You are on page 1of 68

NA016

PHASE & RESIDUAL OVERCURRENT


PROTECTION RELAY

MANUAL

NA016 - Manual - 08 - 2009


TABLE OF CONTENTS

1 INTRODUCTION 4
Scope and liability ...........................................................................................................................................................................................4
Applicability ......................................................................................................................................................................................................4
Conformity ........................................................................................................................................................................................................4
Technical support ............................................................................................................................................................................................4
Copyright...........................................................................................................................................................................................................4
Warranty ...........................................................................................................................................................................................................4
Safety recommendations ...............................................................................................................................................................................4
Insulation tests ................................................................................................................................................................................................4
Product identification .....................................................................................................................................................................................5
Environment .....................................................................................................................................................................................................5
Graphical conventions ...................................................................................................................................................................................5
Glossary/definitions ........................................................................................................................................................................................5
2 GENERAL 9
Preface............................................................................................................................................................................................................. 9
Photo ................................................................................................................................................................................................................ 9
Main features................................................................................................................................................................................................ 10

3 TECHNICAL DATA 11
3.1 GENERAL ............................................................................................................................................................................................................11
Mechanical data ...........................................................................................................................................................................................11
Insulation ........................................................................................................................................................................................................11
EMC tests for interference immunity .........................................................................................................................................................11
Voltage dip and interruption ........................................................................................................................................................................11
EMC tests for interference immunity .........................................................................................................................................................11
Emission ..........................................................................................................................................................................................................12
Mechanical tests...........................................................................................................................................................................................12
Climatic tests..................................................................................................................................................................................................12
Safety ..............................................................................................................................................................................................................12
Certifications ..................................................................................................................................................................................................12
3.2 INPUT CIRCUITS .............................................................................................................................................................................................. 13
Auxiliary power supply U aux ...................................................................................................................................................................... 13
Phase current input circuits ....................................................................................................................................................................... 13
Residual current input circuit..................................................................................................................................................................... 13
Binary input circuits..................................................................................................................................................................................... 13
3.3 OUTPUT CIRCUITS ........................................................................................................................................................................................... 13
Output relays ................................................................................................................................................................................................. 13
3.4 MMI .....................................................................................................................................................................................................................14
3.5 COMMUNICATION INTERFACES ...................................................................................................................................................................14
Local port ........................................................................................................................................................................................................14
Remote ports ..................................................................................................................................................................................................14
3.6 GENERAL SETTINGS ........................................................................................................................................................................................14
3.7 PROTECTIVE ELEMENTS .................................................................................................................................................................................14
Phase overcurrent - 50/51............................................................................................................................................................................14
Residual overcurrent - 50N/51N .................................................................................................................................................................15
3.8 CONTROL AND MONITORING ........................................................................................................................................................................16
Trip Circuit Supervision - 74TCS ..................................................................................................................................................................16
Circuit Breaker monitoring ..........................................................................................................................................................................16
Oscillography (DFR) ......................................................................................................................................................................................16
3.9 MEASURES ........................................................................................................................................................................................................16
4 FUNCTION CHARACTERISTICS 17
4.1 HARDWARE DESCRIPTION .............................................................................................................................................................................17
Power supply board ......................................................................................................................................................................................17
CPU board...................................................................................................................................................................................................... 18
Input board .................................................................................................................................................................................................... 18
MMI (keyboard, LED and display) ............................................................................................................................................................. 18
4.2 SOFTWARE DESCRIPTION ............................................................................................................................................................................. 19
Kernel ............................................................................................................................................................................................................. 19
Drivers ............................................................................................................................................................................................................ 19
Application..................................................................................................................................................................................................... 19
Base protocol (kernel) ................................................................................................................................................................................. 19
Calibration (kernel)....................................................................................................................................................................................... 19
Communication (drivers) ............................................................................................................................................................................. 19
MMI (drivers) ................................................................................................................................................................................................ 19
Data Base (application/drivers) ................................................................................................................................................................. 20

22 NA016 - Manual - 08 - 2009


Self-test (application) .................................................................................................................................................................................. 20
Development tools ....................................................................................................................................................................................... 20
4.3 I/O DESCRIPTION ..............................................................................................................................................................................................21
Metering inputs .............................................................................................................................................................................................21
Signal processing ..........................................................................................................................................................................................21
Use of measured values...............................................................................................................................................................................22
Binary inputs ................................................................................................................................................................................................. 23
Output relays ..................................................................................................................................................................................................24
LED indicators ................................................................................................................................................................................................25
Communication interfaces...........................................................................................................................................................................26
4.4 PROTECTIVE ELEMENTS .................................................................................................................................................................................27
Rated values...................................................................................................................................................................................................27
Phase overcurrent - 50/51........................................................................................................................................................................... 28
Residual overcurrent - 50N/51N ................................................................................................................................................................ 30
4.5 CONTROL AND MONITORING ........................................................................................................................................................................32
Data Logger ....................................................................................................................................................................................................32
Trip circuit supervision - 74TCS...................................................................................................................................................................32
Circuit breaker supervision .........................................................................................................................................................................34
Test ..................................................................................................................................................................................................................35
Oscillography ................................................................................................................................................................................................35

5 MEASURES, LOGIC STATES AND COUNTERS 36


Measures........................................................................................................................................................................................................36
Circuit breaker ...............................................................................................................................................................................................36
Counters..........................................................................................................................................................................................................36
Fault recording - SFR ....................................................................................................................................................................................36
Event recording - Events ..............................................................................................................................................................................36
Setting changes - Settings ..........................................................................................................................................................................37
Info ...................................................................................................................................................................................................................37
Protections trip ..............................................................................................................................................................................................37
Self-test ...........................................................................................................................................................................................................37
Oscillography - DFR ..................................................................................................................................................................................... 38

6 INSTALLATION 39
6.1 PACKAGING ...................................................................................................................................................................................................... 39
6.2 MOUNTING ....................................................................................................................................................................................................... 39
6.3 ELECTRICAL CONNECTIONS ..........................................................................................................................................................................41
6.4 NOMINAL CURRENT I n AND I En SETTING ..................................................................................................................................................46
6.5 LED ALLOCATION ............................................................................................................................................................................................. 48
6.6 FINAL OPERATIONS ........................................................................................................................................................................................ 48
7 PROGRAMMING AND SETTINGS 49
7.1 SW ThySetter.................................................................................................................................................................................................... 49
ThySetter installation ................................................................................................................................................................................... 49
ThySetter use ................................................................................................................................................................................................ 49
7.2 MMI (Man Machine Interface) ..................................................................................................................................................................... 50
Reading variables (READ) ........................................................................................................................................................................... 50
Setting modifying (SET) ............................................................................................................................................................................... 50
Test ...................................................................................................................................................................................................................51
Communication ..............................................................................................................................................................................................52
Reset................................................................................................................................................................................................................52
DEFAULT (Option) ..........................................................................................................................................................................................52
Data/time setting (Time) ...............................................................................................................................................................................52
7.3 MENU TREE....................................................................................................................................................................................................... 53
7.4 MAINTENANCE .................................................................................................................................................................................................55
7.5 REPAIR ................................................................................................................................................................................................................55
7.6 PACKAGING .......................................................................................................................................................................................................55
8 APPENDIX 56
8.1 APPENDIX A1 - Inverse time IEC curves .....................................................................................................................................................56
Mathematical formula ..................................................................................................................................................................................56
Phase overcurrent 50/51 - Standard inverse time curve (IEC 60255-3/BS142 type A) ......................................................................57
Phase overcurrent 50/51 - Very inverse time curve (IEC 60255-3/BS142 type B) ............................................................................. 58
Phase overcurrent 50/51 - Extremely inverse time curve (IEC 60255-3/BS142 type C) .................................................................... 59
8.2 APPENDIX B1 - I/O Diagram .......................................................................................................................................................................... 60
8.3 APPENDIX B2 - Interfaces ..............................................................................................................................................................................61
8.4 APPENDIX B3 - Connection diagrams ..........................................................................................................................................................62
8.5 APPENDIX C - Dimensions ..............................................................................................................................................................................65
8.6 APPENDIX D - Revisions history ....................................................................................................................................................................66
8.7 APPENDIX E - EC Declaration of conformity ................................................................................................................................................67
NA016 - Manual - 08 - 2009 3
1 INTRODUCTION
Scope and liability
This document describes the functions, the technical data of NA016 devices; instructions for mount-
ing, setting and commissioning are included.
This manual has been checked out, however, deviations from the description cannot be completely
ruled out, so that no liability in a legal sense for correctness and completeness of the information or
from any damage that might result from its use is formally disclaimed.
The information given in this document is reviewed regularly; any corrections and integration will be
included in subsequent editions that are identified by the date of revision.
We appreciate any suggestions for improvement.
We reserve the right to make technical improvements without notice.

Applicability
This manual is valid for NA016 devices with firmware version 1.00 and following.
Revision history is listed in appendix.

Conformity
The product complies with the CEE directives:
• EMC Council Directives: 89/336/EEC
• Low voltage Directives: 73/23/EEC

Technical support
Contact: THYTRONIC Technical Service www.thytronic.it

Copyright
All right reserved; It is forbidden to copy, modify or store material (document and sw) protected by
copyright without Thytronic consent.

Warranty
Thytronic warrants devices against defects in materials and workmanship under normal use for a
period of ONE (1) YEAR from the date of retail purchase by the original end-user purchaser (“War-
ranty Period”).

Safety recommendations
The warming contained in this document are all-important for safety; special attention must be paid
to the following symbols:

Death, severe personal injury or substantial property damage can result if proper precautions
WARNING are not taken.

CAUTION Minor personal injury or property damage can result if proper precautions are not taken

Installation and commissioning must be carried out by qualified person; Thytronic assumes no re-
sponsibility for damages caused from improper use that does not comply all warning and caution in
this manual.
In particular the following requirements must be met:
• Remove power before opening it.
• Verify the voltage absence by means suitable instrumentation on relay connections; attention must
be paid to all circuits supplied by external sources (binary input, CT, etc...)
• Care must be taken when handling metal parts (front panel, connectors).

Settings must be established on the basis of a coordination study.


CAUTION Numerical values inside examples have educational purpose only; they don’t be used, in no way,
for actual applications.

Insulation tests
After insulation tests, hazardous voltages (capacitor charges,...) may be arise; it is advisable to grad-
ually reduce the test voltage avoiding to erase it abruptly.

44 NA016 - Manual - 08 - 2009 INTRODUCTION


Product identification
Each device is equipped with:
• Identification label installed on the front side with following informations: code number, phase and
residual nominal currents, auxiliary voltage range and CE mark:

In 5A 1A 5A In Rated 50...500A/Extended 50...1250A


IEn 5A 1A 5A IEn 5A 1A 5A
UAUX 24-230 Vac/dc UAUX 24-230 Vac/dc
1 50-51 1 50-51
2 50N-51N 2 50N-51N
3 CB OPEN 3 CB OPEN
4 CB CLOSED 4 CB CLOSED
5 TCS 5 TCS

NA016#xxx0 NA016#xxx1

• Test label with following informations: data, serial number and test operator signature.

Environment
The NA016 device must be employed according to the environment conditions shown (see technical
data).
In case of different environment conditions, appropriate provisions must be provided (conditioning
system, humidity control, etc...).
If contaminants are present (dust, corrosive substances, etc...), filters must be provided.

Graphical conventions
The CEI/IEC and ANSI symbols is employed where possible:
e.g.: 51 = ANSI code concerning the overcurrent element.
Following text formats are used:
The ThySetter[1] menu:
Phase overcurrent -50/51
The parameter description (measures, thresholds, operate time,...) and related value:
First threshold 50/51 definite time
I>def
The display messages (MMI) are shown as:
NA016
Notes are highlighted with cursive letters inside colored bar

Note: Useful description note

Glossary/definitions
I En Relay residual nominal current
I Enp Residual CT primary nominal current
In Relay phase nominal current
I np Phase CT primary nominal current
50/51 Phase overcurrent ANSI code
50N/51N Residual overcurrent ANSI code
74CT CT supervision
74TCS Trip Circuit Supervision

DFR Digital Fault Recorder (Oscillography)


SER Sequential Event Recorder
SFR Sequential Fault Recorder
ANSI American National Standard Institute
IEEE Institute of Electrical and Electronics Engineers
IEC International Electrotechnical Commission
CENELEC Comité Européen de Normalisation Electrotechnique

52 o CB (Circuit Breaker) Circuit Breaker


52a Auxiliary contact in the breaker that is in the same position as the
breaker. It can be assigned to a binary input to locate the CB posi-
tion (Breaker failure and/or CB diagnostic functions). (52a open = CB
open)
52b Auxiliary contact in the breaker that is in the opposite position as the
breaker (52b open = CB closed)
K1...K4 Output relays
tTR1... tTR4 Output relay minimum pulse width
Latched Output relay with latched operation (manual reset) Output relay with
latched operation (automatic reset)

Note 1 The graphic interface and the operation of the ThySetter software are described in the relative chapters

INTRODUCTION NA016 - Manual - 08 - 2009 5


No-latched Output relay with no-latched operation (automatic reset)

CT or TA Current Transformer
LPCT Low Power Current Transformer

P1 IEC nomenclature for primary polarity mark of CTs (as an alternative to


a ANSI dot)
P2 IEC nomenclature for primary polarity mark of CTs (as an alternative to
a ANSI no-dot)
S1 IEC nomenclature for secondary polarity mark of CTs (as an alternative
to a ANSI dot)
S2 IEC nomenclature for secondary polarity mark of CTs (as an alternative
to a ANSI no-dot)
Self test Diagnostic
Start Leave an initial condition or reset condition (Pickup)
Trip Operation (with operate time)

Operating time Duration of time interval between the instant when the character-
istic quantity in reset condition is changed, under specified condi-
tions, and the instant when the relay operates
Dropout ratio The ratio of a reset value to an operate value in well-specified con-
ditions. The dropout ratio may be lower or greater than 1 according
as an over or under element is considered
Reset time Duration of the time interval between the instant when the charac-
teristic quantity in operate condition is changed, under specified
conditions, and the instant when the relay operates.
The stated reset time is related to a step variation of characteristic
quantity in operate condition to the reset condition.
Overshoot time The critical impulse time for a relay which is in its reset condition,
is the longest duration a specified change in the input energizing
quantity(ies) (characteristic quantity), which will cause the relay
to change to operate condition, can be applied without the relay
switches. The overshoot time is the difference from the operate time
and the critical impulse time.
The declared values for the overshoot time are applicable with the
lower setting value of the operation time.
MMI (Man Machine Interface) Operator front panel

ThySetter Setting and monitoring software


Log file A text file that lists actions that have occurred (ThySetter).
J2SE Java Platform Standard Edition
Sw Software
Fw Firmware
Upgrade Firmware upgrade
XML eXtensible Markup Language

66 NA016 - Manual - 08 - 2009 INTRODUCTION


Symbols

I>> Threshold setting (e.g. pickup I>>).


