You are on page 1of 4
STARTING THE ENGINE AND DRIVING OFF THE VEHICLE Eei Automatic transmission equipped vehicle Move the selector lever to “P” position and depress th brake pedal. pply the parking brake. fake sure that there are no persons or obstacles in the anger area around the vehicie. WARNING automatic transmission equipped vehicle, depress the brake dal when the selector lever is at “P” position. Never depress .ccelerator pedal CAUTION e engine in automatic transmission equipped vehicle can be rted only when the selector lever is at “P” or “N” position * position is preferred). jesel engine equipped vehicle: Tum the ignition key to “ON” position and check the ap- propriate warning lights are operating. The preglow indi- cator light will come on and go out when the glow plugs are sufficiently heated for cold engine starting. As soon as the glow indicator goes out, start the engine. Crank the engine without touching the accelerator pedal by turning the igniting key to the “START” position. Release the key when the engine starts. If the engine starts, but fails to run, repeat the above procedure. 8. Release the parking brake. 9. * Automatic transmission equipped vehicle Keep the brake pedal depressed and shift inte -D position. Drive off the vehicle by releasing the br pedal slowly. ENGINE HOOD 1. To open the engine hood, pull the release knob @ located ‘on left lower side of instrument panel to unlatch the engine hood. The engine hood will then be unlocked and partially ‘opened. 2. Push the safety catch 4 Wanting fever located under the "An open engine hood with engine running exposes moving parts hood to the arrow direc-” ‘hich ean gush, eut or entangle tion @ and tift up the. Gheck thatthe engine hood is ful latched in postion by puling atts engine hood. front eoge tore drvng. + To avoid a personal injury, take care of the separation of the sup- Prt rod from the siot especially in windy day. 3. To hold the engine hood in the open position, insert the sup- port rod © into the slot FUEL FILLER DOOR 1. Open the fuel filler door © by pulling the release lever @ located on left lower side of driver's seat. A wasnc ‘Sto the engin blo retusing @ Fuel Filler Door Release Lever 2 warns *+ Gasoline vapor is highly lammable. I burns violently and that can cause very bad injures. ‘+ Whon refueling, + Switch off engine. + Nosmoking + Nonakedflame. + Nosparking materia + Using low qualty fuel could resut in a serious damage to the engine ‘due to the water or impuries in fuel. Never use the low quailty fuel, A. caution ‘+ Fuel damages paintwork. {fuel spils onto paintwork, immediately wash the affected area with cold water. ‘+ The fuel filer door may not open in cold weather. Push or tap fuel filor door Bghty to open. 2. Open the fuel filler cap @ by turing it counterclock- wise @. 3. After refueling, tighten the fuel filer cap by turn- ing it clockwise @ and push the fuel filer door © roperly until it latches. @cise

You might also like