1. (Nair, Sawdust Polymer Polymer The polymer
Kamath, & composite composite composites have Shetty, percentage different percentage. 2016) of matrix the sawdust is use (85, 80, different percentage by 75, 70%) weight. This study Sawdust shows a 12.75% and percentage 17.25% increase in of matrix tensile strength and (0, 5, 10, hardness respectively. 15%) Result, the higher of percentage of the sawdust will make the tensile and hardness increase. The test that use is Tensile and hardness test. 2. (Kumar, Sundi Epoxy Epoxy and Sundi wood dust has Kumar, wood hardener been tested with seven Sahoo, & dust 10:8 different filler. The Bhowmik, Wood dust tensile and flexural 2014) particle were test to study the size is mechanical behaviour 2 µm and of the composites. density From this research the 1.26g mechanical property increases up to certain filler age and then properties gradually decrease. This wood dust has a good filler characteristic. The experimental results confirm that Sundi wood dust reinforced epoxy composites have better filler characteristics 3. (Mishra, Wood Epoxy Wood The composite of teak 2014) dust dust wood has 3 type of 150µm, size. 150µm,212 µm 212µm, and 300 µm. It uses 300µm. hand moulding Volume technique. The size of fraction moulding is 8mm (10% by diameters 50 mm weight) length. From 3 size of sawdust 150 µm is the best choice. Teak composite 150μm in size has the highest elasticity and density modulus obtained by mixing rule. The ratio that use in this research is 10% sawdust and 90% epoxy. The test that use are disc wear and friction testing machine. 4. (Library, Sawdust Epoxy Epoxy, Composition sawdust 2011) (SW) chip (SW) and chip wood wood (CW) have three 100:40 different sizes coarse, Chip rough, soft. The wood Epoxy, specimen is 6mm (CW) sawdust thickness according to 100:40 ASTM standard. SW and CW has higher tensile strength at rough. The mixing material with resin are excellent. The tensile strength increase trend when soft to rough particle.
5. (Sued, 2011) Sawdust Epoxy Sawdust The composite has
Chip and Chip three different size of wood wood 14% fibre soft, rough, and ratio by coarse that derived weight from chip wood and loaded to sawdust. This epoxy specimen is form with the using open mould base weight on ASTM standards. 100g and From this research, hardener rough size particle of weight sawdust has higher 40g strength of tensile than the chip wood.