1 Check the condition of the PPE: Illness caused by the ingestion, Personal protective equipment (PPE) should include the following; Inspect the protective boots, inhalation, and/or absorption of toxic Chemical goggles, respirator, protective boots, gloves, jumpsuit, and gloves for tears, chemicals. holes and other damage. 2 Check respirator mask filters and assembly for damage. 3 Adjust respirator mask to fit securely around the mouth and nose. 4 Ensure that the goggles are clean and adjusted to fit securely around the eyes. 5 Review MSDS before handling Illness caused by the ingestion, Personal protective equipment (PPE) should include the following; chemicals. inhalation, and/or absorption of toxic respirator, jumpsuit, chemical goggles, protective footwear chemicals. 6 Put on all personal protective equipment. Use only clean equipment to avoid chemical reaction.
Page 1 of 3 Print Date: Jan/13/2004
7 Dilute and/or mix the Fume-Toxic Use only designated clean mixing containers. Mix only in well- pesticide/herbicide ventilated areas. chemicals following the chemical manufacturers procedures. 8 Pour the mixed chemicals into the sprayer unit container. 9 Install the sprayer unit's pump and nozzle assembly. 10 Before spraying check area Illness and ingestion, inhalation and/or Follow established procedures, ensure no people or animals are in absorption of toxic chemicals. the area 11 Place signage along the perimeter of the spraying area to caution personnel of the hazardous activity. 12 Grasp the sprayer units pump handle and pump until pressure has accumulated in the sprayer unit. 13 DO NOT stand in a downwind Do not spray pesticide/herbicide Follow -established procedures position relative to the area to chemicals in high wind conditions. be sprayed . 14 Carry the sprayer container in Do not spray at or near people or Follow established procedures one hand and the sprayer nozzle animals. in the other hand. 15 Release the pesticide/herbicide chemical from the sprayer unit by opening the valve to the sprayer nozzle. 16 Walk forward and move the sprayer nozzle side to side to uniformly spread the pesticide/herbicide chemical over the area being treated. 17 After treating the area with pesticide/herbicide chemicals, return all signage, chemicals and sprayer unit to the designated storage area.
Page 2 of 3 Print Date: Jan/13/2004
18 Slowly remove the pump and Splash Follow established procedures nozzle assembly from the sprayer unit to release accumulated pressure. 19 Pour any excess pesticide/herbicide chemicals from the sprayer container into a labeled storage container. 20 Remove personal protective equipment and wash any chemicals off with a large volume of water. 21 Clean spraying and mixing equipment. 22 Store personal protective equipment in designated area. 23 When applying granulated and Same as above. Same as above powdered pesticide/herbicide chemicals, the same procedures, precautions and hazards are utilized and exist in the application of granulated and powdered pesticide/herbicide chemicals. The chemical's applicator tool will be different. 24 Ensure that the designated applicator tool is used when applying the pesticide/herbicide chemical.