.25 X
•• n. Ac
Q.10 X 0.65

Re Ac R, Ac R, 4c
X
R, .. "'
1.0
"""·
.....
� ...
Ac "'
=-._...... I
Slqlo 1250 0 I I I I J J I 5 ' 7 I I 9 10 II 12 IJ II IS II 19 21 12 .A 1250

u.. u-
'
u,,

I I
u,,

a ...... ' u u
,.
ICC Q ! 0 ! ! ' ! ! ! l ! l ! 6 !O l I! !6 A !!0ll

"
mil
• • •
0-

1: u�
Dool,I, 1.c,...
1600 I r > 5 6 1 P II 12 12 U IS 16 II 2J 21?1 1600

ft
'
5

315 • • r • 2 • J • • ' 0 0 I 9 5 0 6 I 7 I I 2 A Jl5

• '
·�
2 0 J 0 J I 5 I 6 2 7 J I J 9 10 6 12 7 Ii 6JQ

' • '
6JQ

"'.... 915 0 2 0 J I 2 6 J I ' 6 10 11 I IJ II 11 IJ 19 MS

Maltlfl• 12IIO 0 J I ' 2 5 J 7 5 10 6 II I IJ 10 15 u 17 1' Z2 19 25

J57S ! ! ! ! ! 6 5 I I I! 9 12 II 15 II II II 20 12 Z5 25 29 ms
ll90 I J J s I 6 I 9 10 12 12 !I Ii II II 20 11 2l 11 29 J! ll !■90

l205 2 J I 5 6 I 9 10 IJ II !I 15 II 19 II 22 25 21 12 ll JI ,a Z205

0.010 0.015 X 0.025 O,OIO 0.065 0.10 0,15 o.zs X G.10 X 0.65 >< 1.0 X ":t..·
1.0

&ccq,<al,le O,elltJ Lc,,I, (llptned la........l

6 a UN .. ,, pncMI., uaple 11&• � lat1• for •�c� eco,-:111c:, ucl ,elect* ,uit.r, .,. ,... u.w,.
Ac = Acc,rptinte H9NI'
Ra = ReitctlOII __..,
c UN ...... ,uap11,, .... ,._,..,

0. a .lc:nptNU IOI pttalll-4 11 1•h 1-,l1 th•.


::=ii::, TABLE X-R-Tahles for sample. sin �ode letter: R

CHART R - OPERATING CHARACTERISTIC CURVES FOR SINGLE SAMPLING. PLANS


l't.lCt:lll or LOT!
lll'rcr.:n 1U llt ICur-u, for d1t11hle ind 1111ltlple ••K1Pli111 1r1 11111clted 11 clo■-lr H pnctic,hh•J
,.
ACCJ.l"Tl,IIIP•I

..
., ' .....
,.'
..
'

..'
....
IO

"
.,
.."
'
o.on 0 CMCI ��°':\ "' o.n ,._ O,ll ....
..
'

• 0.1 0.2 '·' ,., ,., ,., '·' '·' 1., I.I I.I I.I ,., ,.,

..
�•l'll.f"rl Cf �110:ITTrlJ LOTS fr,, In l""f'fPrtt .tereclll'r for AQL'1 (. 10; In derei::11 J"l'' hundr'ld 11nlu fo, AOL'• ) I0J
,,... I n, ... u ., ........ Att,,a■loh o-n,, t ..,1, 1AOl.'•I ,_ ....., 1.. ,-,n,-.
0\

TABLE X-R-1 • TABUIAT£D VALUES FOR 'OPERATING CHARACTIRISTIC CURVES FDR SINGLE SAMPLING PLANS
...
0

Acc1pt1bl1! Q.. lilr Lurh (_,..al lnp,rc1lon)

P, 0.0::!S 0.040 0.0<.5 0.10 0.15 X 0.2S X D.40 X 0,65


r (In perunt dl!'tttlln or ddtcll per h11adr1d 111i11)
99.0 0.0070 0.0218 o.om 0.0892 0 .115 0.175 0.2J9 0.JOS 0.Jll 0.511 0.629
95.0 0.0171 0.0109 0.068! · O.IJI 0.199 0.235 O.J09 0.314 0.462 0.622 0.74S
llO.0 0.0266 0.0551 o.om 0.158 0.2.JJ 0.212 O.JSI 0.IJ2 0.515 0.664 0.812
75.0 0.0'81 0.08&4 0.127 0.211 0.29! 0.342 0.UJ 0.521 0.612 0.195 0.9JI
50.0 0.0&39 0.134 0.111 0.281 O,JIJ o.m O.SJJ o.w 0.7JJ 0.9JJ 1.08
25.0 O.llS 0.196 0.HS 0.371 0.484 0.540 0.651 0.761 0.870 1.09 l.2S
10.0 0.194 0.266 0.Jl.t 0.46' 0.589 0.650 0.770 0.11811 I.OJ 1.24 1.41
s.o 0.237 O.JIS OJBD 0.526 0.6S7 0.722 0.818 0.972 1.09 I.JJ 1.51
1.0 o.m o.uo 0.502 0.65S o.800 0.870 1.02 1.14 1.27 I.SJ 1.72
0.010 0.0<.5 0.10 0.15 X 0.2S X o.,o X 0.65 ><
A�tpt■bl, Qu■lltr l...n,h (1l,:h1r1ied lupn::llonJ

