Marka Leino: Tarkastuskerlomos 612014
Matis Rikenen Tarcetuakertonus 572014
Kuva2
pinta ja las reunaan nahden ja akusa,
leveys 0,8 mm. oll edenryt 101mm.
Fikaoutuman alkukonta ol kohtsuorassa lain
Thermal Stress Breaks
Low stress thermal stress breakage
is indicated by a single break line
starting from the origin at the edge
(90° to the edge and surface) and
propagating 2 inches (5 cm) or more
before branching into more break
lines. Reference left sketch. Low
stress thermal breakage indicates
damaged glass edges.
High stress thermal stress breakage is
indicated by the single break line at the
origin (90° to the edge and surface)
branching into more break lines within
2 inches (Sem) of the edge). Reference
center sketch. This __ indicates
surrounding conditions or glazing
conditions are causing high stress, ¢.¢
severe outdoor shading patterns,
heating registers located between glass
and indoor shading devices, closed light
colored drapes located within 2 inches
of the glass, glazing in massive concrete
framing, etc.
basic annealed glass due to
Figure 14.2 Crack pattem in basic annealed glass due to
load failure
Example:
Reason:
Other reason
Edge pressure breakage
Mechanical point load
* short term or long term aggressive
* weak to medium intensity
to be seen at float glass, laminated se
laminated glass,
cast resin panes and ornamental glas
undersized blocks for high glass weig
too high clamping pressure by screw.
too high clamping pressure by using
wood strips without preformed tape
Characteristics: Feeding angle out of square,
continuous angle out of square,
shells of edge not or seldom present.
origin at edge to be seen