Professional Documents
Culture Documents
com/electric-traction-electrical-engineering-objective-type-
questions-and-answers/
http://www.electricalnotes4u.com/2017/08/most-asked-electrical-engineering.html
1 What is the minimum Head light Focusing distance required in the locomotives provided
with electrical head light? . d
a) 100 meters
b) 1000 meters
c) 2000 meters
d) 250 meters and above
Ans: c
7. Overload capacity of diesel engines is usually restricted to
(a) 2 percent
(b) 10 percent
(c) 20 percent
(d) 40 percent
Ans: a
8. In case of steam engines the steam pressure is
(a) 1 to 4 kgf/cm2
(b) 5 to 8 kgf/cm2
(c) 10 to 15 kgf/cm2
(d) 25 to 35 kgf/cm2
Ans: c
9. Which of the following is the advantage of electric braking ?
(a) It avoids wear of track
(b) Motor continues to remain loaded during braking
(c) It is instantaneous
(d) More heat is generated during braking
Ans: a
10. Co-efficient of adhesion is
(a) high in case of D.C. traction than in the case of AC. traction
(b) low in case of D.C. traction than in the case of AC. traction
(c) equal in both AC. and D.C. traction
(d) any of the above
Ans: b
1. The friction at the track is proportional to
(a) 1/speed
(b) l/(speed)2
(c) speed
(d) none of the above
Ans: c
15. The value of co-efficient of adhesion will be high when rails are
(a) greased
(b) wet
(c) sprayed with oil
(d) cleaned with sand
Ans: d
16. The voltage used for suburban trains in D.C. system is usually
(a) 12 V
(b) 24 V
(c) 220 V
(d) 600 to 750 V
Ans: d
7. For three-phase induction motors which of the following is the least efficient method of
speed control ?
(a) Cascade control
(b) Pole changing
(c) Rheostat control
(d) Combination of cascade and pole changing
Ans: c
21. _______ was the first city in India to adopt electric traction.
(a) Delhi
(b) Madras
(c) Calcutta
(d) Bombay
Ans: d
26. If the co-efficient of adhesion on dry rails is 0.26, which of the following could be the value
for wet rails ?
(a) 0.3
(b) 0.26
(c) 0.225
(d) 0.16
Ans: d
. 7. The illumination is directly proportional to the cosine of the angle made by the
normal to the illuminated surface with the direction of the incident flux. Above statement
is associated with
(A) Planck's law
(B) Macbeth's law of illumination
(C) Bunsen's law of illumination
(D) Lambert's cosine law.
20. Which photometer depends for its operation on Lambert's cosine law ?
(A) Macbeth lllumino meter
(B) Trotter Illumination Photometer
(C) Lummer Brodhum Photometer
(C) Guild's Flicker Photometer.
21. Which photometer depends for its operation on Inverse Square Law ?
(A) Guilds Flicker Photometer
(B) Lummer Brodhum Photometer
(C) Macbeth llluminometer
(D) Trotter Illumination Photometer.