Professional Documents
Culture Documents
IoT - SCADA
IoT
SCADA
Rev.5 06/2019
Application Note
IoT - SCADA
How It Works
Newtec Dialog® provides the means to establish an “always-on” The hub contains management functionalities to monitor,
two-way IP connectivity between a Remote Terminal Unit (RTU) and configure and control remote sites in large geographical areas.
the Internet or a private network, therefore remaining completely Individual service configurations can be configured to meet
independent from existing terrestrial networks. specific requirements of a remote site.
The basic IP connectivity is extended with Quality of Service (QoS) in To make satellite an attractive alternative for SCADA, the Newtec
forward and return, allowing the deployment of real-time services. terminal implements the most bandwidth efficient technologies,
such as DVB-S2X ACM forward link, 4CPM adaptive return link
The system consists of a hub that can support thousands of and embedded IP traffic enhancement software.
remote terminals with a variety of service levels.
DVB-S2X
DVB-S2 CCT
“Always-on” two-
way IP connectivity RF
GATEWAY
between a Remote MF-TDMA
4CPM
Terminal Unit (RTU)
NEWTEC
and the Internet or a HUB
SCADA MDM2210
IP MODEM
SITE
private network.
IPSEC VPN VOIP RTU VIDEO
MPLS VPN SWITCH
2
Application Note
IoT - SCADA
High Availability
Security at Minimum Cost
Confidentiality of exchanged information is guaranteed. Data Newtec’s simple, yet very efficient implementation of Adaptive
can be directly communicated to the RTU using a single satellite Coding and Modulation (ACM), doubles satellite throughput and
hop. The communication end-points are authenticated which customer satisfaction by providing 100 per cent link availability.
increases the security of the SCADA network.
ACM technology is incorporated into the DVB-S2X standard,
Since the encryption is fully integrated in the system, it can be providing significant increases in bandwidth efficiency for satellite
combined with traffic acceleration and compression, resulting in applications and allowing modification of modulation parameters
real-time network behaviour comparable to traditional delivery of a satellite signal during almost any form of interference, without
networks. interrupting the transmission or losing data.
Since rain fades are statistically short and happen quite rarely over
time, higher modulation parameters can be used most of the
time. However, when SCADA requires a fixed transmission rate or
a permanent high availability, the ACM technology ensures that
the fade only affects one of the services. This mechanism gives
the platform extremely high availability at no additional space
segment cost.
3
4
Application Note
IoT - SCADA
NON REAL-TIME
TIME
Network Scaling
The Newtec VSAT platforms support services ranging from
data-only to voice and video. For many SCADA applications,
adding video will provide extra information when abnormal
events are detected. Integrating video traffic in the SCADA
network will improve operation efficiency by providing
CONTROL
greater insight into events, thus diminishing the potential CENTER
for damage caused by emergency events.
VIDEO
SITE 1
terminals on a minimal hub estate.
VIDEO
5
Application Note
IoT - SCADA
TECHNICIAN
In a typical SCADA scenario, the critical data class would be
DATA RTU
used for the monitoring and control traffic requiring a consistent
low latency.
VIDEO
6
Application Note
IoT - SCADA
Fast Deployment
Newtec VSAT platforms can be operated as a single service
provider platform or a multiservice provider platform. The
latter gives the opportunity to start a service without investing
into a full system.
7
SHAPING THE FUTURE OF SATELLITE COMMUNICATIONS
More Information:
Send a mail to: sales@newtec.eu
Follow us:
You Youtube.com/NewtecSatcom
Twitter.com/Newtec_Satcom Tube
in Linkedin.com/company/newtec Slideshare.net/newtec_satcom
Newtec
Europe
Newtec
North America Newtec
China
Newtec
MENA
Newtec
Asia Pacific
Newtec
South America