Professional Documents
Culture Documents
Content ....................................................................................................................................... 1
Electrical Power Engineering ..................................................................................................... 2
Energy management .................................................................................................................. 2
EUC Energy management .......................................................................................................... 4
EUC 3 Manual and automatic compensation of reactive power ................................................. 4
The Lucas-Nülle training systems have been designed in anticipation of the newest developments:
Smart measuring instruments which avail of various communication interfaces (e.g. LAN, RS485, USB)
and control elements
SCADA Power Engineering Lab software for the intelligent control and evaluation of the "Smart Grid" with
soft plc
Permits investigation of dynamically alternating loads and power generation inside the laboratory
Modular integration of renewable energies into the smart grid using protective engineering
Wind power plant with doubly-fed asynchronous generator (DFIG) with mains sychronisation
Energy management
For economic and environmental reasons, a rational use of energy is becoming increasingly important.
Exercises on manual and automatic compensation of reactive power as well as experiments on reducing peak
loads through measurements with active-current and maximum-demand meters demonstrate how the load on a
mains supply network can be reduced and evenly distributed over a 24-hour period. An analysis of the power
supply grid and connected consumers (loads) is necessary for effective use of the involved measurement
techniques. Accordingly, each experiment permits a detailed investigation of static, dynamic, symmetric and
asymmetric loads. Protection of electrical consumers is another important training subject.
In this case, a three-phase asynchronous motor coupled with the servo machine test stand is used as a
dynamic load. The active and reactive powers (motor‘s cos-phi) depend on the motor load and are therefore not
constant. The servo machine test stand can be used to drive the asynchronous motor, thereby feeding active
power into the three-phase network.
Reactive power compensation in alternating voltage networks is designed to reduce undesirable reactive current
and resultant reactive power of consumers. In this process, capacitive loads are connected to all inductive loads
via a central feed point. The opposing, capacitive reactive power arising here is ideally of the same magnitude as
the installed, inductive reactive power. This reduces undesirable reactive currents, and none of the systems
needed to supply the reactive current has to be over-dimensioned.
Training contents:
Weight: 2.5kg
Capacitance values:
State 1: 3 x 2 µF, 450 V, 50 Hz
State 2: 3 x 4 µF, 450 V, 50 Hz
State 3: 3 x 8 µF, 400 V, 50 Hz
State 4: 3 x 16 µF, 400 V, 50 Hz
Weight: 2 kg
3 Three Phase Power Quality Meter with display and long-term CO5127-1S 1
memory
Pulse measurement
Event logging
Realtime clock
Ethernet interface
Current: 5A
Measurement accuracy:
Voltages 0,2%
Currents 0,2%
Reactive power 1%
Weight: 2kg
Special features:
Training contents:
Dynamic loads
The 'SCADA Viewer' is a software program used for the control and
monitoring of power engineering systems. With the software it is
possible to display all measured values and operating states inside
the system in real time on the existing measuring instruments.
Important parameters and signals can be controlled by the software.
Using the 'SCADA Viewer' projects in power engineering are not only
made transparent but readable.
Software functions:
1x 1m yellow
2x 2m yellow
Weight: 2kg
Contact-protected
Contact-protected
Contact-protected
Contact-protected
Table top:
Frame:
Dimensions:
2 Cable clips
Additionally included:
Cable management set for installing cables along the profiles of the
aluminium lab system furniture in the SybaPro range