Professional Documents
Culture Documents
Abstract: The experiment is about to demonstrate Current Analysis, we can also use node analysis to
mesh and nodal analysis using constructed calculate the voltages around the loops, but we
Wheatstone bridge with the appropriate resistors must not get confused while using kichoff’s
that I had choosed and get the experimental voltage law for mesh analysis and kirchoff’s
measurements and observe the difference between current law for nodal analysis.
theoretical and simulation results . From the circuit
I had to measure the voltage drops and the current
flows at all branches. I used a breadboard , wires ,
and a 5v dc power supply to build the complete II. EXPERIM
circuit. Apart from that , a multimeter was used to III. ENTS SET UP
measure the voltage and the current in the circuit.
From that result I had gained , I would use mesh The tasks began with choosing 6 appropriate
analysis and nodal analysis to find a calculated resistor of any different values in the range KOhm
results. After that , i had to compare between the and identify the values of R1,R2,R3,R4,R5 and R6
actual reading and the calculated results whether its using multimeter .Multimeter is a device used to
match with the analysis . measure voltage, current and resistance. Multimeter
might be analog type multimeters or digital
Keywords: Mesh , Nodal , Multimeter ,Compare multimeter. The multimeter we use was analog
multimeter that have great detecting slow voltage
changes, as you will the see the needle moving over
the scale.
I. INTRODUCTION