The value is available for reading and is adjustable by means ThySetter + MMI.

I Limit block (I>> threshold).


I ≥ I>>
I L1
I L2 Ma x [I L1 ,I L2 ,I L3 ] Computation block (Max phase current)
I L3

Curve type (definite/inverse time)


T 0

Logic internal signal (output); may be a logical state (e.g.I>> Start) or a numerical value
I>> Start
It is available for reading (ThySetter + communication interface)

Logic external signal (intput); may be a command coming from a binary input or a sw command
IPh Block2
It is available for reading (ThySetter + communication interface)

Internal signal (e.g. Breaker Failure output state concerning to the 2nd threshold of the 50 element)
I>> BF_OUT It is not available for reading (missing arrow)

Switch

& & AND and NAND logic gates

≥1 ≥1 OR and NOR logic gates

=1 EXOR logic gate

INPUT

t ON t ON t ON t ON t ON

T 0 ON delay timer with reset (t ON delay)


RESET OUTPUT

RESET
t

INPUT
t ON
ON delay timer without reset (t ON delay) t ON t ON t ON
T 0

OUTPUT

INPUT
t DROP
OFF delay timer (dropout) without reset (t DROP delay) t ON t DROP t ON
0 T

OUTPUT

Symbols.ai

INTRODUCTION NA016 - Manual - 08 - 2009 7


INPUT

t DROP t ON t ON t DROP t ON t DROP

0 T OFF delay timer (dropout) with reset (t DROP delay)


RESET OUTPUT

RESET t DROP
t

INPUT
t TR
Minimum pulse width operation for output relays (t TR) t TR t TR
0 T

OUTPUT

INPUT

Latched Latched operating mode for output relays and LEDs

OUTPUT

INPUT

t TR t TR
Pulse operating mode for output relays
t TR
OUTPUT

Symbols1 .ai

88 NA016 - Manual - 08 - 2009 INTRODUCTION


2 GENERAL
Preface
The relay type NA016 can be used in radial networks as feeder or power transformer protection.
In solidly grounded systems the residual overcurrent protection can be used on feeders of any length,
while in ungrounded or Petersen coil and/or resistance grounded systems, the residual overcurrent
protection can be used on feeders of small length in order to avoid unwanted trippings due to the
capacitive current contribution of the feeder on external ground fault.
The NA016 protection relay may be shipped with traditional CTs or low power (LPCT) current inputs.

Following input circuits are available:


• Three phase current and one residual current inputs with nominal currents independently select-
able at 1 A or 5 A using DIP-switch.
• Three binary inputs.

In addition to the main protection element, the Trip Circuit Supervision (TCS) is also provided.
Setting, programming and reading operations must be effected by means of Personal Computer with
ThySetter software or by means of remote communication interface (RS485 bus); all operations must
be performed through MMI.
The NA016 hardware case is suitable for flash and rack mounting
Other options are:
• Auxiliary power supply operating range.
• Communication protocols (Modbus or IEC60870-5-103).

Photo

GENERAL NA016 - Manual - 08 - 2009 9


Main features
• Metallic case.
• Backlight LCD 2x16 Display.
• Eight LEDs that may be joined with matrix criteria to many and various functions.
• RESET key to clear LED indications and latched output relays.
• Free settable three binary inputs.
• Independently settable for start, trip, self-test and control four output relay (K1...K4) Each output
relay may be set with normally energized or normally de-energized operating mode and manual or
automatic reset (latched/no-latched).
• Rear RS485 port, with ModBus protocol.
• RS232 front serial port (local communication for Thysetter).
• Real time clock with super capacitor backup.

The most significant constructive features are:


• Galvanically insulated input and output circuits (communication and binary circuits included).
• Fast sampling rate for inputs.
• Optimum filtering of input signals through combined use of analog and digital filters.
• Traditional electromechanical-type final output contacts with continuous monitoring of control coil
continuity.
• Auxiliary supply comprising a switching-type voltage stabilizing circuit having a very wide working
range and a very small power dissipation
• Nominal frequency: 50 or 60 Hz.

The most significant operating features are:


• Programming of operating modes and parameters by means of the front keys and alphanumeric
display, with a programming procedure based on carrying out guided selections and on explicit and
immediate signalling of the operations being performed, so that such procedure can be carried out
without coding tables or mnemonic informations.
• The feature modification operations do not interrupt the normal functions of the relay.
• Impossibility of programming unacceptable parameter values, thanks to the automatic limitation of
top and bottom scale values for the relative setting ranges.
• Currents are sampled 64 times per period and measured in the effective value (RMS) of the funda-
mental component using the DFT (Discrete Fourier Transform) algorithm and digital filters.
• The fault recorder (SFR) runs continuously capturing in circular mode the last twenty events upon
trigger of binary input/output and/or element pickup (start-trip).
• The event recorder (SER) runs continuously capturing in circular mode the last three hundred
events upon trigger of binary input/output.
• Recording of the last setting changes (Logger).
• Recording of the last setting changes (Logger).
• Digital fault recorder (DFR) in COMTRADE format (oscillography).

10 NA016 - Manual - 08 - 2009 GENERAL


3 T E C H N I C A L D ATA
3.1 GENERAL
‡ Mechanical data
Mounting Flush, Rack
External dimensions 177 x 107 x 105 (high x width x depth)
Terminals screw connection
Mass 1.2 kg

Reference standards EN 60529, EN 60529/A1


• Degrees of protection provided by enclosures (IP Code)
• Front IP52
• Terminals IP20

‡ Insulation
Reference standards EN 60255-5 IEC 60255-5
High voltage test (50 Hz 60 s)
• Auxiliary power supply 2 kV
• Input circuits 2 kV
• Output circuits 2 kV
• Output circuits (between open contacts) 1 kV
• Communication interfaces 500 V

Impulse voltage withstand test (1.2/50 μs):


• Auxiliary power supply 5 kV
• Input circuits 5 kV
• Output circuits 5 kV
• Output circuits (between open contacts) 2.5 kV

Insulation resistance >100 MΩ

‡ EMC tests for interference immunity


Reference standards
• Product standard for measuring relays EN 50263
• Generic standards immunity for industrial environments EN 61000-6-2
• Electromagnetic compatibility requirements for measuring relays and protection equipment
EN 60255-26
• Apparati di automazione e controllo per centrali e stazioni elettriche
• Compatibilità elettromagnetica - Immunità ENEL REMC 02
• Normativa di compatibilità elettromeccanica per apparati e sistemi
ENEL REMC 01

‡ Voltage dip and interruption


Reference standards EN 61000-4-29
IEC 60255-22-11
Voltage dips, short interruptions and voltage variations on dc input power port immunity tests
Auxiliary power supply in dc energizing quantity
• Interruption (UT=40%) 100 ms
• Interruption (UT=0%) 50 ms
• Voltage variations (UT=80...120%) 10 s

‡ EMC tests for interference immunity


Reference standards EN 60255-22-1 IEC 60255-22-1
EN 61000-4-12 EN 61000-4-12
Damped oscillatory wave
• 0.1 MHz and 1 MHz common mode 2.5 kV
• 0.1 MHz and 1 MHz differential mode 1.0 kV
• Ring wave common mode 2.0 kV
• Ring wave differential mode 1.0 kV
Reference standards EN 60255-22-2 IEC 60255-22-2
EN 61000-4-2 IEC 61000-4-2
Electrostatic discharge
• Contact discharge 6 kV
• Air discharge 8 kV

Reference standards EN 60255-22-3 IEC 60255-22-3


EN 61000-4-3 IEC 61000-4-3
Radiated radio-frequency fields
• 80...1000 MHz AM 80% 10 V/m
• 900 MHz Pulse modulated 10 V/m

TECHNICAL DATA NA016 - Manual - 08 - 2009 11


Reference standards EN 60255-22-4 IEC 60255-22-4
EN 61000-4-4 IEC 61000-4-4
Fast transient burst (5/50 ns)
• Auxiliary power supply 2 kV
• Input circuits 4 kV
Reference standards EN 60255-22-5 IEC 60255-22-5
EN 61000-4-5 IEC 61000-4-5
High energy pulse
• Uaux (line-to-ground 10 ohm, 9 μF) 2 kV
• Uaux (line-to-line 0 ohm, 18 μF) 1 kV
• I/O ports (line-to-ground 40 ohm, 0.5 μF) 2 kV
• I/O ports (line-to-line 40 ohm, 0.5 μF) 1 kV

Reference standards EN 60255-22-6 IEC 60255-22-6


EN 61000-4-6 IEC 61000-4-6
Conducted radio-frequency fields
• 0.15...80 MHz AM 80% 1kHz 10 V
Reference standards EN 60255-22-7 IEC 60255-22-7
EN 61000-4-16 IEC 61000-4-16
Power frequency immunity tests
• Dc voltage 30 V
• 50 Hz continuously 30 V
• 50 Hz 1 s 300 V
• 0.015...150 kHz 30 V

Reference standards EN 61000-4-8 IEC 61000-4-8


Magnetic field 50 Hz
• 50 Hz continuously 100 A/m
• 50 Hz 1 s 1 kA/m

Reference standards EN 61000-4-10 IEC 61000-4-10


Damped oscillatory magnetic field
• Damped oscillatory wave 0.1 MHz 30 A/m
• Damped oscillatory wave 1 MHz 30 A/m

‡ Emission
Reference standards EN 60255-25 IEC 60255-25
EN 61000-6-4 IEC 61000-6-4
EN 55011 CISPR 11
Electromagnetic emission tests
• Conducted emission auxiliary power supply 0.15...0.5 MHz 79 dB μV
• Conducted emission auxiliary power supply 0.5...30 MHz 73 dB μV
• Radiated emission 30...230 MHz 40 dB μV/m
• Radiated emission 230...1000 MHz 47 dB μV/m

‡ Mechanical tests
Reference standards EN 60255-21-1 EN 60255-21-2 RMEC01
Vibration, shock, bump and seismic tests on measuring relays and protection equipment
• EN 60255-21-1 Vibration tests (sinusoidal) Class 1
• EN 60255-21-2 Shock and bump test Class 1

‡ Climatic tests
Reference standards IEC 60068-x ENEL R CLI 01 CEI 50
Operating temperature -25...+70 °C
Storage temperature -40...+85 °C
Permissible relative humidity 10...95 %
Atmospheric pressure 70...110 kPa

‡ Safety
Reference standards EN 61010-1
Safety requirements for electrical equipment for measurement, control and laboratory use
Pollution degree 3
Reference voltage 250 V
Overvoltage category III

‡ Certifications
Reference standards
Product standard for measuring relays EN 50263
CE Conformity
• EMC Directive 89/336/EEC
• Low Voltage Directive 73/23/EEC
• Type tests IEC 60255-6

12 NA016 - Manual - 08 - 2009 TECHNICAL DATA


3.2 INPUT CIRCUITS
‡ Auxiliary power supply U aux
Voltage
Nominal value (range)[1] 24...230 V~/-
Operative range 19...265 V~/19...300 V-

Inrush current (max)


• 24 V- 3 A, 1 ms
• 48 V- 5 A, 1 ms
• 110 V- 10 A, 1 ms
• 230 V~ 40 A, 1 ms
Frequency (for alternate voltage supply) 45...66 Hz
Max distortion factor ( for alternating voltage supply) 15%
Max alternating component (for dc voltage supply):
• Full wave rectified sine wave 100 %
• Sine wave 80 %
Power consumption:
• Maximum (energized relays, three LEDs, backlight ON) 4.5 W (U AUX = 24 V-)
• Maximum (energized relays, three LEDs, backlight ON) 9 VA (U AUX = 230 V~)

‡ Phase current input circuits


Standard CTs:
Connections M4 terminals
Relay nominal phase current I n 1 A or 5 A selectable by DIP-switch
Permanent overload 25 A
Thermal overload (1 s) 500 A
Dynamic overload (half cycle) 1250 A
Rated consumption (for any phase) ≤ 0.002 VA with I n =1 A
≤ 0.04 VA with I n =5 A
LPCT - Low Power Current Transformers:
Connections RJ45 plug
Relay nominal phase current I n 50...500 A
Extended primary current 50 A...1250 A selectable by DIP-switch
Max primary current 12.5 kA
Nominal secondary voltage (with Inp = 100 A) 22.5 mV

‡ Residual current input circuit


Relay nominal residual current I En 1 A or 5 A selectable by DIP-switch
Permanent overload 25 A
Thermal overload (1 s) 500 A
Dynamic overload (half cycle) 1250 A
Rated consumption ≤ 0.006 VA with I En =1 A
≤ 0.12 VA with I En =5 A

‡ Binary input circuits


Quantity 2
Type optocoupler
Operative range 24...265 V~/-
Min activation voltage UDIGmin 18 V
Max consumption, energized 3 mA

3.3 OUTPUT CIRCUITS


‡ Output relays
Quantity 4
Type of contacts changeover (SPDT, type C)
Nominal current 8A
Nominal voltage/max switching voltage 250 V~/400 V~
Breaking capacity:
• Direct current (L/R = 40 ms) 50 W (K1, K2 trip)
• Direct current (L/R = 40 ms) 30 W (K3, K4 signalling)
• Alternating current (λ = 0,4) 1250 VA
Make 1000 W/VA
Short duration current (0,5 s) 30 A
Minimum switching load 300 mW (5 V/ 5 mA)
Life:
• Mechanical 106 operations
Electrical 105 operations
Minimum pulse width (K1tTR...K4tTR) 0.01...0.50 s (step 0.01 s)

