Professional Documents
Culture Documents
1. Chip loose concrete in the honeycomb until we reach the solid part of the beam.
3. Seal the edges of the phenolic board by cement and epoxy mixture to avoid leakage of the epoxy.
4. Chip small hole on the beam for the access of the epoxy.
5. Mix 1 part of structural epoxy (Omni Grout 035) and ¾ part of silica sand.
6. Continuously pour the structural epoxy-silica sand mixture to the hole until it completely occupied the
honeycombs.
Prepared by:
Roggie Reyes
Assistant Project Engineer
Ironcon builders and Development Corporation
Noted by:
Page 1 of 1