Professional Documents
Culture Documents
Name :
Date :02/11/2019
Class : Duration : 30min
3. The impulse response of a continuous time LTI system is h (t) = 𝑒 −4𝑡 u (t-2). The system is
a. Causal and stable c. Causal but not stable
b. Stable but not causal d. Neither Causal nor stable
11. A network consists only of independent current sources and resistors. If the values of all the current sources
are doubled, the values of node voltages will
a. Remains same b. be doubled c. be halved d. be quadrupled
12. A 20µF capacitor has a voltage of 5v across it at t = 0 second. If a constant current of 25mA flows
through the capacitor, then how long will it take for the capacitor to charge upto 200µC?
a. 12ms b. 8ms c. 2ms d. 4ms
13. The function in MATLAB, to solve ordinary differential equations by mean of trapezoidal rule method is
a. ode15 b. ode113 c. ode23 d. ode45
15 .Which library call status support the implementation of control module especially for controlling all other
associated modules in time-slice fashion?
a. Dynamic Linkage Library (DLL) Call
b. Timer Call of MFC Library
c. Modulo Call of MFC Library
d. None of the above
16. Which bridge is utilized in signal conditioning circuits for balancing purpose?
a. Maxwell Bridge
b. Wheatstone Bridge
c. Wein Bridge
d. Kelvin Bridge
17. What should be the value of resistance between collector and ground (R0) for below drawn schematic of transistor
amplifier, comprising h-parameters as hie = 1.1 kΩ, hfe = 50, hre= hoe = 0 with short-circuit capacitors?
a. 5.2 k
b. 2.3 k
c. 1.1 k
d. Infinity
18. On which factor/s do/does the value of thermal resistance depend?
a. Size of transistor
b. Type of cooling system
c. Type of heat transfer mechanism
d. All of the above
19 How does the value of mutual inductance vary between two coils of an inductive transducer?
a. By the variation in self-inductances and coupling coefficient
b. By the variation in number of turns
c. By the variation in reluctance and permeability
d. All of the above
20. Which phenomenon results in producing the difference in resistance due to incapability to regain its original
physical form before an application of stress to the gauge element?
a. Hysteresis Effect
b. Barkheussan Effect
c. Differentiative Effect
d. Integrative Effect
21. What is the value of gate-to-source voltage (VGS) for the circuit
diagram shown below?
a. 1.5 V
b. 2.9 V
c. 3.5 V
d. 4.9 V
22. Determine the output voltage of a resistance position transducer when wiper is 8cm with the utilized shaft stroke
level of about 20 cm from another end under the input voltage application of 10V with the total resistance value of
potentiometer estimated to 6V.
a. 2V
b. 4V
c. 6V
d. 8V
23. Which reversible phenomenon in a thermocouple device exhibits the absorption and liberation of heat during flow
of current through the two dissimilar copper-iron and iron-copper junctions under the application of an external e.m.f
by transforming these junctions to be hot and cold respectively?
a. Seebeck Effect
b. Peltier Effect
c. Thompson Effect
d. None of the above
24. Which active transistor results in the generation of voltage in correspondence to an illumination?
a. Piezo-electric Sensor
b. Photo-voltaic Cell
c. Thermocouple
d. All of the above
25. Which among the following are specifically the advantages of bipolar design technology?
a. A&B
b. A&C
c. B&D
d. C&D