Professional Documents
Culture Documents
IR value
PI
Tan d and C
all
ON & ON
OFF & ON
ON & OFF
15.00%
2.00%
25.00%
Competent Person
Selected Person
Location manager
Competent Person
Authorised Person
Selected Person
Nominated Supervisor
TRUE
FALSE
25 mm2
45 mm2
65 mm2
55mm2
Competent Person
Control Person
Nominated Supervisor
Authorized Person
Who can carry out the duties for switching- isolation and
earthing to achieve safety from the system and to receive &
clear Sanction for test on apparatus up to 11 KV
Competent Person
Nominated Supervisor
Authorized Person
Competent Person
Nominated Supervisor
Shift Incharge
Erection of Equipment
Installation of Equipment
Commissioning of Equipment
De-Commissioning of Equipment
On - Site Supervision
Personal Supervision
Careful Supervision
FALSE
Both
None
HOP
RED
NTPC Board
CMD
Your driving your route and you come across a victim lying in
the middle of the road that appears to be unconscious, you
should�.
pull the bus safely to the side of the road place your reflectors around the injured
person and call 911.
Position your bus to protect the victim, turn on your flashing red lights, call 911.
Pull the bus safely to the side of the road, drag the victim out of the roadway, call
911.
Both a and b
Hypothermia�.
To control bleeding
Ease pain.
Apply a tourniquet.
He is having a seizure.
He has internal bleeding.
Hazardous chemicals
Slippery floors
Pull-on boots
All of the following statements are true, EXCEPT:
Both A and C
Impact-resistant lenses
Strong frames
Atmospheric hazards
Chemical hazards
Compression hazards
Impact hazards
Both A and B
Motors
Busbars
Generators
Ball valves
Which of the following statements is NOT true about hydraulic
energy?
Line valve
Disconnect switch
On/off switch
Circuit breaker
TRUE
FALSE
I am tied up today but I might have time to help you out tomorrow
A CEO
A salesperson
A factory worker
Everyone
A tool needs costly repairs and should be kept out to supervisor�s sight
The equipment is damaged, should not be, and you should follow facility�s
procedures for arranging for repairs
Removing barricades
Hand tools such as pliers, tongs, magnets and cup lifters can
be used instead of machine guards and devices.
TRUE
FALSE
A safe work practice before beginning hotwork on a metal wall,
would be:
Safety manager
Entry supervisor
Employer
Attendant
The attendant
Limiting the watch to only the front part of the work zone
Section 20
Section 21
Section 22
Section 23
Red
Orange
Green
Purple
Three E's
Four E's
Five E's
Six E's
By always having the same person work with the toxic substance.
123
1234
34
23
Two workers must climb the ladder at the same time. Which
ladder is appropriate?
A job-made ladder
A trestle ladder
A single ladder
A stepladder
Trucks
Special signs such as "deer crossing"
Objects can easily fall from a scaffolding platform how can you
best protect the people below?
Tell the people below to stop work and clear the area
ACB
OCB
MCCB
True
FALSE
True
FALSE
HOD(OPN)
Head of OandM
HOP
HOD(maintenance)
To ensure smooth and jerk free operation over the full range of travel
All of above
During startup
During shutdown
All of above
HOD(OPN)
Head of OandM
HOD(OPN)
Head of OandM
A close watch should be kept on the fue gas and air outlet
temperatures of air heaters. Any unusual increase in one or
more of these should be investigated immediately
True
FALSE
A space that contains a material that can smother someone who enters
A space that contains a material which can engulf someone who enters
Reportable injury
Dangerous Occurrences
TRUE
FALSE
12
24
48
all
Capacity test
Surge test
all
ED(OS)
HOP
Director (O)
RED
True
FALSE
True
FALS
True
FALSE
Air heater soot blowing shall also be carried out while shutting
down the boiler after oil firing.
True
FALSE
SCE
GM(Opn)
GM(OandM)
HOP
Before turbine ovespeed test, ATT for RTS-1 and RTS-2 should
be carried out
True
FALSE
Operation
CandI
Concerned maintenance
All of abov
True
FALSE
True
FALSE
Detection
Classification
Prevention
Theory
At the same time how many people can use one ladder?
One
Two
MCB
ACB
OCB
MCCB
The basic fire theory says that a fire needs four main elements
in order to start: heat fuel oxygen and
Hydrogen sulfide
Carbon dioxide
A chain reaction
Benzene
Correct a skid
Locked in place
Retracted
Flexible
Stop immediately
Speed up slightly
20th August'18
10th November '18
20th November'18
15th November'18
ultraviolet/infrared light
perspiration
sparks
both a and c
Any time
Hazards
Accident
Risk
Hoists
Conveyors
Machine tables
Fail safe
Safety interlocks
Limit switches
How should you wear your safety helmet if you need to lean
over an exposed edge while working at height?