Note 1 The different versions must be select on order

TECHNICAL DATA NA016 - Manual - 08 - 2009 13


3.4 MMI
Display 16x2 LCD backlight module

LEDs
Quantity 8
• ON/fail (green) 1
• Start (yellow) 1
• Trip (red) 1
• Trip I>, I>>, I>>> (red) 1
• Trip IE>, IE>> (red) 1
• 52a - Circuit Breaker position (red) 1
• 52b - Circuit Breaker position (red) 1
• TCS - Trip Circuit Supervision (red) 1

Keyboard 8 keys[1]

3.5 COMMUNICATION INTERFACES


‡ Local port
Connection RJ10
Baud rate 19200 bps
Parity None
Protocol Modbus RTU®

‡ Remote ports
RS485
• Connection screw terminals
• Baud rate 1200...57600 bps
• Protocol[2] ModBus®RTU
IEC 60870-5-103

3.6 GENERAL SETTINGS


Relay nominal frequency fn 50, 60 Hz
Phase CT primary nominal current Inp [3] 1 A...1250 A
1...99 A (step 1 A)
100...1250 A (step 5 A)
Residual CT primary nominal current IEnp [4] 1 A...1000 A
1...99 A (step 1 A)
100...1000 A (step 5 A)

3.7 PROTECTIVE ELEMENTS

‡ Phase overcurrent - 50/51


I> Element
I> Curve type (I>Curve) Inverse[5] IEC/BS A, B, C

50/51 First threshold inverse time (I>inv) 0.100...2.50 In


0.100...0.999 In (step 0.001 In)
1.00...2.50 In (step 0.01 In)
Operating time (t >inv) 0.02...60.0 s
0.02...9.99 s (step 0.01 s)
10.0...60.0 s (step 0.1 s)

Nota 1 The “ O” and “ I” keys are not actives


Note 2 The different versions must be select on order
Note 3 The nominal current settings doesn’t concern the 50/51 protection elements; they must agree with nominal primary current for traditional CT
inputs or dip-switch 50...1250 A for LPCT inputs for a right reading of the phase current primary values (Reading Direct).
Note 4 The nominal current settings doesn’t concern the 50N751N protection elements; they must agree with nominal primary current of the CT inputs
for a right reading of the residual current primary values (Reading Direct).
Note 5 Standard Inverse Time (IEC 255-3/BS142 type A or SIT): t = 0.14 · t>inv / [(I/I>inv)0.02 - 1]
Very Inverse Time (IEC 255-3/BS142 type B or VIT): t = 13.5 · t>inv / [(I/I>inv) - 1]
Extremely Inverse Time (IEC 255-3/BS142 type C or EIT): t = 80 · t>inv / [(I/I>inv)2 - 1]
t: operate time
I> inv : pickup value
t>inv : operate time setting
Asymptotic reference value: 1.1 I> inv
Minimum operate time: 0.1 s
Equation is valid for 1.1 ≤ I/I>inv ≤ 20

14 NA016 - Manual - 08 - 2009 TECHNICAL DATA


I>> Element
50/51 Second threshold definite time (I>> def ) 0.100...20.0 In
0.100...0.999 In (step 0.001 In)
1.00...9.99 In (step 0.01 In)
10.0...20.0 In (step 0.1 In)
I>> def Operating time (t >> def ) 0.03...10.00 s (step 0.01 s)
I>> Reset time delay (t >> RES) 0.00...1.00 s (step 0.01 s)

I>>> Element
50/51 Third threshold definite time (I>>> def ) 0.100...20.0 In
0.100...0.999 In (step 0.001 In)
1.00...9.99 In (step 0.01 In)
10.0...20.0 In (step 0.1 In)
I>>> def Operating time (t >>> def ) 0.03...10.00 s (step 0.01 s)
I>>> Reset time delay (t >>> RES) 0.00...1.00 s (step 0.01 s)

Pickup time ≤ 0.03 s


Dropout ratio 0.95...0.98
Dropout time ≤ 0.04 s
Overshoot time 0.03 s
Pickup accuracy ± 4% ± 1% I n
Operate time accuracy 5% or ± 10 ms

‡ Residual overcurrent - 50N/51N


IE> Element
50N/51N First threshold definite time (IE > def ) 0.005...5.00 IEn
0.005...0.999 IEn (step 0.001 IEn)
1.00...5.00 IEn (step 0.01 IEn)
IE > def Operating time (t E > def ) 0.03...180 s
0.03...9.99 s (step 0.01 s)
10.0...99.9 s (step 0.1 s)
100...180 s (step 1 s)
IE > Reset time delay (t E > RES) 0.00...1.00 s (step 0.01 s)

IE>> Element
50N/51N Second threshold definite time (IE >> def ) 0.005...5.00 IEn
0.005...0.999 IEn (step 0.001 IEn)
1.00...5.00 IEn (step 0.01 IEn)
IE >> def Operating time (t E >> def ) 0.03...10.00 s (step 0.01 s)
IE >> Reset time delay (t E >> RES) 0.00...1.00 s (step 0.01 s)

Pickup time ≤ 0.03 s


Dropout ratio 0.95...0.98
Dropout time ≤ 0.04 s
Overshoot time 0.03 s
Pickup accuracy ± 4% ± 1% I En
Operate time accuracy 5% or ± 10 ms

TECHNICAL DATA NA016 - Manual - 08 - 2009 15


3.8 CONTROL AND MONITORING
‡ Trip Circuit Supervision - 74TCS
Enable (74TCS) On / Off
Operating time 40 s
Reset time delay 6s

‡ Circuit Breaker monitoring


Circuit breaker diagnostic
Diagnostic (CB Diagnostic) On / Off

‡ Oscillography (DFR)
Format COMTRADE
Number of records 2
Recording mode circular
Sampling rate 16 samples / power
Set trigger:
• Pre-trigger time 0...63 T[1] [2]
• Trigger inputs IN1, IN2, IN3
• Triggeroutputs K1...K4
• Manual Trigger ThySetter
• General Trigger general from start / trips Start, Trip
• Trigger from start / trips Start I>, I>>, ...Trip I>...

Set analog channels:


Analog 1...Analog 4
• Instantaneous currents value i L1, i L2, i L3, i E
• Phase currents I L1, I L 2 , I L 3
• Residual current IE

Set digital channels:


• Inputs IN1, IN2, IN3
• Outputs K1...K4
• General from start / trips Start, Trip

3.9 MEASURES
RMS value of the fundamental component for phase currents (I L1, I L 2 , I L 3 )
RMS value of the fundamental component for residual current (I E )

Note 1 - T = number of power cycles


Exampile, with setting T=4 the pre-trigger is 80 ms with f = 50 Hz

16 NA016 - Manual - 08 - 2009 TECHNICAL DATA


4 FUNCTION CHARACTERISTICS
4.1 HARDWARE DESCRIPTION
The following figure illustrates the basic structure of the relay.

MMI
LCD
LEDs

RS232

RS485
1A/5A
EEprom INPUT MODULE


DSP ≈
≈ CTs

RTC
≈ I L1
LPCT Setting

LPCTs CURRENT INPUTS


L1

L2

≈ I L2
50 A
L3

100 A
200 A


400 A
800 A
I L3 In=50...1250A

CPU BOARD
POWER FAIL
RESET
+10 V

+24 V
-10 V
+5 V

0V

BINARY INPUTS

POWER SUPPLY IN1


IN2 Input

IN3

RELAYS

Uaux K1...K4 Output contacts

POWER SUPPLY BOARD


hw.ai

Printed boards hold the circuit components arranged according to a modular allocation of the main
functions.
Power supply board
All the components necessary for conversion and stabilization functions are present.
Two versions are envisaged suited to the input range 24...230 V.
The circuit provides stabilized voltages of +10 V and -10 V, required for the analogue measurement,
+24V for relays and +5 V for supplying the digital circuits.
The circuit board additionally comprises:
INPUT CIRCUITS:
• Three binary input circuits,
The logical input circuits and the block circuits include photo-couplers which provide for galvanic
separation.
OUTPUT CIRCUITS:
• One block output circuit (BLOUT 1),
• Four output relays (k1...K4).

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 17


CPU board
This circuit board contains all the circuits necessary for performing the analogue and digital pro-
cessing of the signals.

Analog processing
The following are envisaged:
• Anti aliasing filter circuits, .
• Amplifier circuits for conditioning the input signals,
• Reference voltage adjustment circuits for the measurement A/D converter.
The relays usea a DSP processor operating at 40 MHzThe input currents are sampled at a frequency
of 64 samples per period by means of a dual conversion system which allows the attainment of infor-
mation pertaining to polarity and amplitude with high resolution. The measurement criterion allows
precise measurement of even those signals having a unidirectional component, such as transient
currents with overlapping exponential, which typically appear during faults.
The circuit board also houses the output relays with the corresponding command and control cir-
cuits, communication circuits, buttons, LCD display, LEDs and the key switch.
CPU
A 32 bit DSP is provided.
The following are envisaged:
• Real Time Clock circuits with oscillator and super capacitor,
• RS232 communication port,
• RS485 communication port,
Memories:
• Ram: high speed static memory
• Flash memory,
• EEprom memory: used for calibration data storage,

Input board
• Three CTs committed for phase currents acquisition,
• One CT committed for residual current acquisition.
The input circuits are suitable for 1 A or 5 A external CTs.[1]

MMI (keyboard, LED and display)


The MMI module (Man Machine Interface) includes:
• An eight keys 8 keyboard,
• a backlight LCD display,
• Eight signalling LEDs,
• RS232 communication port.

Note 1 The phase and residual nominal currents must be adjusted by means dip-switch.

18 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


4.2 SOFTWARE DESCRIPTION
The program which handles operation of the Pro-N relays is made up of three fundamental elements
shown in the following block diagram.

APPLICATION

DRIVERS

timers

sampling KERNEL

Kernel
The kernel represents the nucleus of the system: it includes the processing functions closest to the
electronic circuits; particularly the algorithms providing for the generation of the synchronisms (tim-
ers) for sampling the analogue signals and numerical processing.
The software is structured with interrupts operating with various priority levels in a non “pre-emp-
tive” task system. By means of Discrete Fourier Transform calculation, based on 32 samples/period,
information is deduced in relation to the amplitude and phase of all the current measurements; these
are constantly updated and at the disposal of all the protection and control application algorithms.
In addition, the kernel manages a service communication protocol known as Basic Protocol (BP).

Drivers
The driver library contains all the specialised modules for the command and control functions which
make up the connection ring between the kernel and the application. Examples of drivers include the
Modbus communication and LCD display modules.

Application
The application contains all the elements which carry out the protection and control functions.
The main modules are:
- diagnostic function,
- input management (logical inputs and block signal),
- protective functions,
- event recording,
- output management (output relays, LEDs and block signals).

Each element (Kernel, Drivers and Application) may, in turn, be split into modules:

Base protocol (kernel)


The module known as the Basic Protocol (BP) manages the service communication between the
kernel and the other modules through the communication buses:
- direct for internal functional call,
- SPI over synchronous serial,
- SCI over asynchronous serial.
The activities which may be performed by means of BP include:
- measurement configuration ,
- measurement reading,
- measurement enabling.

Calibration (kernel)
Calibration is performed using the base protocol functions for coordinating the calibration and test-
ing stages with the automatic testing equipement (ATE).

Communication (drivers)
The protective device implements the MODBUS RTU protocol for communicating via the RS232 inter-
face with the ThySetter setting software and via the RS485 interface with the field bus.
All major codes according to the Modbus standard are envisaged; for a complete description and
map of the addresses, please refer to the appendix mentioned further in this manual.

MMI (drivers)
This handles the menus, available both on the panel and by means of Modbus messages, which
may be run from commands using the keyboard, LEDs and LCD display.
MMI information is stored in EEPROM and may be loaded remotely by means of the basic protocol
functions.

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 19


Data Base (application/drivers)
Using modular criteria, the database is structured in three sections:
- RAM containing the volatile data,
- REE and PAR containing the data recorded in non-volatile memory.
Duplication of the data into two memory banks is envisaged with a continuous control system based
on the cross checking of the consistency of the stored data. Modification of the calibration pa-
rameters is split into two stages; in particular, data undergoing modification is placed in temporary
memory and subsequently confirmed permanently (Store command) or discarded (Clear command).
Instead, the area identified as REE is set aside for recording data which does not require the Store
command for storage, or date written directly by the application (e.g.: counters,...)

Self-test (application)
This function cyclically monitors the operation of the main hardware and software functions without
affecting the process cycle with any significant delays.
In particular, the functions monitored are the following,
- the reference voltage levels,
- output relay coil continuity,
- the program flow control by monitoring the execution times and stack area occupancy,
- checking the pilot wires (accelerated logic system),
- the consistency of the data in the REE and PAR blocks, duplicated in the EEPROM.

Development tools
For the development of the project, a CASE instrument has been developed, responsible for the opti-
mized production of software code for the management of collaboration, the database and the MMI
data and the Xml files used for communication. The automatic code generation criteria ensures the
quality of the result in terms of the reusability, verifiability and maintainability of the software life
cycle.

20 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


4.3 I/O DESCRIPTION
Metering inputs
The following input are provided:
• Three phase current inputs fo traditional CTs or LPCTs (Low Power Current Transformers).
• One residual current input.
• The nominal currents are independently adjustable at 1 A or 5 A through DIP-switches (CTs inputs).

NA016

3 phase CT current inputs

3 phase LPCT current inputs

one residual current input

sensori.ai

The input circuits are appropriately dimensioned in order to withstand the currents which arise
when a fault occurs, both in transient and steady state condition.

Signal processing
Various processing levels are involved:
• Acquisition (base level).
• Direct measures of physical channels (first level).
• Calculated measures (second level).
• Derived (third level).
The measures concerning a level are based on data worked out in the previous level.
For each level the required resources concerning the priority for tasks (conditioning circuits, DSP)
are on hand.

ACQUISITION (base level)


The input signals are sampled 24 times per power cycle

ACQUISITION

≈ INSTANTANEOUS VALUES

acquisition.ai

- iL1...iL3 phase currents instantaneous value


- iE residual current instantaneous value

From the sampled quantities, several measures are computed for protection, monitoring and meter-
ing purposes.

