Professional Documents
Culture Documents
Nitoprime 31 is used for flooring work with the Nitoflor resin floor- Application
ing range, it is also recommended for some coating systems.
Nitoprime 31 should be applied by brush or short haired qual-
Nitoprime 31 is a two-part solvent free, general purpose aro- ity wool roller. When applying by roller use suitable roller tray
matic amine cured epoxy based primer. Particularly suitable to avoid primer ponding on the floor and to reduce exotherm
for normal weather conditions allowing sufficient time to finish effects which will shorten the pot life.
the flooring/coating application.
The primer should be applied evenly across the surface avoiding
Temperature
thick layers which could result in air entrapment.
All Nitoprime primes should be applied at temperatures of 5oC
The following drying regimes apply depending upon the Fosroc
or above. Use Nitoprime 32 for conditions of above dew point.
product system to be used.
Consult Fosroc Technical Department for specific conditions.
All Nitoflor FC and SL systems. Antistatic and Nitocote EP
Physical Properties
range, allow the primer to dry completely before applying the
Nitoprime 31
flooring/coating product.
Carrier None
Cure time 5oC 24-36 Nitoflor TF5000/10000, Cicol ET Slurry and Nitomortar HB and
(hours) 25oC 6-8 S should be applied whilst primer is tacky.
35oC 2-3
Any porous or absorbed areas are still showing after primer
Pot life 5oC 5-7
application, should be re-primed.
(hours) 25o C 1-2 Cleaning
35oC 0.5-1
Tools and equipment should be cleaned with Fosroc Solvent
Open time (hours) 24 hours after curing
102 immediately after use.
Mix viscosity 25o 1 pose
Mix S.G 25oC 1.05
Coverage kg/m2 0.3
Nitoprime 31
page 1 of 2
Nitoprime 31
Precautions Storage
Some people are sensitive to epoxy resins so gloves and a bar- Package and coverage
rier cream, Kerodex 71, Rozalex 9, Debba-Wet work or similar, Approximate coverage
should be used when handling these products. If contact with
the resin occurs, it must be removed, before it hardens, with
resin removing cream such as Kerocleanse 22, and Rozalex Application Brush Roller Spray
42 follow by washing with soap and water. Do not use Solvent. Type
Nitoprime 31 5-7m2/Kg 7-9m2/Kg 10-12m2/Kg
Fire 1 & 5 Kg Packs
Nitoprime 31 is non-flammable whereas30, 31 and Fosroc Fosroc Solvent 4 & 25 litres
Solvent 102 are flammable. Ensure adequate ventilation when 102
using primers and solvents. Do not smoke during use and do
Supply
not use in the vicinity of naked flames.
Flash points Contact your local Fosroc office or representative.
Additional Information
Important note :
Fosroc products are guaranteed against defective materials and manufacture and are sold
subject to its standard terms and conditions of sale, copies of which may be obtained on
request. Whilst Fosroc endeavours to ensure that any advice, recommendation specification
or information it may give is accurate and correct, it cannot, because it has no direct or
continuous control over where or how its products are applied, accept any liability either
Fosroc Chemicals directly or indirectly arising from the use of its products whether or not in accordance with
any advice, specification, recommendation or information given by it.
(India) Pvt. Ltd.
Head Office telephone fax e-mail
“Sapthagiri Palace”, No.38,
II & III Floor, 12th Cross, ++91 80-42521900 ++91 80-23551510 enquiryindia@fosroc.com
CBI Road, Ganganagar North,
Bangalore 560 024
Regional Offices
www.fosroc.com
page 2 of 2 INDIA/2014/0529/A