You should tilt your helmet to the side which will help to prevent it from falling
over
You should ensure you make use of the chinstrap and wear the helmet as normal
You should tilt your helmet backwards which should prevent it from falling over
You should not wear your helmet while carrying out these tasks
2 ppm& 5 ppm
3 ppm& 6 ppm
1 ppm& 3 ppm
4 ppm& 6 ppm
When connecting the hose to the regular, the red hose must be
connected to the
Oxygen regulator
Acetylene regulator
Oil
Clean Water
Soapy water
Grease
Stops the machine cycle when the stock is not properly in place
Creates a sensing field that deactivates the machine when a hand tool enters a
hazardous area
Rough
Tired
Sloppy
OSHA
NIOSH
CDC
EPA
Engineering control
Administrative control
Elite control
Substitutional control
The second level of formal communication lists the contributing factors and the
lessons learned from the incident
What happened
Follow-up
Closure of a recommendation
Documenting findings
If you have used a tool time without noticing hearing loss, no protection is
needed
The length of time a tool is used can require hearing protection regarding of
noise level
Noise levels can never be accurately measured so hearing protection can never
adequately protect your hearing
Heart disease
Weight loss
Liver disease
TRUE
FALSE
TRUE
FALSE
Mechanical work
Electrical resistance
Gas compression
Radiation
Employer
Employee
Co-worker
Both A and B
Safety glasses
Goggles
Face shields
Both A and C
Hazardous chemicals
Foot impact hazards
Slippery floors
Metal insoles
Jaw thrust.
Check for danger and ensure that contact with the electrical source is broken.
What is a faint?
A response to fear.
An unexpected collapse.
A brief loss of consciousness.
A sign of flu.
Heat Stroke
Heat Exhaustion
Heat Cramps
Heat Rash
The circulatory system fails to deliver blood to all parts of the body.
What is the first thing you should do for someone you suspect
has an electrical burn?
Never
Both a & b
Yes
No
Who will confirm all persons working under the Sanction for
test have been withdrawn from the plant/high voltage
apparatus and warned not to continue the testing.
Competent Person
Nominated Supervisor
Authorized Person
Which Section of the PTW is to be signed by the Competent
person while receiving a PTW from Senior Authorised person
Section 2
Section 3
Section 4
Section 5
Section 3
Section 4
Section 5
Section 6
GM O&M
GM TS
CGM
AGM Operation
Competent Person
Authorized Person.
Control Person
Nominated Superviso
Nominated person
Supervisor
Crane operator
Stand by man
Person Incharge
Authorized Person
Location manager
Both 1 & 2
he������inchargeof the works should ensure that danger
cannot arise due to release of stored energy by locking or
checking the belt so that it cannot move during work.
Person Incharge
Authorized Person
Competent Person
Location manager
ROMP
LMI
Permit to work
Anthrax
Black lungs
Asbestosis
50 & 50
60 & 40
40 & 60
55 & 45
Oxygen content
TRUE
FALSE
Occurrence of any fatal accidents and involving loss / damage
of Rs. 25 lakhs or more, and / dangerous occurrences, shall be
intimated to Director (HR) and Executive Director concerned
immediately by the quickest possible means of communication
by Head of Project / Station
TRUE
FALSE
12
24
48
immediate
24hrs
48hrs
Keep the air and flue gas dampers of the stalled air heaters
closed
True
FALSE
True
FALSE
True
FALSE
True
FALSE
TRUE
FALSE
True
FALSE
True
FALSE
24 hours to 48 hours
Test by touch
Test before touch
The areas in front of, behind, and on either side of a truck where you disappear
from the sight of the truck driver
Non-reportable injury
Reportable injury
Dangerous Occurrences
All ______________ are also to be reported to Safety Head by
Head of the Department immediately but not later than 24
hours of the event
Non-reportable injury
Reportable injury
Dangerous Occurrences
immediate
24hrs
48hrs
TRUE
FALSE
ensure DC JOP ON
Electrical burns
Scalds
Shutdown is complicated
It saves time
Keep your foot off the accelerator and off the brake
Turn the wheel in the direction you want the rear of the vehicle to go
Spills
Exposed electrical
More than
Less than
Equal to
Three E's
Four E's
Five E's
Six E's
What should you do if you need to use a safety lanyard but the
stitching is damaged?
Continue using the lanyard only if the damaged stitching is less than four inches
Ask for a replacement and do not start working until you have a suitable
replacement
Continue to use the lanyard and get another one at the end of your shift