Samples are processed by means DFT (Discrete Fourier Transform) algorithm and the phase and
amplitude of fundamental are computed:

• Phase currents IL1, IL2, IL3

ACQUISITION
TA
i L1, i L2 , i L3 IL1, IL2 , IL3
≈ DFT (In)

IL1.ai

• Residual current IE

ACQUISITION
TA
iE IE
≈ DFT (IEn)

IE.ai

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 21


Use of measured values

Start (START) Relay K1...K4


Trip (TRIP) Relay K1...K4

Trip (CB CLOSED) LED


Trip (CB OPEN) LED
Srart (START) LED

Trip (50N/51N) LED


Binary input IN1
inary input IN2 ,

Trip (50/51) LED


Trip (TRIP) LED
inary input IN3

(TCS) LED
IL1, IL2 , IL3
i L1, i L2 , i L3

IE
iE
PROTECTION
Phase overcurrent (50/51) g g g g g g
Residual overcurrent (50N/51N) g g g g g g
CONTROL & MONITORING
Circuit Breaker Position (52b) g g g
Circuit Breaker Position (52a) g g g
Trip Circuit Supervision (TCS) g g
Diagnostic
Protection states
Input states
Output states
MEASURES
Phase current g
Residual current g
EVENT RECORDING
Event 0 g g g g g
Event 1 g g g g g
Event ... g g g g g
Event 99 g g g g g
FAULT RECORDING
Fault 0 g g g g g
Fault 1 g g g g g
Fault ... g g g g g
Fault 19 g g g g g
OSCILLOGRAPHY
Record 1 g g g g g g g g g
Record 2 g g g g g g g g g

22 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


Binary inputs
Three binary inputs are available.
The dry inputs must be powered with an external voltage, (usually the auxiliary power supply).
The connections are shown in the schematic diagrams.

Every input is customized for a defined function.

Binary input
FUNCTION
IN1 IN2 IN3

52a (auxiliary CB contact) g


52b (auxiliary CB contact) g
TCS (Trip Circuit Supervision) g

TCS
Trip Circuit Supervision.
Supervision with one binary input may be performed.
The exhaustive treatment of the TCS function is described in the concerning paragraph.

+UAUX

NA016

TRIP
Binary input IN3 Towards 74TCS logic

R
52
52a 52b

-UAUX
Trip Circuit Supervision - 74TCS

52a and 52b


The CB position can be acquired by means of binary inputs connected to the auxiliary contacts: the
information is used to acquire the CB position (open-closed-fault).

+UAUX
IN2

52
52a 52b
CB position
CB diagnostic
IN1

-UAUX
Binary input allocation for CB state acquisition

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 23


Output relays
Four output relays are available (K1...K4) with two changeover contacts (SPDT, type C):[1]
• K1 and K2 are trip relays.
• K3, K4 are signalling relays.[2]
Each output relay may be programmed with following operating mode:
• Operation MODE (No latched, Latched).
• Logic (Energized/De-energized).
To each output relay a programmable timer is matched (Minimum pulse width parameter).
All parameters are available inside the Set \ Relays menu.

Input

No-latched operation

t TR Minimum pulse width

Latched operation

Output relay operation Relay-operation-timers.ai

Any change to the settings can be affected at any time, also with the relay on duty, separately for
each relay.
Notes:
• When de-energized operating mode is set, the relay remains in rest condition if no trip command
is in progress.
• When energized operating mode is set, the relay remains in operating condition if no trip command
is in progress and the auxiliary supply is powered on.
• When no-latched operating mode is set (Kx Mode No-latched), the output relay reset at the end
of the trip condition. To each output relay a programmable timer is matched (minimum pulse width
operation).
• When latched operating mode is set Kx Mode Latched, the output relay doesn’t reset at the end
of the trip condition; it stays ON until a reset command is issued (RESET key, ThySetter or com-
munication command).
• It is advisable to make sure that the output contact technical data are suitable for load (Nominal
current, breaking capacity, make current, switching voltage,...).

Matching every output relay to any protective element is freely programmable inside the Setpoints
submenus according a tripping matrix structure.[3][4]

RELAY
FUNCTION
K1 K2 K3 K4
Self-test relay g g g g

I> Start relays (Start I>) g g g g


I> Trip relays (Trip I>) g g g g
I>> Start relays (Start I>>) g g g g
I>> Trip relays (Trip I>>) g g g g
I>>> Start relays (Start I>>>) g g g g
I>>> Trip relays (Trip I>>>) g g g g

IE> Start relays (Start IE>) g g g g


IE> Trip relays (Trip IE>) g g g g
IE>> Start relays (Start IE>>) g g g g
IE>> Trip relays (Trip IE>>) g g g g

TCS Trip relays (Trip TCS) g g g g

Self test CB g g g g

Note 1 Schematic diagram are shown inside APPENDIX B1.


Nota 2 K3 e K4 hanno un potere di interruzione ridotto rispetto a quello dei relè K1 e K2.
Note 3 Matching of the output relay to the protective and control functions can be defined so that any collision from other function is avoided.
All output relay are unassigned in the default setting.
Note 4 Self test relay: it is advisable to plan the following settings:
- Energized operating mode,
- No-latched ,
in order that it stays ON for normal conditions and the other way round it goes OFF if any fault is detected and/or the auxiliary supply turns OFF.

24 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


LED indicators
Eight LEDs are available.
• One green LED “ON”: if turned on it means that the device is properly working, if flashing the inter-
nal self-test function has detected an anomaly.
• One yellow LED “START” tagged for START of one or more protective elements. (I>, I>>, I>>>, IE>,
IE>>)
• One red LED “TRIP” tagged for TRIP of one or more protective elements (I>, I>>, I>>>, IE>, IE>>).
• One red LED 1, latched, tagged for TRIP of one or more protective elements I>, I>>, I>>>
• One red LED 2, latched, tagged for TRIP of one or more protective elements IE>, IE>>
• One red LED 3, no latched, tagged for binary input state visualization 52a (CB position)
• One red LED 4, no latched, tagged for binary input state visualization 52b (CB position)
• One red LED 5, no latched, tagged for binary input state visualization TCS.

50N-51N (IE>, IE>> elements) CB OPEN (52a)


50-51 (I>, I>>, I>>> elements) CB CLOSED (52b)
TCS (TCS trip)

Start
Trip

Key not active

Key not active

LED
FUNCTIONS
START TRIP 1 2 3 4 5
Start I> g
Trip I> g g
Start I>> g
Trip I>> g g
Start I>>> g
Trip I>>> g g

Start IE> g
Trip IE> g g
Start IE>> g
Trip IE>> g g g

Trip TCS g g

CB OPEN g
CB CLOSED g

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 25


Communication interfaces
Several communication ports are provided:
• RS232 port on the front side for local communication (ThySetter).
• RS485 port on the rear side for bus communication.

RS232
A simple DIN to RJ adapter can be used; the L10041 cable can be supplied.
The RS232 port has high priority compared with the RS485 port.

Female connector
RJ10 Connector 1
Pin1 6
4 2 RXD
7
3 3 TXD
8
1 4 DTR
9
2 5 GND

L10041

serial-sch.ai

If RS232 port is not available on Personal Computer, an USB-RS232 converter must be employed.[1]
The serial port is the simplest access for setting by means the ThySetter software.
RS485
Several protocol are implemented:
• ModBus RTU. Modbus is a serial communications protocol. It is a de facto standard communica-
tions protocol in industry, and is now the most commonly available means of connecting industrial
electronic devices also inside electric utilities and substation.
• IEC 60870-5. The IEC 60870-5 suite of protocol is used for communications from master station to
substation, as well within the substation; the IEC 60870-5-103 (Protection equipment) is available
together the Modbus protocol on some version of Pro-n devices (code NA016#xCxx).

Note 1 After installation, the same communication port must be selected to define the Thysetter parameters (typically COM4, COM5,...).

26 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


4.4 PROTECTIVE ELEMENTS
Rated values
Inside the Set \ Base menu the following parameters can be set:
• Primary nominal values, employed for measures relative to primary values.
• Measurements reading mode (Reading Direct or Relative).
Information for settings:

• Phase CT primary current Inp


This parameter affects the measure of the phase currents when the primary measurement reading
mode is selected (Reading Direct). It must be programmed to the same value of the phase CT
primary nominal current Traditional CTs) or to the value set for the LPCT inputs.
Example

52
NA016

1A/5A
KTA = 500A/5A=100
In
LPCT Setting

LPCTs CURRENT INPUTS


L1 In = 500 A

L2 In = 500 A
I L1...I L3
L3 In = 500 A
50 A
100 A
200 A
400 A
800 A
In=50...1250A

Es-In.ai

The phase CT primary current Inp must be set as: Inp = 500 A
• Residual CT primary current IEnp
This parameter affects the measure of the residual current when the primary measurement read-
ing mode is selected with traditional CTs inputs. It must be programmed to the same value of the
residual CT(s) primary nominal current.
Example 1

52
NA016

KTA = 100 A /1 A IEn= 1 A


1x

Es1-IEn.ai

The residual CT primary current IEnp must be set as: IEnp = 100 A
Example 2

52
NA016

KTA = 100A / 5A
3x IEn= 5 A

Es2-IEn.ai

The residual CT primary current IEnp must be set as: IEnp = 100 A

• Measurement reading mode


Measures may be displayed according the following operating modes:
- With Reading Relative setting all measures are related to the nominal value,
- With Reading Direct setting all measures are related to the primary value.

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 27


Phase overcurrent - 50/51
Preface
Three operation thresholds, independently adjustable (I>, I>>, I>>>) with adjustable delay
(t >, t >>, t >>>).
The first one may be programmed with inverse time according the IEC 60255-3/BS142 standard.
The second and third thresholds have a definite time characteristic.
For the definite time thresholds a reset time can be set (t>>RES, t>>>RES) useful to reduce the clearing
time for intermittent faults.
Operation and settings
Each phase fundamental frequency current is compared with the setting value. Currents above the
associated pickup value are detected and a start is issued. After expiry of the associated operate
time a trip command is issued; if instead the current drops below the threshold, the element it is
restored.
The first threshold (I>) may be programmed with definite or inverse time according the following
characteristic curves:
• Standard Inverse Time (IEC 255-3/BS142 type A or SIT): t = 0.14 · t >inv / [(I/I>inv)0.02 - 1]
• Very Inverse Time (IEC 255-3/BS142 type B or VIT): t = 13.5 · t >inv / [(I/I>inv) - 1]
• Extremely Inverse Time (IEC 255-3/BS142 type C or EIT): t = 80 · t >inv / [(I/I>inv)2 - 1]

Where:
t: operate time
I>inv : threshold setting
t >inv : operate time setting

I> inv
TRIP

t >> def

t >>> def

I> inv I>> def I>>> def I


General operation time characteristic for the phase overcurrent elements - 50/51 t-int-F50-51.ai

For all inverse time characteristics, following data applies:


• Asymptotic reference value (minimum pickup value): 1.1 I>inv
• Minimum operate time: 0.1 s
• Range where the equation is valid:[1] 1.1 ≤ I/I>inv ≤ 20

For all definite time elements the upper limit for measuring is 40 In for traditional CT input versions or
12.5 kA (primary current) for LPCT input versions (e.g. 25 In with In = 500 A).
All overcurrent elements can be enabled or disabled by setting the relative start and/or trip output to
a selectable relay inside the Set \ Relays menu.
The first overcurrent element can be programmed with inverse time characteristic by setting the
I>Curve parameter (DEFINITE, IEC/BS A, IEC/BS B, IEC/BS C) available inside the Set \ 50/51
menu.
An adjustable reset time delay is provided for second and third threshold (t >> RES, t >>> RES).

INPUT

t>> RES t>> RES t>> RES

I>> Start
t>> def t>> def

I>> Trip

RESET

t
I>> element phase overcurrent timers - 50/51 Timers-F50-51.ai

Note 1 When the input value is more than 20 times the set point , the operate time is limited to the value corresponding to 20 times the set point

28 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


Start I>

I>Start relays
I>Start LEDs

TRIPPING M ATRIX
(LED+REL AYS)
I > inv

I L1
I L1 ≥ I > inv I> Curve t> inv

I L2 t> inv I>Trip relays


≥1
I L2 ≥ I > inv T 0 T 0 I>Trip LEDs

I L3 Trip I>
I L3 ≥ I > inv

Start I>>
I>>Start relays
I>>Start LEDs

TRIPPING M ATRIX
(LED+REL AYS)
I >> def

I L1
I L1 ≥ I >> def t >>RES t>> def

I L2 t >>RES t>> def I>>Trip relays


≥1
I L2 ≥ I >> def 0 T T 0 I>>Trip LEDs

I L3 Trip I>>
I L3 ≥ I >> def

Start I>>>
I>>>Start relays
I>>>Start LEDs

TRIPPING M ATRIX
(LED+REL AYS)
I >>> def

I L1
I L1 ≥ I >>> def t >>>RES t>>> def

I L2 t >>>RES t>> def I>>>Trip relays


≥1
I L2 ≥ I >>> def 0 T T 0 I>>>Trip LEDs

I L3 Trip I>>>
I L3 ≥ I >>> def

General logic diagram of the phase overcurrent elements - 50/51 Fun_50-51S1.ai

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 29


Residual overcurrent - 50N/51N
Preface
Three operation thresholds, independently adjustable (IE >, IE >>, IE >>>) with adjustable delay (t E >,
t E >>, t E >>>).
For each threshold a reset time can be set (t E>RES, t E>>RES, t E>>>RES) useful to reduce the clearing
time for intermittent faults.

Operation and settings


The residual fundamental frequency current) is compared with the setting value. Current above the
associated pickup value is detected and a start is issued. After expiry of the associated operate
time a trip command is issued; if instead the current drops below the threshold, the element it is
restored.

t E > def
TRIP

t E >> def

I E > def I E >> def IE


t-int-F50N-51N.ai

General operation time characteristic for the residual overcurrent elements - 50N/51N
For all elements the upper limit for measuring is 10 IEn.
All elements can be enabled or disabled by setting the relative start and/or trip output to a selectable
relay inside the Set \ Relays menu.

