Professional Documents
Culture Documents
Learning Outcomes
LO.1. Explain the essentials of welding
LO 2. Deposit weld beads on plates
LO 3 Weld plate in single pass Fillet joint in 1F,2F,3F,4F,All position
LO 4 Weld plates in multiple pass Fillet joint in1F,2F,3F,4F, All position
LO 5 Weld plates single pass groove joints in flat, horizontal, and vertical position
LO 6 Weld plates in multiple pass groove joints in flat, horizontal, and vertical over-head position
INTRODUCTION :
This unit covers the skills, knowledge and attitudes required in welding carbon steel plates and pipes using SMAW process.
LEARNING ACTIVITIES:
Learning Outcome:. 5 Weld plates single pass groove joints in flat, horizontal, and vertical position
4. Weld defects, Power point Read Answer self-check Compare to CBLM on performing 15hours
causes and presentation information no. 5.2.1. answer key groove welding on
remedies Discussion sheet 5.1.4 on 5.1.4 carbon steel pipes
weld defects,
causes and
remedies
6. Welding Power point Read Answer self-check Compare to CBLM on performing 12hours
techniques and presentation information no. 5.1.6 answer key groove welding on
procedures sheet 5.1.6 on 5.1.6 carbon steel pipes
Welding
techniques and
procedures
7. Safe welding Self- paced Read Answer self-check Compare to CBLM on performing 13hours
practices Discussion information no. 5.1.7 answer key groove welding on
sheet 5.1.7 on 5.1.7 carbon steel pipes
Safe welding
practices
ASSESSMENT METHOD
Written/oral
Direct observation
Return demonstration
Prepared by:
ERWIN MACALINO
SPTI