•-1 AD•......-� ................ ,................... ..,.. ...... 11 ... "---I.


i
u .! t
.! ••.! a � � � � � a � ; �

=-
I!IJ_:•�C a:•

.:i
<l <1

.. :
<l
i �:-ac
e

- -= == -.., X
cl: R % !: Wl p: ::i :!!
-
i:;

.:i !: rl ;:;

-- - ==
;; Ill N

• :
X
a: !: ;s Jl Wl It ::i
$
.l! • R :: R i:; ::;

..• := - :: --
= ::
- • - X
� !: 2 Iii A Ill
s
""
C:

... • = ::
::
;; l'I

X ..• =- ..• = .., -


2 :!! � ft R
C:
sci

..
0
- = =
2 :: :: ;;

..- = - X j
C: 2 � !:

• - •
Wl

- == ::: ::
.., •
I d

-.,,
.:i 2 0


l::l
J X - ..,- -•
!!
- •- = ::::

i
..••
il:

- • .. -
• �

1r. .,;;; ..• - - .l! 0 N


..- -- .. ::: X !"'=
2 !!
- ..,
C:

.. .. - ..,
• .. ...
2
..
-
0

.., ., - .. ;;; .
,l 2 .3

., ... ... -
., • • s
&
d
cS
.
i
.:i

-
N N

,.. .., •
:i'L
-- ..,• .,• .,..
• .,
! ! ..• -
il! 2
.., • i
..
d
u • 0 f
.., • .., ..,
- - .., • :§
.., u

.."'•• ..
u
0 C:
N
t
i!! i'
d .., • 0 0 ci

- - -
N 0
.., .., ..,
- - i
N N N N N N
0

• • f,

-�
0 u 0 0 0

X ..
-�
!
,l

., =
u J I; .,

� .• :
:, u.:, ... X
.,6
..•
il:
!j
-
0
I 0
� u
:, d

X
a:
. . :
0

.l! 0

Al-• l. .!•• � §I ! � � i R � � I
i"' 1 • • • • •
'1 J
!l'
I
J
. .
R
65
V"' TABLE X-S-Tables for sample size code lelter: S

Aceoptohlo 0-olllJ 1-el


(oon,ol IHpectlaal
Typo ol
1uplliii
C1;1mu-
l,lin ...,_,.
pt .. Hmple
.1 ..
Ac Re

Sl•al• 3150 I 2

2llOO 0 2
Dod,le

17'1
4000 I 2
17'1

800 • 2

1600 • 2

2400 0 2

Multiple 3200 0 3

I 4000 I 3

4800 I J

5600 2 3

0.025

Acceptable Qu•lily Lewel


(tish1ened lnspeclionJ

Ac = Accep1aace ■umber
=
=
Re Rejection number
I Acccploaat IOI ponillecl ■ !W■ ■uplo ■lu.
MIL-5'1'!)-105£

6. rcn::s
6 .1 Intended Use. Sanpling procedw:es and tables for inspection by
attriD..n:es are intended to be used in the acquisition of Defense material.
6.2 SUbject Tenn (Key Word) Listing .
.Acceptable ()Jality Level IAQL)

Average C>Jtgoi.ng Quality (M:Q)

Defect
Defective
Lot or Batch
Process Average
Sanple
Sanpling Plan
Unit of Product
6.3 � fran Previous Issue. Vertical lines or asterisks are not used in
this revison to idern:ify changes witil respect to che previous issue due to
t.he extensiveness of the changes.

61
MIL-S'ID-lOSE

Custodians: Preparing Activity:


Army - AR Anny - AR
Navy - OS
Air Force - 23

Review Activities:
Army - MI, EA, TE, AV, ER (Project QCIC-0085)
Navy - AS, E.C, M:, a,i, SA,
SH, ID, YD
DLA - ES, GS, SS
OSD - IP, SO

User Activities:
Army - ME
DLA - ES, SS

68

You might also like