An adjustable reset time delay is provided for every threshold t E>RES, t E>>RES, t E>>>RES).

INPUT

t E>RES t E>RES t E>RES

IE> Start
t E> t E>

IE> Trip

RESET
t
IE> element residual overcurrent (50N/51N) - Timers Timers-F50N-51N.ai

30 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


Start IE>

IE>Start relays
IE>Start LEDs

TRIPPING M ATRIX
(LED+REL AYS)
t E>RES t E> def
I E> def

IE t> RES t E> def IE>Trip relays


I E ≥ I E > def 0 T T 0 IE>Trip LEDs

Trip IE>

Start IE>>

IE>>Start relays
IE>>Start LEDs

TRIPPING M ATRIX
(LED+REL AYS)
t E>>RES t E>> def
I E>> def

IE t>> RES t E>> def IE>>Trip relays


I E ≥ I E >> def 0 T T 0 IE>>Trip LEDs

Trip IE>>

General logic diagram of the residual overcurrent elements - 50N/51N Fun_50N-51NS1.ai

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 31


4.5 CONTROL AND MONITORING

Data Logger
Preface
When remotely controlled by shunt trip coil is employed a data Logger is advisable to provide a full
monitoring of the protection system.[1]

NA016
PG
DG 74TCS SELF

LOGGER

TA 50 51

TO 50N 51N

• Any power down of the auxiliary power supply are logged inside the 100 events; Power up and
Power down are stored inside distinct events
• A dedicated element is provided for the Trip Circuit Supervision function; any fail inside the trip
circuit is monitored (break on the coil and the circuit, power supply failure). The congruity of the
auxiliary contact is detected in run time mode (52a and 52b), any failure is detect and stored inside
the 100 events.
• Any setting change is logged and information is stored inside ten memory register with time stamp
(date-time); any change is always stored inside the 100 events.
• Any start and/or trip of a protection element is stored inside the 100 events with time stamp (date-
time); moreover a detailed information (trip cause, input currents, I/O states, faulted phase) is
stored inside twenty memory register.
• The relay diagnostic (self-test) is verified; any failure may drive relays and LEDs.

Trip circuit supervision - 74TCS


Preface
The trip circuit can be monitored to signal possible anomalies that would lead to the missing opening
of circuit breaker when trip and/or operator command are issued.
Circuit interruption as well as missing of auxiliary voltage and/or coil faults are detected.
Operation and settings
The 74TCS element may be enabled or disabled; to enable it, the 74TCS Enable parameter must be
set to ON inside the Set \ Circuit breaker menu.
By means of the right sizing of a resistor, the trip circuit supervision may be performed even with
lower control voltage (e.g. when the control voltage is less than 36 V required for driving of two
binary inputs, typically UAUX = 24V). The binary input is connected to the trip and an external resistor
must be connected the 52b auxiliary contact.

+UAUX
NA016
IN3
TRIP
Binary input INx Towards 74TCS logic

R
52
52a 52b

-UAUX
Trip Circuit Supervision - 74TCS TCS1s.ai

Note 1 The Data Logger function is available on request (to be selected on order all’acquisto).

32 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


The fault condition of the trip circuit is detected by binary input power down.
With healthy circuit and TRIP contact closed, the binary input is feed across the 52a path (CB closed)
or across the resistor R and 52b path (CB open).
When the TRIP contact turns ON, the binary input becomes short-circuited; to avoid untimely opera-
tions the previous condition are checked every 80 ms and the output is issued after a 40 s delay in
order to allow the fault clearing and the consequent reset of the TRIP protection.
Outputs are reset to zero after 6 s from the TRIP contact open.[1]

TRIPPING M ATRIX
(LED+REL AYS)
IN3 40 s 6s Relay Trip 74TCS
Enable (ON≡Enable) &
T 0 0 T LED Trip 74TCS
74TCS

Trip 74TCS
Trip 74TCS
Logic diagram concerning the Trip Circuit Supervision - 74TCS Fun-74TCS1.ai

How to calculate resistance


Both the following conditions must be filled:
1) The circuit breaker coil must no be powered when the CB is open and an open command is is-
sued;
2) The binary input is energized when the trip contact open.

1) If the circuit breaker is just open an unnecessary excitation must be avoided; the most critical
event arises when the TRIP contact is closed (e.g. manual or test command), so with minimal
series resistance. To avoid an unwanted excitation the series resistance must be higher than a
minimum value defined as:

Rmin = R TC · (UAUX - U TCmin) / U TCmin


where:
U TCmin: minimum coil excitation voltage
UAUX : auxiliary voltage
R TC : coil resistance

2) To energize the binary input circuit when the TRIP contact and CB open, the series resistance
must be lowerer than a maximum value defined as:

Rmax = [(UAUX - UDIGmin) / IDIG] - R TC


where:
UDIGmin: minimum binary input excitation voltage (18 V)
UAUX : auxiliary voltage
R TC : coil resistance
IDIG: binary input excitation current (0.003 A)

To satisfy the above requirements, the R value must be chosen between the Rmin and Rmax values;
typically the normalized value nearest the arithmetic mean:

R = (Rmin + Rmax) / 2

The power dissipated by the R resistor is:

P R = R · I 2 = R · [UAUX / (R + R TC)] 2

Example
UAUX = 110 Vcc (auxiliary voltage)
P TC = 50 W (coil power)
R TC = UAUX 2 / P TC = 242 Ω (coil resistance)
U TCmin = 77 V (minimum coil excitation voltage = 70% UAUX )
UDIGmin = 18 V (minimum binary input excitation voltage)
IDIG = 0.003 A (binary input excitation current)

Rmin = R TC · (UAUX - U TCmin) / U TCmin = 242 · (110 - 77) / 77 = 103.7 Ω

Rmax = [(UAUX - UDIGmin) / IDIG] - R TC = [(110 - 18) / 0.003] - 103.7 = 30563 Ω

R = (Rmin + Rmax) / 2 = (103.7 + 30563) / 2 = 15333 Ω ~ 15 k Ω

P R (Power dissipated by the R resistor) = UAUX 2 /R = 110 2 / 15000 = 0.8 W


P R = R · I 2 = R · [UAUX / (R + R TC)] 2

Note 1 The trip contact (TRIP) of the protection relays must be set with automatic reset (No-latched operating mode).

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 33


Circuit breaker supervision
Preface
By means 52a and 52b auxiliary contacts, the CB position is acquired. Depending on such information
the Open and/or Close commands can be safely issued by user.

The wrong congruity of the auxiliary contact is detected in run time mode (52a and 52b), by means of
two binary inputs; any failure is detect and stored inside the 100 events (Data Logger).

CB monitoring
+UAUX
52a ON/OFF
IN2

TRIPPING M ATRIX
52

(LED)
52a 52b t mask

t mask
=1
IN1 T 0

-UAUX 52b ON/OFF

Logic diagram concerning the Circuit Breaker monitoring Fun-CB-position.ai

Operation and settings


52a is the auxiliary contact in the breaker that is in the same position as the breaker (52a open = CB
open). It must be assigned to the IN2 binary input.
52b is the auxiliary contact in the breaker that is in the opposite position as the breaker (52b open =
CB closed)). It must be assigned to the IN1 binary input.

34 NA016 - Manual - 08 - 2009 FUNCTION CHARACTERISTICS


Test
The test function allows the checking of each 50-51 and 50N-51N protection function threshold by
means of the introduction of a dummy signal, with twice the setting threshold value and duration as
to cause the start and/or tripping of the threshold itself, into the input circuit stages of the relay.
This test does not include checking the system measuring transformers and the relevant connec-
tions to the digital protection relay.
Having activated the test function mode, the threshold relating to the protective function to be
checked and the relevant test method must be selected. The latter may or may not include changing
the status of the output relays assigned as the selected threshold start and /or trip.
For the thresholds relating to protective functions 50 and 51 the dummy signal is applied simultane-
ously over all phases.
Example, with setting t>inv = 1 s, the operate time for the first element 50/51is:
• 10 s with IEC/BS A characteristic
• 13.5 s with IEC/BS B characteristic
• 26.6 s with IEC/BS C characteristic

In cases involving selection of the test mode without any changes in the status of the output relays
(“blank” Testing), upon tripping of the selected threshold, the corresponding LED is lit and the test
outcome recorded as the most recent event. The test condition is shown by means of the blinking
green LED ON.[1]

• Test I> led


• Test I>> led
• Test I>>> led
• Test IE> led
• Test IE>> led
In cases involving selection of the test mode with changes in the status of the output relays, at
the start and/or tripping of the selected threshold the corresponding programmed output relay is
switched, the corresponding LED lit and the outcome recorded as the most recent event. The test
condition is shown by means of the blinking green ON.[2]
• Test I> full
• Test I>> full
• Test I>>> full
• Test IE> full
• Test IE>> full
For both modes the test may be ended by means of the Test off command; in any case they are
ended after 2 minutes.

Oscillography
Set trigger
Following parameters, available inside the Oscillography \ Setting menu, are user-programmable:

• Pre-trigger time.

Trigger

pre-trigger Time
trigger.ai

• With setting of the Trigger parameter General start or General trip the recording starts with
state change of any protection elements.
• With setting of the Trigger parameter Manual the recording starts with manual command (Thy-
Setter).
• With setting of the Trigger parameter K1...K4 the recording starts with state change of the se-
lected output relay.
• With setting of the Trigger parameter IN1, IN2, IN3 he recording starts with state change of
any binary input.
• With setting of the rigger aux parameter Start I>, Start I>>, Start I>>>,.... the recording
starts with state change of start or trip of the selected protection element.

Set measured channels


The analog measures ((iL1, iL2 , iL3 , iE ), IL1, IL2 , IL3 , IE ) may be select inside the Oscillography \ Setting
\ Analog channel 1...4 menu.
Everyone of four analog channel may be associated to one of the selected measures.

Set digital channels


The desired I/O signals may be select inside the Oscillography \ Setting \ Digital channels menu
(General start, General trip, K1... K4, , IN1, IN2, IN3).

Note 1 The test is performed (LED) even if the concerning element is assigned to almost one output relay
Note 2 The test is performed (LED & relays) even if the concerning element is assigned to almost one output relay

FUNCTION CHARACTERISTICS NA016 - Manual - 08 - 2009 35


5 M E A S U R E S , L O G I C S TAT E S A N D C O U N T E R S
Measures
• RMS value of fundamental component for phase currents (I L1, I L 2 , I L 3 )
• RMS value of fundamental component for measured residual current (I E )

Circuit breaker
The CB and Trip Circuit Supervision states are provided
• Position Open - Closed - Unknown
• TCS On - Off
and the binary inputs state:
• IN1-52b On/Off
• IN2-52a On/Off
• IN3-TCS On/Off

Counters
For every protective element and control function several counters are available; the partial coun-
ters can be cleared by the user.
Every partial counter is reset to zero when ten thousand count is passed.
All partial counters can be cleared by means a single command; for this purpose the Reset coun-
ters command must be issued available inside the Reset menu.
• Counter ST I>
• Counter ST I>>
• Counter ST I>>>
• Counter ST IE>
• Counter ST IE>>
• Counter TR I>
• Counter TR I>>
• Counter TR I>>>
• Counter TR IE>
• Counter TR IE>>

Fault recording - SFR


Recording[1] is triggered by:
• Relay activation (OFF-ON)
• External trigger (binary input) programmed as Fault trigger
• Element start or trip
Twenty events are recorded into a circular FIFO (First In, First Out) buffer.[2]
Following information are stored in every record (Read \ Faults \ Info menu):
• Fault counter (Faults stored)[3]
• Last fault
• Date and time (S-Year)
• Date and time (S-Year)
• Date and time (S-Month)
• ...
• Data e ora (S-Millisecond
• Fault cause (F-Cause)
• Phase currents (F-IL1, F-IL2, F-IL3, F-IE)
• Residual current IEr or IECr
• Inputs
• Outputs
• Fault cause info (F-Phases)
The fault log may be erased by means of the command available inside the Read \ Faults \ Reset
menu.

Event recording - Events


Recording is triggered by:
• Power up and/or Power down.
• Element start or trip.
• Binary input switch (OFF-ON or ON-OFF).
• Setting modify.
• Control function trip (TCS OFF-ON or ON-OFF and CB switch OFF-ON or ON-OFF).
One hundred events are recorded into a circular FIFO (First In, First Out) buffer (Read \ Events \ Info
menu).[4]
Following information are stored in every record (Read \ Faults \ Event menu):
• Event counter (Events stored) [5]
• Last Event
Note 1 Data concerning the twenty events are stored into non volatile memory; they are held in spite of power down
Note 2 Fault 0 is the newest event, while the Fault 19 is the oldest event
Note 3 Counter is updated at any new record; it may be cleared by means ThySetter
Note 4 The newest event data are stored inside the event addressed by the Last event parameter (1...100)
Note 5 Counter is updated at any new record; it may be cleared by means ThySetter

36 NA016 - Manual - 08 - 2009 MEASURES, LOGIC STATES AND COUNTERS


• Date and time (S-Year)
• Data e ora (S-Year)
• Data e ora (S-Month)
• ...
• Data e ora (S-Millisecond)
• Event cause (E-Cause)

Setting changes - Settings


Any change on the following parameters are stored:
• Output relays (function, logic and mode).
• CB position monitoring enabling.
• TCS enabling.
• Threshold changes.
Ten events are recorded into a circular FIFO (First In, First Out) buffer.[1]
Following information are stored in every record (Read \ Faults \ Info menu):
• Fault counter (Setting stored)[2]
• Last setting
Following information are stored (Read \ Settings \ Setting menu):
• S-Number counter
• S-I>Curve
• S-I>inv (I>threshold)
• S-t>inv (I> operate time)
• S-I>>def (I>> threshold)
• S-t>>def (I>> operate time)
• S-I>>>def (I>>> threshold)
• S-t>>>def (I>>> operate time)
• S-IE>def (IE> threshold)
• S-tE>def (IE> operate time)
• S-IE>>def (IE>> threshold)
• S-tE>>def (IE>> operate time)
• S-CB Diagnostic
• S-74 TCS
• S-K1 (K1 assignment)
• S-K1 logic (K1 logic)
• S-K1 mode (K1 mode)
• S-K2 (K2 assignment)
• .....
• S-Year (Date)
• S-Month (Date)
• ...
• S-Second (Time)

Info
• Code NA016-a
• Serial ...... (Serial number)
• Firmware release ...... (eg: 2.00)
• Nominal freq. (eg: 50 or 60 Hz)
• Firmware release ...... (ef: 1.00)
• Protocol release ...... (eg: 1.00)

Protections trip
• Protections trip (eg: Trip I>>)

Self-test
Following information are available (Read \ Self test \ Info menu):
• Type
• Self-test cause
• Self-test latch
The relay self-test function classifies relay operational anomalies according to three levels:
- MINOR ANOMALY: The device continues to function within the possible limits with the protective
devices activated;
- MAJOR ANOMALY: Operation of the device may be corrected by the operator by resetting the
initial (default) configuration and hence the desired settings;
- FATAL ANOMALY: All logic and protective functions are inoperative and the relay must be returned
to the factory.
The internal self-test function is capable of detecting the following anomalies and indicating them
by means of messages:
- defective auxiliary power supply (FATAL ANOMALY);
- output relay coil breakage (FATAL ANOMALY);
- alteration of the calibration data stored in EEPROM memory (FATAL ANOMALY);
- alteration of the parameters (threshold setting, times, relays… etc.) in EEPROM memory (MAJOR
ANOMALY);
Note 1 The last change on settings ia stored inside memory addressed by the Last setting (1...10) parameter
Note 2 Counter is updated at any new record; it may be cleared by means ThySetter

MEASURES, LOGIC STATES AND COUNTERS NA016 - Manual - 08 - 2009 37


- alteration of the data (counters, records, ...etc.) in EEPROM memory (FATAL ANOMALY);
Upon detection of at least one of the above mentioned anomalies, the output relay programmed for
Self-test is switched and the information is recorded (latched).

