INTERNAL FINISHING TOOL HOLDERS (BORING BARS) WITH
INDEXABLE INSERTS COMMONLY USED IN MACHINE SHOP-I FOR
LIGHT MACHINES LIKE H-22, H-26, NH-22 etc.
1) Tool Holder S25T PCLNR 12 (i.e., Dia. 25 finishing boring bar of
length 300mm) 2) Tool Holder S32U PCLNR 12 (i.e., Dia. 32 finishing boring bar of length 350mm)
Where, S = Solid steel tool
25/32 = Dia. of cylindrical shank (25mm for sl.no.1 and 32mm for sl.no.2) T /U = Length of tool (300mm for sl.no.1 and 350mm for sl.no.2) P = Type of clamping (inside lever type) C = Shape of insert (rhomboidal, 80 deg.) L = Style of tool (approach angle 95 deg.) N = Clearance angle of insert ( 0 deg.) R = Hand of cutting (right hand) 12 = Size of insert ( one side of rhombus=12 mm)
3) Insert for above tool holder:
This may be designated as below
“Insert CNMG 120408, uncoated hard metal type, of grade P-40.”
Where, C = Shape of insert (rhombic with nose angle 80 deg.)
N = Clearance angle ( 0 deg. ) M = Tolerance in thickness, corner point, inscribed circle etc. G = Fixing / or chip breaker detail (with hole, with chip breaker on both side) 12 = Insert size (12mm) 04 = Insert thickness (4.76mm) 08 = Corner radius (0.8mm)
This is ISO designation and may be procured on non-proprietary
basis with item description as given in 3 above. For item 3 similar vocab no. is 09205320737. 4) Spares for above tool holders (item 1 & 2): Spares may be designated as below. As the spares for tool holder 1 & 2 are same only one designation is required.
a. Shim for tool holder S25T PCLNR 12
b. Shim pin for tool holder S25T PCLNR 12 c. Lever for tool holder S25T PCLNR 12 d. Screw for tool holder S25T PCLNR 12 e. Key for tool holder S25T PCLNR 12 For first time procurement the above spares (as mentioned in 4 above) are to be procured by the item description as given in a to e above and afterwards these may be procured on proprietary basis from the supplier of above tool holders with ordering code of these spares.
NOTE: FOR ANY OTHER DESIGN DIFFERING FROM
ABOVE TOOL HOLDERS, ISO DESIGNATION OF TOOL HOLDERS MAY BE REFERRED IN KNOWLEDGE MANAGEMENT PIECE (BSP-2005-0276, TURNING TOOLS WITH INDEXABLE INSERTS) AND FOR INSERTS KNOWLEDGE MANAGEMENT PIECE (BSP-2005-0277, ISO DESIGNATION FOR THROW AWAY INSERTS) MAY BE REFERRED