WATER BATH Aim: To lay down the procedure for operation of water bath.
Procedure:
1. Connect the power supply.
2. Ensure the water level in water bath is sufficient to pour the heating element. 3. Switch “ON” the main power supply and instrument mains. Temperature setting 4. Press SET key to set the required temperature. press ↑ to increase the temperature and ↓ to reduce the temperature 5. The temp. Sensor will maintain the set temp. During use of water bath. 6. Switch “OFF” the instrument mains & main power supply after use. Attention DO NOT add too much water, so as not to overflow during water is boiling. After used the water bath, you should drain away water in time, clean the working chamber, so as to extend life span of instrument Instructions : Glowing of Red lamp indicate mains “ON” & Glowing of yellow lamp indicate heater “ON”
1. Always ensure platform & surrounding are dry.
2. Use only Purified water to fill water bath. 3. Always. Switch “OFF” the mains on completion of water bath use. 4. Do not disturb the capillary (Temp. Sensor) located near the heater.