Oscillography - DFR[1]
Upon programmable trigger, the fault records are recorded in COMTRADE format d; the sampled
measures (64 sample per cycle) are stored in a circular shift memory buffer.
The fault record are self-triggered; they are stored in sequential order up the allocated memory is
used up after which the oldest memory is overwritten.
An operating procedure example for the digital fault recording is illustrated inside the ThySetter
section.

Following parameters are user-programmable:


• Pre-trigger time (0...63 T where T = number of power cycles; Example, with settings T=4 the pre-trig-
ger duration is 80 ms with f = 50 Hz).

Trigger

pre-trigger Time

Trigger oscillografia trigger.ai

• Selected sampled quantities.


• Analog channels (1...4) allocation.
• Digital channels allocation (output relay and/or binary inputs).
• Trigger setup; the information storage starts when a state transition on the selected signal occurs.
(protective element start and/or trip, output relay and/or binary input switching).

COMTRADE
Records are recorded in COMTRADE format; (Common Format for Transient Data); This is a standard
for the data exchange for various types of tests or simulation datas, etc, for power system applica-
tions.
The measurements are recorded in ASCII or BINARY format. COMTRADE files always come by
pairs:
• The “.CFG”-file describing the configuration: number of analog and digital channels, sampling rate,
scale factors, etc.
• The “.DAT”-file containing the data

The COMTRADE is part of IEC 60255-24 standard.


The recording can be analyzed by mean of ThySetter sw or any other standard compliant viewer.

The record length is depending on settings of following parameters:


• Pre-trigger times
• Number of allocated channels.

Example
With the following setting:
• “Analog channel 1”: iL1
• “Analog channel 2”: iL2
• “Analog channel 3”: iL3
• “Analog channel 4”: iL4
• Digital channel: K1

the stored record duration of the two records with f = 50 Hz is 240 ms

Note 1 The Programmable Logic Controller requires a licence; to purchase it please contact Thytronic.

38 NA016 - Manual - 08 - 2009 MEASURES, LOGIC STATES AND COUNTERS


6 I N S TA L L AT I O N
6.1 PACKAGING
Packaging consists of a paperboard packaging guaranteeing adequate protection for transport and
storage under normal environmental conditions.
The Pro-N protection relays must be stored within the required temperature limits; the relative hu-
midity should not cause condensation or formation of frost.
It is recommended that the devices are stored in their packaging; in the case of long storage, espe-
cially in extreme climatic conditions.
It is recommended that the packaging not be disposed of into the environment, but kept in case the
relay should be moved at some later time.

6.2 MOUNTING
The devices are housed inside metal cases suitable assembly:
• Flush mounting
• Rack9”.

Flush mounting
The fixed case, fitted with special fastening brackets, is mounted on the front of electric control
board, previously drilled as indicated in the drawing.
In case of side-by-side mounting of several relays the minimum drilling distance is determined by
the front dimensions indicated in the overall dimensions drawing, increased by 3 mm, to ensure an
adequate tolerance and gasket space between adjacent relays.
The depth dimension, as indicated in the drawing, must be increased by as much as needed to allow
room for the wiring.

102.5 ±0.3
107 75 30 70
101

D1

A1
A2
C1 C2
A3 F1
A4 RX F2
A5 F3
A6 TX F4
A7 F5
A8 C3 C4
A9 B1
A10 B2
161
154
177

171
149

A11 B3
A12 B4
ON 1 2 3 4 5 START B5
A13
A14 C5 C6 B6
TRIP
A15 B7
A16 B8

A17
A18
A19
A20 C7 C8

A21
A22

E1

N.4 fori ø 3.5

• Remove the upper tile and open the little door to access the fastening screws.

Removing tie to access the fastening screws Remove-tile.ai

INSTALLATION NA016 - Manual - 08 - 2009 39


• The fixed case is fastened by means of four screws onto the panel as indicated in the drawing.

Flush-mount1.ai

Rack mounting
For mounting inside a standardized 19-inch system (EIA 310-D, IEC 60297 and DIN 41494 SC48D), the
MAR adapter is required (available on request).

482.6
465
177 (4U)
101.6

ON 1 2 3 4 5 START ON 1 2 3 4 5 START ON 1 2 3 4 5 START ON 1 2 3 4 5 START

TRIP TRIP TRIP TRIP

Rack mounting Rack-mount.ai

To allow opening of the keyboard door a one unit space must be provided when several rack are
overlapping mounted.

Rack mounting Rack-mount1.ai

40 NA016 - Manual - 08 - 2009 INSTALLATION


6.3 ELECTRICAL CONNECTIONS
Electrical connections should be made by referring to the connection diagram; in cases where cer-
tain of the circuits (communication, block, or others) are not used, the relevant connections must
remain open. Examples of connection diagrams are reported on Appendix to this manual.

CAUTION Devices must be installed by qualified personnel only. No liability is accepted from Thytronic due to improper use.
For the A1...A22 connections and (RS485), screw terminals with following characteristics are avail-
able:
• Nominal cross section: 0.14...2.5 mm2 (AWG 26...16) for single conductor
da 0.14 a 0.75 mm2 for two conductors with same cross section
• Tightening torque: 0.5-0.6 Nm
• Stripping length: 8 mm

The connections to the current signal inputs C1...C8 can be made by ring lugs suitable for M4 screws
and an insulating panel covering the terminals may be mounted for safety purposes.

D1

A1 A1
K1 A2 A2
C1 C2
A3 A3 F1
A4 A4 RX F2
K2 A5 A5 F3
A6 A6 TX F4
A7 A7 F5
K3 A8 A8 C3 C4

A9 A9 B1
A10 A10 B2
K4 A11 A11 B3
A12 A12 B4
A13 A13 B5
IN1
A14 A14 C5 C6 B6
B7
IN2
A15 A15
A16 A16 B8

IN3
A17 A17
A18 A18

≅ A19 A19
UAUX A20 A20 C7 C8 RS485
A+
A21
1 2 3

A21
3

B-
A22 A22
2
1

E1

Amperometric inputs from traditional CTs

D1

L1
A1 A1
K3 A2 A2
A3 A3 F1
A4 A4
L2
RX F2
Amperometric inputs from LPCTs
K1 A5 A5
1 2 3 4 5 F3
A6 A6 L1
TX F4
L3
A7 A7 1 2 3 4 5
F5
K2 A8 A8 L2
A9 A9 1 2 3 4 5 B1
A10 A10 L3 B2
K4 A11 A11 B3
LPCT Setting
A12 A12 50 B4
100
A13 A13 200
400
B5
IN1
A14 A14 800 B6

IN2
A15 A15 B7
A16 A16 EX. In =
300A
B8
(100+200)

IN3
A17 A17
A18 A18
≅ A19 A19
UAUX A20 A20 C7 C8 RS485
A+
A21
1 2 3

A21
3

A22 A22 B-
2
1

E1

INSTALLATION NA016 - Manual - 08 - 2009 41


Core balanced CT
Proper installation is shown in fig. 1a and 1b.
The current balance transformer, when used for measuring residual current, must be crossed in the
same direction by all active conductors and hence, also by the neutral conductor if distributed, with
the exception of the ground connection protective conductor. The drawing below shows cases of
assembly of the toroid on unscreened and screened cables; prior to proceeding with assembly, it is
necessary to check that there are no screen-to-ground connections upstream of the sensor.

Source Source

Insulated cables

Shielded cables

Armoring Armoring

Load Load
Fig. 1a Fig. 1b
Current balanced transformer Toroide.ai

In order to ensure a linear response from the sensor, the cables must be positioned in the centre
of the transformer so that the magnetic effect of the three cables is perfectly compensated in the
absence of residual current (Fig.2a).
Hence, the assembly indicated in the drawing of fig.2b, in which phase L3 causes local magnetic
saturation whereby the vectorial sum of the three currents would be non-null, should be avoided.
The same considerations also apply when the sensor is positioned near bends in the cabling.
It is recommended that the transformer be placed away from bends in the conductors).
E’ consigliabile l’impiego di un toroide

L1 L1

L2 L3 L2 L3

Fig. 2a Fig. 2b Fig. 2c


Current balanced transformer Toroide.ai

42 NA016 - Manual - 08 - 2009 INSTALLATION


Earth
A protective ground connection is required, which must be connected to the suitable screw with a
separate lead of at least 2.5 mm2; the connection from A21 or a22 terminal and the ground srew is
also required.[1]

Earthing rear.ai

CT amperometric inputs
The amperometric input circuits are assembled inside the fixed module, so no short circuit on the
secondary CTs must be provided when the removable module is pulled out
In the event of case replacement, some camps must be provided externally to shorting the second-
ary CTs circuits to avoid secondary open circuit of CTs that may endanger equipment or people.

CAUTION In case of disconnection CT wiring to the case, pay attention must to do not open live circuits.

When making the current connections, attention must be paid to not exceeding the performance
of the line current transformers. To be exact, the total load, constituted by the protective relay, any
other protective relays or measuring instruments and the resistance of the connections, must not ex-
ceed the line CT performance. In particular, consumption of the relay input circuit must not exceed
0.2 VA while the load (expressed in VA) constituted by the conductors is given by:

0.018 × L × In 2 / S
where:
L the overall length, expressed in m, of the two conductors in relation to each phase;
In nominal current of the line CT expressed in A;
S cross sectional area of the current conductors expressed in mm2.
It is recommended that cabling of a suitable thickness be used in order to limit wear of the CT sec-
ondary circuits.

LPCT amperometric inputs


The amperometric input are designed for Low Power Current Transformer with 100 A - 22.5 mv ratio.
Connections to NA016 device must be carried out by means RJ45 plugs, forming a part of the Trans-
former.[2]

Note 1 The A21 and A22 terminal are link together inside the relay
Nota 2 For technical data please call Thytronic.

INSTALLATION NA016 - Manual - 08 - 2009 43


Binary inputs
The dry input circuits, despite being galvanically isolated, must preferably be supplied with the same
auxiliary voltage of the control panel.
The inputs are polarity free with wide voltage range.
+UAUX

A B A13
IN1
A14

A15
-UAUX
IN2
A16

A17
IN3
A18

The optocupled inputs are immune to transitory interferences, however the following recommenda-
tion must be considered in high disturbed environments:
• Position input wiring away from high energy sources.
• Use shielded cables with ground connection on only one end (preferably at the relay side.

Output relays
Four output relays are available (SPDT, type C):
• K1 and K2 (trip relays).
• K3 e K4 (signalling relays).
It is advisable to verify that the technical characteristic of the contacts be suitable for the applied
load (about current, nominal voltage, make and break current , etc..).
All contacts are shown in de-energized state for standard reference

RS232 port
The link from PC and NA10 serial port must be established by means a L10041 cable.

USB-RS232 converter
Female connector L10041
RJ10 Connector 1
6
Pin1 4 2 RXD
7
3 3 TXD
8
1 4 DTR
9
2 5 GND

(if none RS232 PC port is available)

serial1-sch.ai

When no RS232 port is available on Personal Computer, a suitable USB to RS232 converter must be
employed.
After installation, the same communication port must be selected to define the Thysetter parameters
(typically COM4, COM5,...).

44 NA016 - Manual - 08 - 2009 INSTALLATION


RS485 port
RS485 communication circuit connections must be made using screened twisted pair cable observ-
ing the polarities; screening must only be connected to the end terminating at the RS485 interface
circuit pertaining to the monitoring unit.
It is recommended to terminate the line at the extremities of the same; this must be performed on the
RS485 line control unit and on the NA016 device placed at the furthest point connecting the specially
provided resistor; termination can be made by means a jumper between the E1-E2 terminals.
Termination resistors allow adjusting the impedance of the line, reducing the influence of the induc-
tive components of the same, which might compromise good communication.

Pro-N NA016

K1 A3
A4
A5
K2 A6
C1
A7
I L1 A8

OUTPUT RELAYS
C2
C3 CURRENT INPUTS K3 A9

C4
I L2
K4 A10
C5 A11
I L3 K5 A12
C6
K6 A13
C7
IE A14
C8
F1
F2 1
F3 E1
RS485

RS485
B- F4 B- 2
A+ F5 A+ 3
ETHERNET

A1 ≅ D1
UAUX
A2
THYBUS

SUPERVISION UNIT E1

B-
BLOCK OUT

RS485
BLOCK IN

BLOUT-
A17 A15
BLOUT+
120 Ω A18 A16
A+

A19
BINARY INPUTS

IN1 FRONT PANEL


A20
RS232

A21
IN2
A22

RS485-wiring.ai

INSTALLATION NA016 - Manual - 08 - 2009 45


6.4 NOMINAL CURRENT I n AND I En SETTING
Factory default settings:
• Nominal phase current In: 5 A
• Nominal residual current IEn: 1 A
To modify settings, the dip-switches placed on the front board must be changed (the case must be
open).

