Professional Documents
Culture Documents
• FABRICATOR is to ensure that all internal and external handrail/prism fitting to not impede or
interfere with proposed access points to equipment and control units.
• Check if the identification markings are clearly painted at the top elevation of the
jacket for offshore identification:
o Legs B3 and B4
o Legs C3 and C4
1 • Check all grating welds/clips are firmly secured.
• Inspect the upending padeyes-based on the information provided by the
CONTRACTOR.
o Location
o Details (as per technical design provided by the CONTRACTOR)
• Compare padeyes to the shackle sizes that are provided.
• Identify the position, where the topside hinged ladder would land.
• Check all shackles actual pin diameter/holes size.
• Compare weight control reports provided by the FABRICATION with the design
calculations provided by the CONTRACTOR.
• Check for the adequate protection against damage of the paint from rigging, tie
down and during installation.
• Inspect the cathodic anode clash with CONTRACTOR’s rigging and installation aids.