Professional Documents
Culture Documents
Design (Metric) 5 (1) .37
Design (Metric) 5 (1) .37
37
Customer Name
Conveyor Number
Conveyor Length (m) 1000
Load (T/hour) 700 86.8 kW
Belt Speed (m/s) 2.5 1050 mm
Material Lift Height (m) 0 RECOMMENDED DRUM MOTOR
Ambient temperature (deg C) Min -10 90 kW
Ambient temperature (deg C) Max 40 2.5 m/s
Initial Velocity of Material (m/s) 0 JOKI Model(s):
Number of Belt Cleaners 2 800
Number of Belt Ploughs 1 $0
Length of Skirt Zone (m) 3
Depth of Mat'l in skirt zone (mm) 25
Number of Non-driven Pulleys 4 ALTERNATE DUAL DRIVE OPTION
0 Kg/m 0 55 kW/ea
2.5 m/s
JOKI Model(s):
Elevation (Km above sea level) 1.0 630, 800
Type of Material Sand, dry bank $0
Belt Width (mm) 1000 0
Belt Carcass Type Fabric
Idler Roll diam (mm) 108
CEMA Type (A,B,C,D,E) C RECOMMENDED OPTIONS:
Troughing (carrying) Idler Spacing (m) 1.2
n 50 Hz power.)
eek/yr operation
V-belt drive)
or 71629 Kw-Hrs/Yr, 3
2 €/Yr, 3 shifts/day @
11/26/19
Date
www.rulmecacorp.com
www.rulmeca.com
© Copyright - Rulmeca Group
0 11/26/19
0 Date
0 www.rulmecacorp.com
www.rulmeca.com
© Copyright - Rulmeca Group
0 0 0
Telephone Telefax e-mail
0 0
Project Name Conveyor Reference
0 11/26/19
0 Date
0 www.rulmecacorp.com
www.rulmeca.com
© Copyright - Rulmeca Group
0 0 0
Telephone Telefax e-mail
0 0
Project Name Conveyor Reference
Surcharge Angle of
Description of Material
Angle Repose
Uniform size, very small rounded particles, either very wet or very dry; such as dry silica sand,
5 0 to 19
cement, and wet concrete.
10 20 to 29 Rounded, dry polished particles, of medium weight, such as whole grain and beans.
Irregular, granular or lumpy materials of medium weight, such as anthracite coal, cottonseed
20 30 to 34
meal, and clay.
25 35 to 39 Typical common materials such as bituminous coal, stone, and most ores.
Irregular, stringy, fibrous, interlocking material, such as wood chips, bagasse, and tempered
30 40+
foundry sand.
Note:
This program uses actual C.O.G.* height above
top of belt (based on actual cross section) to plot
trajectory. Height of C.O.G. for CEMA
max. allow. cross section is given for ref. only. Design Cross Section - dotted red line; CEMA max allow. - solid black line.
*C.O.G. = center of gravity of material, shown as ∆ and ∆