CAUTION Turn off power supply before opening the case.

The following operations must be performed:


• Remove the auxiliary supply
• Remove the upper tile and open the little door to access the fastening screws.

Removing tie to access the fastening screws Remove-tile.ai

• Unscrew gradually back to back the four fastening screw in order avoid loss of the internal washer.
• Unmounting of the case from the switchboard is not needed.
• Rotate the MMI module with care to not disconnect the flat cable.

• Avoid touching the printed circuit and connections[1],

Note 1 There are components present which are sensitive to electrostatic discharge.
When the module is removed, it is important to pay particular attention to avoid any accidental contact with the internal components.
In order to avoid the static electricity accumulated in the human body from causing damage, it is recommended to observe the following precautions:
- eliminate any potential differences between the human body and the device by touching the metallic case,
- avoid touching the printed circuit and connections (tracks, component terminals),
- avoid handing the device to others,
- set the programming DIPs by using antistatic tools.

46 NA016 - Manual - 08 - 2009 INSTALLATION


• Set the dip-switches on the top of the circuit board in accordance with the drawing shown below,.

Dip-swithes position

• Move dip-switches according the following layout.

IL3
IL2
IL1
IE

1A Default settings:
- In =5 A
ON

5A - IEn =1 A
4 3 2 1
IL3
IL2
IL1
IE

1A Settings:
ON

- In =1 A
5A - IEn =1 A
4 3 2 1
IL3
IL2
IL1
IE

1A Settings:
ON

- In =1 A
5A - IEn =5 A
4 3 2 1
IL3
IL2
IL1
IE

1A Settings:
ON

- In =5 A
5A - IEn =5 A
4 3 2 1

Dip-switch localization concerning the nominal current setting inside the front board

INSTALLATION NA016 - Manual - 08 - 2009 47


6.5 LED ALLOCATION
Eigth indicator LEDs and six keys[1] are available on the front panel:

50N-51N (IE>, IE>>) CB OPEN (52a)


50-51 (I>, I>>, I>>>) CB CLOSED (52b)
TCS (Itrip TCS)

Start
Trip

Key disabled

Key disabled

6.6 FINAL OPERATIONS

Before energizing the electric board, it is advisable to check that:


• The auxiliary voltage in the panel falls within the operative range of relays.
• The rated current of the line CT’s corresponds to the settings of relay.
• All wirings are correct.
• All screws are tightly screwed.

Nota 1 I pulsanti “I” e “0“ non sono attivi

48 NA016 - Manual - 08 - 2009 INSTALLATION


7 PROGRAMMING AND SETTINGS
All relay programming and adjustment operations may be performed through MMI (keyboard and
display) or using a Personal Computer with the aid of the ThySetter software.

For safety reasons, a change of the following parameters become active only after an hw reset:
WARNING - Relay nominal frequency (fn)
- Ethernet communication parameters (IP host address, IP net mask, Autonegotiation).

7.1 SW ThySetter
The ThySetter sw is a “browser” of data (setting, measure, etc..); it implements an engine that is
afford to rebuild the menu set up and the relationships to data concerning all Thytronic protective
relays by means of XML files.

ThySetter installation
The latest release of ThySetter can be downloaded free of charge from the www.thytronic.it site
(PRODUCT/SOFTWARE APPLICATIONS/THY-SETTER/download area), or from www.pro-n.it site
(Software pc - area download).

ThySetter use
Please refer to ThySetter user manual for detailed instructions.
The document is available on www.pro-n.it site (Software pc - area download) or the www.thytronic.
it site (PRODUCT/SOFTWARE APPLICATIONS/THY-SETTER/download area).

SETTING AND COMMISSIONING NA016 - Manual - 08 - 2009 49


7.2 MMI (Man Machine Interface)

On the front panel there are eight buttons which allow the user to perform all the settings, reading
and modification operations.[1]

50N-51N (IE>, IE>>) CB OPEN (52a)


50-51 (I>, I>>, I>>>) CB CLOSED (52b)
TCS (Itrip TCS)

Start
Trip

Key disabled

Key disabled

The adjustment of the settings and the operation mode of the output relays must be performed while
the unit is electrically powered; the alphanumeric display shows the necessary information with
reference to the operations performed through the keyboard.
All preset values are permanently stored in the nonvolatile memory.
The buttons take the following operations:
- (Up) move the cursor upwards to the preceding menu options
- (Down) move the cursor downwards to the subsequent menu options
- (Left) move the cursor upwards to the preceding menu options
- (Right) move the cursor downwards to the subsequent menu options
- (Enter) access to the selected menu with the option of modifying any given parameter
- (Reset) abort the current changes and/or accessing the previous menu

At power-up, the display shows the text:


“THYTRONIC
NA016
date and time: (01/01/2000 00:00”
The ON green Led points out the auxiliary power supply voltage (permanent lighted) and possible
faults (blink lighted).
The display backlight is automatically activated when any key switch is set.
By means of the (Up) or (Down) buttons, it is possible to cyclically browse through the menu op-
tions: Read, Set, Oscillography, Communication, Test, Reset, Time, Option
Having identified the sub-menu of interest, it is possible to gain access by using the (Right) button
and then analogously, run through the relevant options by using the (Up) or (Down) buttons.
The full menu tree and some examples are showed in the following pages (numerical values and
settings are pointed out as examples and does not agree with real situations.

Reading variables (READ)


All data (measure, settings, parameters, etc...) may be displayed:
“Measures >”
“Circuit breaker >”
“Counters >”
“Last fault >”
“Info >”
“Protection trip >”
“Self-test >”

Setting modifying (SET)


To effect a change, having identified the parameter intended for change, the following procedure
must be performed:
• Select the parameter going through the menus by means the , and keys.
• Begin the setting phase by means of the key; the he modification in progress status is high-
lighted by the symbol “E” flashing in the upper right area of the display.
• Change the parameter by means the (increment) or (decrement) buttons.

Nota 1 The “I” and “0“ keys are disabled

50 NA016 - Manual - 08 - 2009 SETTING AND COMMISSIONING


• Press the (Enter) button; acceptance of the change is indicated by the disappearance of the
flashing “E” to be replaced by the symbol “!”. On must be remember that changes are NOT ac-
tive until the Store command, located in the “Set” menu has been used; in this regard, once the
“Store” message is displayed, it is necessary to use the (Enter) button; this results in the
“execute” message with the symbol “C” flashing.
• Browse the menu by means of the and or keys to go in the Store menu.
• Press the (Enter) button; once more concludes the save procedure with the temporary appear-
ance of the message “ok!”.
After one or more modifications, the status of having data that has still not been permanently saved
is indicated by the “!” symbol in the top right and the display message “WARNING set Clear..
Store” which appears while browsing through the main menu with the use of the or keys.

• The Clear command may be used to abandon unsaved changes (prior to use of the Store com-
mand); the same effect is achieved by switching the key to the OFF position or removing the auxil-
iary power supply to the relay.
Example
To set the K1 relay with Energized mode and latched mode (Energized, Latched) the following sequence
must be operated:
• Select the Set menu “Set >”by means of the key.
• Press the key; the message “Base >” is displayed.
• Browse the menus with
“Relays >”
“50/51 >”
“50N/51N >”
“Circuit breaker >”
“Clear >”
“Store >”
• Select the “Relays >”, menu; the message “K1 None >” is displayed.
• Press the key; the message “K1 Logic De-energized” is displayed.
• Press the key; the he modification in progress status is highlighted by the symbol “E” flashing in
the upper right area of the display.
• Change the parameter by means the or keys; the message “K1 Logic Energized” is
displayed.
• Press the key; acceptance of the change is indicated by the disappearance of the flashing “E”
to be replaced by the symbol “!”.
• Press the key; the message “K1 mode No-latched” is displayed.
• Press the key; acceptance of the change is indicated by the disappearance of the flashing “E”
to be replaced by the symbol “!”.
• Change the parameter by means the (increment) or (decrement) buttons; the message “K1
mode Latched” is displayed.
• Press the (Enter) button; acceptance of the change is indicated by the disappearance of the
flashing “E” to be replaced by the symbol “!”

• Press the key and or to go inside the Store menu.
• Press the key; this results in the “execute ?” message with the symbol “C” flashing.
• Answer with key to confirm setting.
The end of the setting sequence is signalled by the “ok!” message.
The Reset key may be used to abort unsaved changes (prior to use of the Store command); the
same effect is achieved by switching the key to the OFF position or removing the auxiliary power
supply to the NA016 relay.

Test
The operational tests with or without command of the associated output relays may be performed.
Browse the main menu by means the or keys until the “Test” message is displayed; press
the key to enter and subsequently select the test by means of the or keys.

• Test I> led


• Test I>> led
• Test I>>> led
• Test IE> led
• Test IE>> led
• Test I> full
• Test I>> full

SETTING AND COMMISSIONING NA016 - Manual - 08 - 2009 51


• Test I>>> full
• Test IE> full
• Test IE>> full
Example
To set the K1 test on the I> element, the following sequence must be operate:
• Select the “Test I> full >” menu.
• Press the key to enter ; this results in the “execute ?” message with the symbol “C” flashing.
• Press the key to enter; the test in progress condition is marked by “ok! “ message and blinking
of the led ON.[1]
• To stop test select the “Test off >” menu, press the key and answer with a further activa-
tion of the key to the “Test off execute? >>” message.

Communication
Inside the Communication menu the setting data of the serial communication ports (rate, stop bit,
parity and address) for RS485 Modbus and IEC60870-5-103 may be adjusted.
Browse the main menu by means the or keys until the “Protocol RS485 Modbus >”
message is displayed; press the key to enter; the he modification in progress status is highlighted
by the symbol “E” flashing in the upper right area of the display.
• Select the right menu by means of the or keys “Protocol RS485 Modbus >” or
“Protocol RS485 IEC60870-5-103 >”
• By means of the or keys adjust the address; the “Address 1” message is displayed and
enter the intended value. Similarly for all the parameters:
“Address 1”
“Baudrate RS485 9600”
“Enable TX delay 2 ms”
“Start TX delay 2 ms”
• By means of the key and next or go inside the Store menu.
• Press the key; this results in the “execute ?” message with the symbol “C” flashing.
• Answer with key to confirm setting
The end of the setting sequence is signalled by the “ok!” message.
The Reset h key may be used to abort unsaved changes (prior to use of the Store command); the
same effect is achieved by switching the key to the OFF position or removing the auxiliary power
supply to the NA016 relay.

Reset
Inside the Reset menu the clearing of counters (Reset counters) LEDs and relays (Reset alarm) may
be operated.

DEFAULT (Option)
Available inside the Option menu are the configuration parameter reset (Default) commands.
Set default PAR
Set default REE
In case of any anomalies detected by the self-test function, where configuration data has become
corrupted, it is possible to restore the factory default settings. In particular, using the command “Set
default PAR”, the calibration data is restored (thresholds, times, output relay assignment etc), whilst
with the command “Set default REE” all the updated variables (counters, ...etc) and the serial com-
munication parameters are automatically reset.
Except for extraordinary situations, it is not necessary to use such commands which in any case
allow the restoration of the factory set default values following an anomaly.
Following use of this command, it is necessary to then proceed with the setting of the desired set-
tings and/or the calibration of the voltages just as in the case for first installation.

Data/time setting (Time)


To effect a change, (year, month,...) the modification may be confirmed by using the key.
Likewise the Set menu the modification in progress status is highlighted by the symbol “E” flashing
in the upper right area of the display.
Subsequently, it is possible to alter the parameter by means of the or keys (the “E” symbol
continues to flash to highlight the Editing status); upon reaching the desired value, it is necessary to
once more use the key.
Acceptance of the change is indicated by the disappearance of the flashing “E” to be replaced by
the symbol “!”
Differently from the Set menu the changes are stored and became active immediately without the
Store command.

