INDIAN MARITIME UNIVERSITY
(A Central University, Government of india)
May/June 2017. End Semester Examinations
B.Tech. (Naval Architecture & Ocean Engineering)
sixth Semester
com 1271603)
Date : 24.05.2017 Maximum Marks : 70
Time: 3 Hes
4
“Answer ANY FIVE of the following
2. Describe various stages of conventional design process? Explain
the role of computer in CAD?
b. Consider the plane triangle vertices are (3, 1), (4, 1) and (2,1).
Find triangle vertices by rotation of triangle 90°,180°, 270° and
‘360° in anticlockwise direction about the origin?
2 Use parametric representation of hyperbola to generate eight
points on the hyperbolic segment in the first quadrant with
bet for axes
b.How the curves are represented in parametric and non
parametric way? Explain them with suitable examples?
‘a.What Is Bezier curve? Explain its importance in designing ship
hulls?
b. The vertices of Bezier polygon Is By [1 1], 8: [2,3], Be [4 3) and
Bs [3 1]. Determine seven points on the Bezier curve?
a. Calculate the four (n=3) third order (
functions for Nj(t), = 1,2,3,4 with an open knot vector of [
0001222)?
) open uniform basis
b. Calculate the five (n+
functions for N.s(t),
01133377
) third order (k=3) non-uniform basic
1,2,3,4,5 using knot vector of [x]= [0 0
12, What are basic components in NC machine tool? Explain them
with neat diagram? Mention the advantages and applications of
v7
v7
a
fc)
v1
v7
v1
v7
plNC machine tool?
. What are the different ways in which geometry commands like
point, line and circle are specified in APT? Explain any three ways
‘of each element is defined from the data given in the part?
6. For the component shown in Fig. 1 make a part programme on 2
‘machining centre equipped with’ the ISO controller. All the hole
‘making operations are to be machined using tools specified, Clearly
show set point and axes point on the sketch of the part. Show all the
necessary calculations. The work material is C25 steel. Tools used
are Twist drill of @5 mm and 10mm. Speed and feed for both the
tools are 150 rpm and 200mm/min respectively. Use coolant during
‘machining? All dimensions are in mm.
7. For the component shown in Fig. 2 develop complete part
programme on a milling machining using APT language. The rough
{and finishing operations are to be machined using tools specified.
Clearly show set point and axes point on the sketch of the part.
‘Show all the necessary calculations. The work material is C25 stee!.
Coolant, Tools, Speed and feed are specified in the table. Ali
dimensions are in inches,
‘Spindle speed Feed Coolant [Turret Tocation
rpm Inch per of tool |
minute
Rough [600 3.0 on |
cut
Finish [500 20 on 6
cat
ts]
114]
4]l
eee
| AS |
Fig:2
8. a. prove that two pure reflection transformations about lines passing (7)
through the origin result is pure rotation,
b, Explain the parametric representation of Ellipse? a