Professional Documents
Culture Documents
This is a class AB audio power amplifier circuit which built using a TDA2002 or TDA2003
power amplifier IC module. These are replacements for the original LM383 which is no
longer available. It is easy to build and has a minimum of external components. The
module has both short circuit protection and thermal protection. It can drive loads as low
as 1.6 ohm and is capable of delivering over 10 watts from a 16 V supply.
The TDA2002 and TDA2002A are integrated circuit amplifiers specially designed for use
in car radios, where the adverse electrical environment places great demands upon the
reliability of circuits.
The supply voltage may be anywhere between +8 and +18V, and the IC will accept
transient voltage peaks of up to 28V without damage. The IC can supply a short-circuit
output current of 3.5 A and 15W of power at a case temperature of 90°C. At a supply
voltage of 14.4V (fully charged battery ) the maximum output power is at least 4.8W,
and typically 5.2W into a 4Ω load.
We are using cookies to give you the best experience on our website.
You can nd out more about which cookies we are using or switch them off in settings.
Accept
The IC will, in fact, drive load impedance’s as low as 2Ω, in which case the maximum
output power is at least 7W and typically 8W. The above power are all measured at 10%
distortion, but obviously at lower output powers the distortion is much less (Typically
0.2% ).
Specifications:
THD: < 0.2% (1W, 4 ohm load) Gain: 40 dB maximum. S/N ratio : > 80 dBA. (G =
20 dB) > 60 dBA (G = 40 dB)
Frequency response: < 20 Hz to > 40 kHz (-3dB, 4 ohm load)
Input level:
< 100 mV for full output (G = 40 dB)
< 1V for full output(G = 20 dB)
We are using cookies to give you the best experience on our website.
You can nd out more about which cookies we are using or switch them off in settings.
Accept
Amp TDA2002 PCB
layout
Capacitors
C1 10µF 25V Electrolytic Capacitor
C2 1000µF 25V Electrolytic Capacitor
C3 470µF 25V Electrolytic Capacitor
C1 , C3 100nF Polyester or ceramic capacitor – 100n, 0.1, .1, or 104
C2 39nF Polyester or ceramic capacitor – .039, 39n or 393
Semiconductors
IC1 TDA2002 or TDA2003
Connectors
IN Two-terminal connector signal input
OUT Two-terminal connector Audio Output
PWR Two-terminal connector Power Supply
Download the PDF for the PCB for circuit power amplifier
Toni
http://xtronic.org/
Xtronic.org blog author. Electronics technician for the technical school of Brasilia - Brazil. Interested in
electronics, circuits and technology in general.
We are using cookies to give you the best experience on our website.
You can nd out more about which cookies we are using or switch them off in settings.
Accept