Nota 1 I test sono attivi solo se le funzione selezionata è assegnata ad un relè finale

52 NA016 - Manual - 08 - 2009 SETTING AND COMMISSIONING


7.3 MENU TREE

IL1 0.0000 A/In


IL2 0.0000 A/In
IL3 0.0000 A/In
IE 0.00000 A/IEn
Measures Inp value 300
Inp
p unit A
IEnpp value 100
IEnpp unit A
Reading Direct
Position Unknown
TCS Off
Circuit breaker IN1 - 52b Off
IN2 - 52a Off
IN3 - TCS Off
Cunter ST I> 22
Cunter ST I>> 22
Cunter ST I>>> 22
Cunter ST IE> 22
Counters Cunter ST IE>> 22
Cunter TR I> 22
Cunter TR I>> 22
Cunter TR I>>> 22
Cunter TR IE> 22
Cunter TR IE>> 22
Read F - Number 1
F - Cause aaa
F - Phases aaa
F - IL1 0.0000 In
F - IL2 0.0000 In
F - IL3 0.0000 In
F - IE 0.00000 IEn
Last fault
F - Year 2009
F - Month 7
F - Day 22
F - Hour 9h
F - Minute 45 m
F - Second 44 s
F - Millisecond 567 ms
Code NA016-a
Serial 35322
Info Firmware release 1.00
Nominal freq. 50 Hz
Protection trip Protection trip None
Self-test None
Self-test Self-test cause None
Self-test latch None
Inp value 300
Inp unit A
Base IEnp value 100
IEnp unit A
Reading Direct
K1 Trip
p I>>-Tripp I>>>-Tripp IE>
g
K1 logic g
De-energized
K1 mode No-latched
K1 tTR 200 ms
K2 None
K2 logic De-energized
K2 mode No-latched
Relays K2 tTR 200 ms
Set
K3 None
K3 logic De-energized
K3 mode No-latched
K3 tTR 200 ms
K4 None
K4 logic De-energized
K4 tTR 200 ms

SETTING AND COMMISSIONING NA016 - Manual - 08 - 2009 53


I curve IEC/BS B
I>inv 1.00 ln
t>inv 1.00 s
I>>def 7.00 ln
50 / 51 t>>def 0.03 s
t>>RES 0 ms
I>>>def 7.00 ln
t>>>def 0.03 s
t>>>RES 0 ms

IE>def 0.030 lEn


Set tE>def 1.00 s
tE>RES 50 ms
50N / 51N IE>>def 0.050 lEn
tE>def 0.04 s
tE>>RES 50 ms
CB Diagnostic
g Off
Circuit breaker 74 TCS Off

Clear

Store

Records stored 0
Oscillography Info Last record 0
Records state Acquire

pprotocol RS485 Modbus


Address 1
Communication Baudrate RS485 9600
Enable TX delayy 2 ms
Start TX delay 1 ms

Test off >


Test I> led >
Test I>> led >
Test I>>> led >
Test IE> led >
Test Test IE>> led >
Test I> full >
Test I>> full >
Test I>>> full >
Test IE> full >
Test IE>> full >
Reset counters >
Reset Reset alarm >

Set year
y 2009
Set month 7
Set dayy 24
Time Set hour 9h
Set minute 22 m
Set second 0s

Set default PAR


Option Set default REE

54 NA016 - Manual - 08 - 2009 SETTING AND COMMISSIONING


7.4 MAINTENANCE

The devices do not require any particular maintenance; all circuits use high quality static com-
ponents, the subassembly products undergo dynamic checks on their functioning before the final
assembling of the complete equipment. The dedicated circuits and the firmware for the self-test
function continuously check the relay operation; the continuously operating auto-zeroing function
dynamically corrects the measuring errors due to offset, heat dependent drifts, aging of components,
etc.
The microprocessor is equipped with a watch-dog circuit which restores the correct operation of
the firmware in case of fault.
The possibility of reading the value of the signals measured on the display (the relay used as an am-
meter) allows one to check both the system parameters and the operation of the protection relays at
any time. The relay can be preset as well to show the current values referred to the nominal current
of the current transformers, as directly in primary amperes (according to the preset value of CT’s
nominal primary current); the same is done for the input voltages.
If connected to the central control unit, all data available on the display can be checked and pro-
cessed thus performing a continuous check and maintenance.

7.5 REPAIR
No repair of possible faults by the client is foreseen; if following to any irregularity of operation, the
above tests confirm the presence of a fault, it will be necessary to send the relay to the factory for
the repair and the consequent settings and checks.

7.6 PACKAGING
The devices must be stored within the required temperature limits; the relative humidity should not
cause condensation or formation of frost.
It is recommended that the devices are stored in their packaging; in the case of long storage, espe-
cially in extreme climatic conditions, it is recommended that the device is supplied with power for
some hours before the commissioning, in order to bring the circuits to the rating conditions and to
stabilize the operation of the components.

SETTING AND COMMISSIONING NA016 - Manual - 08 - 2009 55


8 APPENDIX
8.1 APPENDIX A1 - Inverse time IEC curves
‡ Mathematical formula
The mathematical formula, according the IEC 60255-3/BS142 standards is:[1]

K
t = t> inv ·
[(I/I> inv)α-1]

Where:
• t = operate time (in seconds)
• t I>inv = setting time multiplier (in seconds)
• I = input current
• I>inv = threshold setting

K coefficient:
• K = 0.14 for IEC-A curve (Normal inverse)
• K = 13.5 for IEC-B curve (Very inverse)
• K = 80 for IEC-C curve (Extremely inverse)

α curve shape constant:


• α = 0.02 for IEC-A curve (Normal inverse)
• α = 1 for IEC-B curve (Very inverse)
• α = 2 for IEC-C curve (Extremely inverse)

For all inverse time characteristics, following data applies:


• Asymptotic reference value (minimum pickup value): 1.1 I>inv
• Minimum operate time: 0.1 s
• Range where the equation is valid:[2][3] 1.1 ≤ I /I>inv ≤ 20
• If I> pickup ≥ 2.5 In, the upper limit is 50 In

Note 1 Symbols are concerning the overcurrent element. The comprehensive overview of the inverse time characteristics concerning the 50/51 and
50N/51N elements is dealt within the PROTECTIVE ELEMENTS section
Note 2 When the input value is more than 20 times the set point , the operate time is limited to the value corresponding to 20 times the set point
Nota 3 With setting more than 2.5 In for the 50/51 elements and 0.5 IEn for the 50N/51N elements, the upper limit of the measuring range is limited to 50
In and 10 IEn respectively.

56 NA016 - Manual - 08 - 2009 APPENDIX


‡ Phase overcurrent 50/51 - Standard inverse time curve (IEC 60255-3/BS142 type A)

t [s]
10000 0.14
t =t> inv ·
[(I/I> inv)0.02-1]

1000

t> inv = 60 s
100

t> inv = 10 s

t> inv = 5 s
10

t> inv = 1 s

t> inv = 0.5 s


1

t> inv = 0.2 s

t> inv = 0.1 s

0.1 t> inv = 0.02 s

0.01
I /I>inv
2 3 4 5 6 7 8 9 10 20
1.1

Note: match of operating and setting time takes place when I/I>inv = 700
F_51-IECA-Char.ai

APPENDIX NA016 - Manual - 08 - 2009 57


‡ Phase overcurrent 50/51 - Very inverse time curve (IEC 60255-3/BS142 type B)

t [s]
10000
t =t> inv · 13.5
[(I/I> inv) -1]

1000

100

t> inv = 60 s

10
t> inv = 10 s

t> inv = 5 s

1
t> inv = 1 s

t> inv = 0.5 s


t> inv = 0.1 s

t> inv = 0.2 s

0.1 t> inv = 0.02 s

0.01
I /I>inv
2 3 4 5 6 7 8 9 10 20
1.1
Note: match of operating and setting time takes place when I/I>inv = 14.5
F_51-IECB-Char.ai

58 NA016 - Manual - 08 - 2009 APPENDIX


‡ Phase overcurrent 50/51 - Extremely inverse time curve (IEC 60255-3/BS142 type C)

t [s]
100000
t =t> inv · 80
[(I/I> inv)2-1]

10000

1000

100

t> inv = 60 s
10

t> inv = 10 s

1 t> inv = 5 s

t> inv = 1 s

0.1
t> inv = 0.02 s t> inv = 0.1 s t> inv = 0.2 s t> inv = 0.5 s

0.01 I /I >inv
2 3 4 5 6 7 8 9 10 20
1.1

Note: match of operating and setting time takes place when I/I>inv = 9
F_51-IECC-Char.ai

APPENDIX NA016 - Manual - 08 - 2009 59


8.2 APPENDIX B1 - I/O Diagram

Traditional CT input circuits Low powerCT input circuits (LPCTs)

NA016 NA016
K1 A2 K1 A5
C1 A1 A4
IL1
C2 A3 L1 A6
CURRENT INPUTS

CURRENT INPUTS
C3 K2 A4 K2 A9
OUTPUT RELAYS

OUTPUT RELAYS
IL2
A6 L2 A8
C4
A5 A7
C5
IL3 K3 A9 K3 A3
L3
C6 A8 A2
C7 A7 C7 A1
IE
K4 A11 IE
K4 A11
C8 C8
A12 A12
A10 A10

A13 A13
IN1 IN1
A14 A14
CIrcuit Breaker CIrcuit Breaker
Monitoring Monitoring
A15 A15
IN2 IN2
A16 A16

A17 Trip Circuit A17 Trip Circuit


IN3 Supervision (TCS) IN3 Supervision (TCS)
A18 A18

A19 ≅ A19 ≅
UAUX UAUX
A20 A20

A+ 3 A+ 3
FRONT PANEL FRONT PANEL
B- B-
RS485

RS485

2 E1 2 E1
RS232

RS232

120Ω 120Ω
1 1

A21 A21
A22 A22

Input-output circuits NA016-I-O.ai

60 NA016 - Manual - 08 - 2009 APPENDIX


8.3 APPENDIX B2 - Interfaces

NA016

A+ 3
FRONT PANEL
B-
RS485

2 E1
RS232

120Ω
1

A21
A22

Interfaces.ai

APPENDIX NA016 - Manual - 08 - 2009 61


8.4 APPENDIX B3 - Connection diagrams
Note: Some typical connection diagram are shown.
All diagram must be considered just as example; they cannot be comprehensive for real applications.
For all diagrams the output contacts are shown in de-energized state for standard reference.

DG

NA016
P1 C1
S1
IL1
S2 C2
P2 C3
IL2 50/51
C4
C5
IL3
C6

P1 C7
S1
IE 50N/51N
S2 C8
P2

A13
IN1
A14
CIrcuit Breaker
CB position Monitoring
A15
IN2
A16

A17 Trip Circuit


IN3 Supervision (TCS)
A18

Three phase CTs and residual current from core balanced CT NA016-SCH.ai

62 NA016 - Manual - 08 - 2009 APPENDIX


DG

NA016

P1 C1
S1
IL1
S2 C2
P2
C3
IL2 50/51
C4
C5
IL3
C6

P1 C7
S1
IE 50N/51N
S2 C8
P2

A13
A14 IN1
CIrcuit Breaker
CB position Monitoring
A15
A16 IN2

A17
Trip Circuit
A18 IN3 Supervision (TCS)

Two phase CTs and residual current from core balanced CT NA016-SCH2.ai

APPENDIX NA016 - Manual - 08 - 2009 63


† Connection diagram with Data Logger

+UAUX

DG 52a 52b 52a 52b

-UAUX
R

NA016
A2
P1 C1 K1
A1 TRIP
S1
S2 C2 IL1 A3 +UAUX
P2 C3
CURRENT INPUTS K2 A4

OUTPUT RELAYS
IL2
C4 A6
C5 A5
IL3 K3 A9
C6
A8
P1 C7 A7
S1
S2 C8 IE
K4 A11
P2 A12
A10

A13
A14 IN1
CIrcuit Breaker
A15
Monitoring

-UAUX
A16 IN2

A17
Trip Circuit
+UAUX
A18 IN3 Supervision (TCS)

A19 ≅
UAUX
A20

A+ 3
FRONT PANEL
B-
RS485

2 E1
RS232

120Ω
1

A21
A22

64 NA016 - Manual - 08 - 2009 APPENDIX


8.5 APPENDIX C - Dimensions

FRONT VIEW REAR VIEWS

107 101 101

D1 D1

L1
A1 A1
A2 A2
C1 C2
A3 F1 A3 F1
L2
A4 RX F2 A4 RX F2
A5 F3 A5 F3
1 2 3 4 5
A6 F4 A6 L1 F4
TX TX
F5 L3 F5
A7 A7 1 2 3 4 5
A8 C3 C4 A8 L2
A9 B1 A9 1 2 3 4 5 B1
A10 B2 A10 L3 B2

171

171
149

149
177

A11 B3 A11 B3
LPCT Setting
A12 B4 A12 50 B4
ON 1 2 3 4 5 100
START A13 B5 A13 200 B5
400
A14 C5 C6 B6 A14 800 B6
TRIP
A15 B7 A15 B7
A16 B8 A16 EX. In = B8
300A
(100+200)
A17 A17
A18 A18
A19 A19
A20 C7 C8 A20 C7 C8

A21 A21

3
A22 A22

2
1
E1 E1

Phase CTs inputs LPCTs Phase inputs

SIDE VIEW FLUSH MOUNTING CUTOUT

102.5 ±0.3
75 30 70
161
154

N.4 holes ø 3.5

DATA LED

In 5A 1A 5A
IEn 5A 1A 5A
ON & Self test
UAUX 24-230 Vac/dc
1 50-51 Start
2 50N-51N
Trip
3 CB OPEN
4 CB CLOSED
5 TCS

NA016#5M00

APPENDIX NA016 - Manual - 08 - 2009 65


8.6 APPENDIX D - Revisions history

DSP
SW
Firmware Documentation Communication Upgrade procedures Description
Release
Release

1.00 - NA016-Manual-08-2009 ThySetter 3.5.3 - First edition

66 NA016 - Manual - 08 - 2009 APPENDIX


8.7 APPENDIX E - EC Declaration of conformity

Manufacturer: THYTRONIC S.p.A.


Address: Piazza Mistral 7 - 20139 MILANO

The undersigned manufacturer herewith declares that the product


Protection relay - type NA016

is in conformity with the previsions of the following EC directives (including all applicable amendments) when installed in accordance
with the installation instructions:
Reference n° title
2006/95/EC Low Voltage Directive
2004/108/EC EMC Directive

Reference of standards and/or technical specifications applied for this declaration of conformity or parts thereof:

- harmonized standards:

nr issue title

EN 61010-1 11.2001 Safety requirements for electrical equipment for measurement, control and laboratory use

EN 50263 08.2000 Electromagnetic compatibility (EMC)


Product standard for measuring relays and protection equipments

EN 61000-6-4 (EN 50081-2) 11.2007 Electromagnetic compatibility (EMC)


Emission standard for industrial environments

EN 61000-6-2 (EN 50082-2) 12.2005 Electromagnetic compatibility (EMC)


Immunity standard for industrial environments

- other standards and/or technical specifications:

nr issue title

CEI 0-16 07.2008 Regola tecnica di riferimento per la connessione di Utenti attivi e passivi alle reti AT e MT delle imprese
distributrici di energia elettrica

EN 61810-1 02.2004 Electromechanical elementary relays


General and safety requirements

EN 60255-6 (CEI 95-1) 05.1998 Electrical relays - Part 6: General requirements for measuring relays and protection equipment

IEC 60255 Electrical relays

Year of CE marking: 2009

Signature .............................................

Name FIORE Ing. GIOACCHINO


Title Managing director
Date 07-2009

APPENDIX NA016 - Manual - 08 - 2009 67


Headquarter: 20139 Milano - Piazza Mistral, 7 - Tel. +39 02 574 957 01 ra - Fax +39 02 574 037 63
Factory: 35127 Padova - Z.I. Sud - Via dell’Artigianato, 48 - Tel. +39 049 894 770 1 ra - Fax +39 049 870 139 0

www.thytronic.it thytronic@thytronic.it www.pro-n.it

You might also like