Professional Documents
Culture Documents
1W Power Amplifier
Circuit Description :
T his is a 1 watt mono amplifier module Kit
using the TDA 7052 from Philips. It is
designed to be used as a building block in There are only 5 external components. C1 is the
other projects where a battery powered audio input coupling capacitor, which blocks any DC
amplifier is required to drive a small speaker. It that might be present on the input. C2 and C3
will operate best from 6 – 12 V DC and requires provide power supply decoupling, and R2
no heatsink for normal use. Two may be used provides adjustable input level. This can be used
for stereo applications. as a volume control.
• The kit has a low component count The Phillips data sheet contains all the
• No external heatsink is necessary necessary information about the TDA7052. You
• It is short circuit protected may download it from the software download
page on our website at :
• Ideal for 3V - 12V battery operation into
an 8 ohm speaker
• Use with Kit 98 if more gain is required
http://kitsrus.com
Assembly Instructions :
Specifications :
Assembly is very straight forward. Make sure
D.C. input : 3 – 15 V at < 300 mA.
you get the integrated circuit and the electrolytic
Idle current < 8 mA, 4 mA typical.
capacitors the correct way around. The
Power output > 1 Watt @ 8 ohms maximum.
electrolytic capacitors are polarized, they have a
> 0.25 Watt RMS continuous
+ or - marked on them and they must be inserted
Freq. Resp. > 20 Hz – 20 kHz
correctly into the PCB. The IC and socket have
~ 10 – 50 kHz, – 3dB
a notch at one end, which is marked on the PC
THD < 1 % @ 100 mW, 0.2% Typ.
board overlay. Solder the socket in place first
S/N ratio > 70 dBA
before installing the IC itself. Leave the
Gain ~ 30 dB maximum.
potentiometer until last. If you require fixed
Input Z ~ 10 k ohm.
gain, you may leave off the spindle.
Page 1 of 2
Kit 27. 1W Power Amplifier
+ C3 + C2
DC input 100 uF
_
3 - 15 V 100 nF
C1 Output
2u2 F R1
+ 1 kΩ 1 8
High
R2 7 N/C
Signal 10 kΩ 2
Input Log.
TDA 7052
Gnd 3 6 Speaker
N/C 4 5
Output
Page 2 of 2