Professional Documents
Culture Documents
MAINTENANCE SERVICE
00-75
12. TRANSMISSION FLUID <CVT>
M1001022700035
TSB Revision
00-76 GENERAL <BODY AND CHASSIS>
MAINTENANCE SERVICE
CHANGE
1. Remove the drain plug on the bottom of the transmission
case to drain the transmission fluid.
Draining amount: Approximately 2.5 dm3 (2.64 qt)
2. Install the drain plug with a new gasket to the transmission
case, and tighten it to the specified torque.
Tightening torque: 35 4 N m (26 2 ft-lb)
CAUTION
If the transmission case becomes full before filling 2.5 dm3
ACB04729AB
(2.64 qt) of transmission fluid, stop filling the transmission
fluid.
3. Fill in the new transmission fluid through the oil filler tube.
Filling amount: Approximately 2.5 dm3 (2.64 qt)
Transmission fluid: MITSUBISHI MOTORS GENUINE
CVTF-J4
4. Start up the engine and let it idle for 1 to 2 minutes.
5. Move the selector lever to every position, and then move it
to the P or N range.
6. Stop the engine and perform the above steps 1 to 5 again.
7. Stop the engine, and discharge a small amount of
transmission fluid to check for fouling. If fouling is found,
repeat steps 1 to 5 until clean transmission fluid comes out.
8. Drive the vehicle until the transmission fluid is warmed up to
the normal operating temperature 50 80 C (122 176 F),
and check the transmission fluid level. It must be within the
"H" area on the oil level gauge.
NOTE: The "C" level is for reference only. Use the "H" level
as the criteria.
NOTE: Use scan tool (M.U.T.-III.) to measure the transmis-
sion fluid temperature.
NOTE:
ACB04730
TSB Revision