Professional Documents
Culture Documents
RMESH
2F B2, Bonifacio Highstreet Bonifacio, Bonifacio Global City, Taguig City, Philippines • Trunkline (02) 856 6888 • www.steelasia.com
R-Mesh is widely-used as a
substitute for commercial
bars in walls and slabs,
foundations, and footings.
It reduces the placement
work of large amount of
ADVANTAGES
manual tying and provides
WRM) is a factory pre-fabricated reinforcement steel much
WRM morethe
delivers reliable
following advantages
are fused with resistance welding technology. This bonding between the steel
uce the original tensile strength of the steel and the ➢ REDUCED TIME FOR PLACEMENT of
bars.
weather condition for progress on si
of the force needed to break the weld.
➢ REDUCED DEPEDENCY OF FIELD LAB
➢ LESS SITE SPACE NEEDED for on-site
➢ BONDING BETWEEN BARS IS MUCH
assembled rebars – this reduces the
ute for commercial bars in walls & slabs,
➢ LESS CRACKING ON CONCRETE as th
uces the placement work of large amount of
➢ LESS WASTAGE OF REINFORCING ST
liable bonding between the steel bars.
size for exact placement (ENGINEERI
➢ LESS QUALITY ISSUE OF BENDING &
undergo proper quality
TRANSVERSE BAR W check and co
LONGITUDINAL BAR
RMESH DELIVERS THE FOLLOWING
ADVANTAGES TO THE CONSTRUCTION ADVANTAGES
INDUSTRY: WRM delivers the followingequal one-half
advantages
SIZES & STEEL GRADES
End overhangs should
to of
theaconstruction industry:
h (WRM) is a factory pre-fabricated reinforcement steel
that are fused with resistance welding technology. This
transverse space.
Unless otherwise
➢ REDUCED TIME FOR PLACEMENT of the reinforcing steel – and hence will be less dependence on
reduce the original
SAFEtensile strength of the steel and the
0% of the force needed to break the weld.
specified
weather condition for progress by the
on site CROSS & LINE
SP
L
➢ REDUCED DEPEDENCY Architect/Engineer.
BONDING BETWEEN BARS IS MORE RELIABLE for the welded OF FIELD LABOUR for placement of the reinforcing steel
WIRE DIAMETER
➢ LESS SITE SPACE NEEDED for on-site steel fabrication (
joints compared to the manually-assembled rebars, reducing
➢ BONDING BETWEEN BARS
Side IS MUCH RELIALBLE
overhangs may for the welded joints(mm)
compared to the manual
the risk ofbars
displacement of bars during concrete pouring assembled rebars – this reduces
vary asthe risks of displacement of bars during concrete pouring
required
stitute for commercial in walls & slabs,
reduces the placement work of large amount of
➢ LESS CRACKING ON CONCRETE
and do as the
not smaller
need to diameter of rebar and x 6.0 can be utilized 10
6.0spacings
LESS CRACKING ON
e reliable bonding between the steel bars.
CONCRETE as the smaller diameter of
➢ LESS WASTAGE OF REINFORCING
be equal. STEEL since the WRM is factory fabricated and can be customiz
Overhang
size for exact placement (ENGINEERING
lengths are limitedMESH)
by
rebar and spacing can be utilized ➢ LESS QUALITY ISSUE OF BENDING
overall sheet FABRICATION ON SITE as the7.0
& width. WRM x is7.0
factory fabricated 15
tha
LESS QUALITY ISSUE OF BENDING AND FABRICATION ON undergo proper quality check and control S