Professional Documents
Culture Documents
The service pack consists of two Service-CDs that need to be used depending on the installed
navigation SD card to update the system.
If the wrong service CD is used, the update process MUST NOT be interrupted.
When finished the correct CD must then be used to update the navigation system
Updating with the wrong CD may cause malfunction of the navigation device.
Please read the update instructions carefully and proceed according to the steps described here.
Therefore, make sure when starting and during the update that there is no electrical load
(eg door mirror / front / rear window demister are switched off).
Additionally, make sure that the engine is started before the launch of the update and is not
switched off until the update is complete
Alternatively, connect to external power source with sufficient battery capacity (charger)
when running the engine is not allowed (Workshops without exhaust extraction).
At the start and middle of an update, the engine should not be started.
Do not press any buttons on the navigation unit during the entire update process.
After the software update, it may happen that despite activated human voice, the audible
navigation instructions no longer be issued.
In this case, the system must be completely powered down once for at least 15 min while
the vehicle with doors closed during this time.
UPDATE SCHEDULE
For the update, the following steps are necessary.
• Engine start / Connect to external power source
• Switch on the navigation device
• Return navigation unit ‘Factory Settings’
• Disable Navigation SD card
• Remove Navigation SD card
• Insert appropriate Service CD
• Update process start
• Update process complete
START
Start the engine, or connect to alternative external power source with sufficient battery
capacity (charger).
To delete the navigation targets in the target storage, please proceed as follows:
• Press the "MENU" button
• Touch the on-screen "Factory Settings" button.
• Reset “Nav/Map Settings”, “Destination Memory” and System Settings” to default
• Confirm the resetting of the above by pressing the on-screen "Yes" button.
The “Download” window will be displayed (“Installed Version” and “CD Version” of
system software will be displayed).
Should the system not restart automatically, press the on/off button.
After the system has restarted, the input of security codes is required. The deactivation
of the security code after your input can be delayed by a few seconds (first entry after
software update).
COMPLETE UPDATE PROCESS
• After the end of the update process, the Service CD is automatically ejected and can be
removed.
If the Service CD is not removed after 10 second, it will be automatically reloaded and
the “Download” screen will appear once again.
• If this should happen, touch the on-screen "Cancel" button, and the CD will be ejected
again.
• Insert the previously removed navigation SD card into the SD card slot.
Depending on the navigation SD card you use, the “Download” window may appear.
• In this should happen, touch the on-screen "Next" button to proceed with the update.
ATTACH COVER
• Position the rounded spring clip spring on the plastic ribs, according to the figure below.
• Press the cover completely in the fascia until it locks into place.
• Refit the volume knob to finish.
NEW SETTINGS
Please note that the settings for map, navigation, radio, screen, time, sound, language and
voice control will be reset to the factory settings after a successful software update.
This document was translated by Ripperoo for the TalkFord and Ford Owners Club communities and is not to be sold. If you paid for this
document, please let me know at thieving-bastards@ripperoo.plus.com, with details of where and from whom this was purchased.