To include lateral strain data in curve fit, be sure to add ‘/USEL,1’ at beginning of txt file containing lateral strain data. Otherwise, it is ignored in the curve fitting routine. …Ogden Foam Curve Fitting Read Experimental Data into MAPDL Curve fitter …Ogden Foam Curve Fitting Curve fit 3rd order Ogden Foam – …Ogden Foam Curve Fitting /prep7 Use APDL commands to fit a 4th /com,Curve Fitting Experimental Data Written To strain_lateral_stress-1.txt TBFT,EADD,1,UNIA,strain_lateral_stress-1.txt order Ogden foam Material /com,Curve Fitting Experimental Data Written To Vratio_Hpressure-1,txt Model. GUI only supports 3rd TBFT,EADD,1,VOLU,Vratio_Hpressure-1,txt Order. TBFT,FADD,1,HYPER,FOAM,4 TBFT,SET,1,HYPER,FOAM,4,1,1 TBFT,SET,1,HYPER,FOAM,4,2,1 Note: Default Initialized TBFT,SET,1,HYPER,FOAM,4,3,1 coefficients of “1” also give a good TBFT,SET,1,HYPER,FOAM,4,4,1 fit. These customized initial values TBFT,SET,1,HYPER,FOAM,4,5,1 offer a slight improvement. TBFT,SET,1,HYPER,FOAM,4,6,1 TBFT,SET,1,HYPER,FOAM,4,7,1 TBFT,SET,1,HYPER,FOAM,4,8,1 ‘CFIT’ commands at end will list TBFT,SET,1,HYPER,FOAM,4,9,1 out the fitted datapoints in tabular TBFT,SET,1,HYPER,FOAM,4,10,1 form in solver output. TBFT,SET,1,HYPER,FOAM,4,11,1 TBFT,SET,1,HYPER,FOAM,4,12,1 ! Refer to APDL Commands Manual TBFT,SOLVE,1,HYPER,FOAM,4,1,1000,0,0 for command syntax details. ! cfit,,dflag,fitteddatlist cfit,,cfname,hyfoam4 cfit,debug …Ogden Foam Curve Fitting
“Experimental Data” = Stress vs Uniaxial Strain
“Hyperfoam Order 4”
Hydrostatic Stress vs Volume Ratio
Looks ok
“Lateral Strain” = Lateral Strain vs Uniaxial Strain
“Fitted Lateral Strain” … …Ogden Foam Curve Fitting(4th order) Use middle mouse button to strategically “hide” curves for clarity
“Fitted Lateral Strain”
“Lateral Strain” = Lateral Strain vs Uniaxial Strain