Professional Documents
Culture Documents
MTC Test Nescom 14 May, 2019 AM Electronics PDF
MTC Test Nescom 14 May, 2019 AM Electronics PDF
1) Which level of system implementation includes the specific function oriented registers, counters &
multiplexers?
(A) Module level
(B) Logical level
(C )Physical level
(d) All of the above
Ans: A
2) In digital ICs, Schottky transistors are preferred over normal transistors because of their
(A) Lower Propagation delay.
(B) Higher Propagation delay.
(C) Lower Power dissipation.
(D) Higher Power dissipation
Ans: A
Ans: B
4) Often a common-collector will be the last stage before the load; the main function(s) of this stage is
to……..
(A) provide voltage gain
(B) provide phase inversion
(C) provide a high-frequency path to improve the frequency response
(D) buffer the voltage amplifiers from the low-resistance load and provide impedance matching for
maximum power transfer
Ans: D
7) If gain is +6db and input power is 1mW for an amplifier; what is output power
(A) 1 mW
(B) 0 mW
(C) 4 mW
(D) None of these
Ans: C
Explanation: Gain in dB=10 log(Po/Pi)
So, 6=10 log(Po/1mW)
Po= 3.9mW or 4mW approx.
9) What is the average voltage when a rectangular wave's base line voltage is 20 V, its peak-to-peak
voltage is 50 V, and its duty cycle is 20%?
(A) 26 V
(B) 30 V
(C) 40 V
(D) 45 V
Ans: B
19) In terms of circuit components, what does the term pole refer to? (repeated at the end too)
(A) A single RL circuit
(B) A single RC circuit
(C) A Cascaded amplifier
(D) A Summing Amplifier
Ans: B
Explanation: Laplace of C is 1/s means pole at origin
23) If R=20 ohm, XL=40 ohm and XC=15 ohm are connected in series and current is 1A, what will be the
supply voltage?
(A) 220V
(B) 32V
(C) 100V
(D) 40V
Ans: B Explanation: Vs=I x sqrt {(R^2 +(XL-XC)^2)}
24) Load impedance ZL=200 ohm, Zi=50ohm then characteristic impedance Zo=
(A) 10000 ohm
(B) 100 ohm
(C) 200 ohm
(D) 4 ohm
Ans: B
Explanation: Zo= Sqrt (ZLxZi)= 100ohm
25) For a triangular and Sawtooth waveform the RMS voltage or current equals
(A) 0.707times peak value
(B) 0.577 times peak value
(C) 0.577times average value
(D) 0.707times Rms value
Ans : B
27) Which of the item below is an advantage of a shunt regulator over a series type?
(A) Has an inherent current limiting
(B) Efficient than series regulator because of its component used
(C) A non-regulating device
(D) None of the choices
Ans: A
28) Using electronic devices as switches, what is(are) the general methods of controlling electrical
power?
(A) static switching
(B) phase control
(C) zero voltage switching
(D) All of the above
Ans: D
29) For a constant input voltage to an integrator, why is the voltage across the capacitor linear?
(A) Capacitor diode does not dissipate heat
(B) Capacitor current is constantly changing
(C) Capacitor current is linear
(D) Capacitor current is constant
Ans: D
30) The output of a signal is given. Thermocouple temperature is shown with voltage , find X
T 0 5 10
V -6.66 X -6.82
X=
(A) -2.66
(B) -6.74
(C) …
Ans: A
32) For the system in the given figure. The transfer function C(s)/R(s) is
(A) G1 + G2 + 1
(B) G1 G2 + 1
(C) G1 G2 + G2 + 1
(D) G1 G2 + G1 + 1
Ans: C
Explanation:
Transfer function = (G1 + 1) G2 + 1 = G1 G2 + G2 + 1
33) Which one is correct:
Ans: Transient Response effects the Speed While Steady-State Response makes accuracy
34) A circuit was given having transistor whose base was grounded ,
So IB=0A hence, Vo=Vce=5v
Options were :
(A) 5V (B) 3.1V (C)2.5V (D) 0V
35) In terms of circuit components, what does the term pole refer to?
(E) A single RL circuit
(F) A single RC circuit
(G) A Cascaded amplifier
(H) A Summing Amplifier
Ans: B
Explanation: Laplace of C is 1/s means pole at origin
36) Theoretically electromagnetic radiation field strength varies in inverse proportion to the square of
the distance, but when atmospheric attenuation effects and the absorption of the terrain are taken
into account the attenuation can be as high as the inverse _______ power of the distance.
(A) Third
(B) Fourth
(C) Fifth
(D) Sixth
Ans: D
(A) 16 Mbps
(B) 24 Mbps
(C) 48 Mbps
(D) 64 Mbps
Ans: C
Explanation: A noiseless channel can carry an arbitrary large amount of information, no
matter how often it is sampled.
If each sample is 3 bits, the channel can send 16 x 106 samples/sec * 3 bits = 48 Mbps.
The key word here is “noiseless”. With a normal 8KHz channel, Shannon limit would not
allow this.
https://electronicspost.com/multiple-choice-questions-and-answers-on-semiconductor-diode/
https://pinoybix.org/2018/06/mcq-in-industrial-electronics-series.html
https://www.sanfoundry.com/electronic-devices-circuits-questions-answers-capacitor-filters/
https://www.electricaltechnology.org/2013/06/mcqs-with-explanatory-answers-1.html
https://www.indiabix.com/electronics-and-communication-engineering/automatic-control-systems/
https://www.careerride.com/
https://www.mcqslearn.com/electronics/electronic-circuit-design/quiz/quiz.php?page=73
http://www.allexamreview.com/2017/06/electronics-and-communication.html
https://scholarexpress.com/multiple-choice-questions-mcq-sensors-transducers/
http://www.electricalunits.com/mcq-electronics-page-8/
https://electricalvoice.com/oscillator-mcqs/
https://www.analyzemath.com/trigonometry_questions/trig_graphs.html
http://ece-board.blogspot.com/2011/06/malvino-chapter-24-mcq-with-answers.html
https://www.electrical4u.com/electrical-engineering-articles/electronics-devices/
https://competitive-exam.in/questions/discuss/for-a-triangular-and-sawtooth-waveform-the-rms
https://www.academia.edu/6022733/TYPICAL_QUESTIONS_and_ANSWERS_PART_-
I_OBJECTIVE_TYPE_QUESTIONS?email_work_card=view-paper
https://www.objectivebooks.com/2017/04/passive-filters-mcq-practice-test-set-01.html
https://edurev.in/course/quiz/-1_test/9872247e-8740-45e8-bee4-8ba0a19a756f