Professional Documents
Culture Documents
Modes of Operation
There are two modes of unit can set up the Dupline- Activation of the Con- connection used. If the RJ
operation for the Dupline- Safe Safety Relay Output figuration and Test Unit for connection is used, the
Safe Configuration and test module or the Safety Input both modes is done by configuration mode will be
unit: module. pressing the “Read / On” entered. If the jack connec-
1. Configuration mode and 2. button. tor is used, the Test Unit
Test Unit mode. In Test Unit mode the unit Determination of the mode mode will be entered.
can monitor the Safety units of operation is done auto-
In Configuration mode the on the DuplineSafe bus. matically according to the
Configuration Mode
When connecting to a ed!” is shown shortly in the Output Unit: Here the number of chan-
DuplineSafe Safety Relay display, followed by the text If a Safety Relay Output nels selected on the Dupline
Output module directly or to “Config Unit begin?”. Now module is connected the channel generator must be
a Safety Input module pressing the “Read / On” or following screen will now be entered. Press ”No” to
through the Adapt 7380, the “Yes” button will start shown: change, press ”Yes” to
configuration mode is the reading of the connect- approve and continue.
enabled. This is done auto- ed unit, “Reading Configu-
matically when activating ration” is shown in the dis-
the unit where the text play while reading is in
“Configurator mode select- progress.
Additional Information
Scope of supply:
1 x Conf./Test unit GS7380 0080
1 x Coding adaptor ADAPT 7380
1 x Programmer cable GAP CAB
1 x Test cable GTU8 GRIP CAB