40 : TROUBLE SHOOTING :
Cele) Dio}
[Won't start
US
1 : Fuse blown or circuit breaker tripped
2 : Loose electrical connection
‘3 : Motor overheated
fete) ea
1 Check for cause of blown fuse or
breaker and replace or reset
'2 : Check wiring connection
'3 : Press reset button
Low pressure
: Malfunction in valves
Loose tube or fittings
+ Restricted air fiter
+ V-belts loose
Defective check valve
2 Worn compression rings
Sa SoS
oa SSNS
+ Check inlet and exhaust valves
: Tighten fittings
+ Clean or replace
+ Adjust belts tension
Replace check valve
: Replace rings
|Pressure relief valve
|releasing continuously
Defect pressure switch or
improper adjustment
2 : Defective pressure relief valve
11 | Check for proper adjustment
if problem persists replace
pressure switch
\2 : Replace valve
loll discharge and
lexcessive carbon
mation or appearance
lof water and oil in the
Improper oll viscosity
+ Overfiling the crankcase with oll
: Restricted air intake filter
Carbon on exhaust valves
ar
: Worn valves
: Wom piston rings
High ambient temperature and/or
humidity
‘Over usage of this compressor
}1 : Use SAE 30 non-detergent
compressor oil
+ Drain oil and fill to proper level
+ Clean or replace filter
: Replace
Replace
Replace piston ring
Install a moisture separator and/or}
dryer follow by filter
Check for air leakage
If no leaks are found you may
required an additional
‘compressor unit as air demand
is too much for the existing unit
w
[Belt roll off the flywheel
lor motor pulley
1: Flywheel and motor pulley not aligned
properly
12: Bolts do not match flywheel / pulley
groove
+ Aniick or tear on the edge of the belt
Not a matched set(f two or more belts
are used)
: Align using a straight edge
l2: Purchase new set of matched
belts
i3: Purchase new set of matched
belts
4: Purchase new set of matched
belts
fater in air receiver tank
|1 : Condensation in the air receiver
11: Drain daily or install an automatic
drain
10