Professional Documents
Culture Documents
How To Make Simple Solar Panels
How To Make Simple Solar Panels
Materials :
1. Shiny copper sheet (1 sheet)
2. Crocodile cap (2 pieces)
3. Micro ammeter (1 piece)
4. electric stove (1 piece)
5. Clear plastic bottle topped with 1 piece
6. Table salt (2 tbsp)
7. Emery or wire brush (1 piece)
8. Scissors (1 piece)
9. Water
Steps :
1. Wash your hands first before holding the solar panel making materials so that no fat or oil will stick.
2. Cut copper wire with the size exactly the size of the heating panel in the electric stove.
3. The cut copper is then cleaned using sandpaper or wire brush so that there is no impurities that can
inhibit the process of absorption of solar energy.
4. After the copper is cleaned then put it on an electric stove and then burn with the highest voltage.
5. Perform this burning process for 30 minutes until the copper layer turns black.
6. After the combustion process is complete, then leave the copper layer to cool naturally for about 20
minutes. After the cold, the copper layer will shrink so that the oxide layer shrinks.
7. Wash and scrub the copper gently with your hands under running water, do not stretch the copper
layer in this process because it can damage the corpus oxide layer needed in the manufacture of cheap
solar electricity panels.
8. Cut another copper sheet about the size of copper first and then bend both copper sheets, first and
second copper, then put in a plastic bottle. Try both copper not to contact each other.
9. Install the crocodile claws on the first copper sheet and on the second copper sheet, then attach the
cable from the second copper to the positive terminal and the cable from the first copper which is
burned to the negative terminal of the ammeter.
10. Enter the heated salt water into the bottle carefully and do not wet the crocodile claws, besides the
size of salt water should not sink the entire copper plate.
11. Test simple solar panels that have been made by putting them in the sun so that the power produced
will increase by around 33 micro amperes.
Source : http://benergi.com/langkah-untuk-membuat-panel-tenaga-surya-sederhana-sendiri
Cara Membuat Panel Surya Sederhana