Professional Documents
Culture Documents
Figure 8 Figure 9
(13) Open/Shot circuit measurement
(a) set function switch to position
insert black test lead into COM terminal, red test lead into V Ω
terminal. Put the testing lead in parallel with the testing circuit.
The buzzer will “beep --- “ when the resistance in circuit is below 30
Ω.
Note : the power should off when measuring the circuit.
Figure 6 Figure 7 Otherwise, it will damage the meter.
(14) Data Hold switch
(10) Temperature measurement Depress this switch when indicated value is desired to be held. “H”
Set the function switch into ºC position when measuring the mark is indicated in the display while indicated value is being held
temperature, insert the black thermocouple into terminal, please note for easy reading. To release “HOLD”, depress the switch or switch
the “+ -“ pole. The hot terminal thermocouple (testing point) put over to function switch. “H” mark will disappear from the display
into the testing position. Read the temperature value on the LCD and return to ready mode.
screen. The reading is ºC (for detail see figure 8). (15) Backlight function
Note : Depress the “LIGHT” key, the backlight will on. It is very easy to
(i) reading format : the temperature is automatically measured when read the display in the dark environment. Toggle the key, the
connected with thermocouple. When the thermocouple is not backlight will off.
inserted or the thermocouple is at the state of open-circuit, it is (16) Display Angle section
shown the environmental temperature. This series of multimeters are provided with protection holsters,
(ii) attached with accessory of TP-01 (K type) simple thermocouple, which can support the meter in different angles as well as protection
the maximum temperature is 250ºC (300ºC for instant) to the meter. This is convenient to observe the reading.
(11) Transistor hFE measurement Maintenance
set the function switch in “hFE” position. It is a precise electronic multimeter. Read and understand the
make sure the transistor is ‘PNP” type or “NPN” type, then insert E,