Professional Documents
Culture Documents
2007
1. A rotameter, through which air at room temperature and atmospheric pressure is flowing,
gives a certain reading for a flow rate of 100 cc/s. If helium (Molecular weight 4) is used
and the rotameter shows the same reading, the flow rate is
A. 26 cc/s B. 42 cc/s C. 269 cc/s D. 325 cc/s
4. Dilute sulphuric acid is handled in vessels made of: (GATE –1989– 9.i.a)
A. stainless steel. B. brass. C. lead. D. cast iron.
5. Which of these terms apply to identifying quality standards and how to satisfy them?
A. quality projection B. quality management C. quality planning D. quality overview.
6. Which of the following definitions apply to the cost of qualify?
a. left over product B. total cost of all project efforts
C. customer satisfaction D. redoing entire project.
7. If the replacement of a piece of equipment is being considered, then the cost of extending its
services for another one year is affected by all of the under listed factors except
B. initial investment.
x →∞
A. 0. B. ½ C. 1 D. ∞
The Nigerian Society of Engineers Professional Examinations May, 2007
9. The annual gross revenue from the sales of a particular product is N 700, 000.00. The
variable manufacturing costs are 60% of the annual gross revenue and the fixed cost per
year is N160, 000.00. The annual profit is
A. N 420, 000.00. B. N 120,000.00 C. N 280,000.00 D. N 500,000.00
13. Which of the following are important for the proper interface of a DTMF generator to
a telephone line?
15. Six messages with the probabilities 1/4, 1/4, 1/8, 1/8 and l/8 of occurrence, can be
accommodated by a single communication channel; the entropy, in Bits per message,
of the system is
A. 0.25 B. 0.52 C. 2.50 D. 5.20
The Nigerian Society of Engineers Professional Examinations May, 2007
17. When an electron enters a uniform electric field at an acute angle, its trajectory is
A. rectilinear. B. elliptical. C. parabolic. D. circular.
19. Five key words in the stages of statistical investigation of numerical data are
A. interpretation, presentation, analysis, organisation and collection.
B. collection, presentation, analysis, organisation and interpretation.
C. collection, organisation, presentation, analysis and interpretation.
D. presentation, analysis, collection, organisation and interpretation.
C. most businesses are not capable of attracting financial institutions to support project
1. C
2. C
3. A
4. C
5. C
6. B
7. B
8. D
9. B
10. A
11. B
12. A
13. C
14. B
15. A
16. C
17. A
18. B
19. C
20. A
The Nigerian Society of Engineers Professional Examinations APRIL,
2006.
1. One of the models used for the depreciation of engineering assets is the
A. accelerated cost recovery system.
B. sum of year – straight line depreciation model.
C. accelerated declining balance depreciation model.
D. sum of year digits double declining balance depreciation model.
3. Standard generating sets cannot be used to power computers and other digital
electronics equipment because
A. unburnt fuel washes past the piston rings and mixes with sump oil.
B. of the relatively long delay between main failures and starts up.
D. they fail to reach efficient running temperatures which causes excessive piston
wear.
A. 1 B. 1 / s C. 1 / s2 D. F(s)
8. What does the Nigerian government intend to achieve through the on going sale of
public corporations?
A. Allow open market forces to drive the production of goods and services.
B. Enable Political party members participate in running government firms.
C. Allow foreign friends of the government officials participate in managing government
firms.
D. Allow foreigners manage these businesses sine Nigerian managers have failed.
9. The operation that takes place at sender’s ends of a communication channel is called
A. modulation and demodulation.
B. demodulation and Modulation.
C. signal processing to enable faithful transmission and reception.
D. protocol conversion to enable transmission
10. Which one of the following describes a communication Protocol?
14. An airline company bought an aircraft equipment for N50, 000.00. The salvage value
after 8 years useful life is N2, 000.00. Using the sum of the year's digits depreciation
scheme, compute the book value after 2 years.
A. N25, 000.00
B. N35, 000.00
C. N30, 000.00
D. N32, 000.00
A. Z + P/W + V2/g = C
B. Z + P/W+V2/2g = C
C. Z – P/W + V2/2g = C
D. Z – P/W + V2/g = C
16. The amount of time by which the activity completion can be delayed without interfering
with the start of succeeding activity is known as
A. earliest completion time.
B. total float.
C. free float.
D. none of the above.
After a number of meetings with the Federal housing Authority, the developer and
the resident's association, you learnt that your firm has been engaged by the
developer to design a major component of the building. Your boss has asked you to
manage this project. What are the ethical implications for you? What should you do?
The Nigerian Society of Engineers Professional Examinations April 2006
1. A
2. A
3. C
4. B
5. A
6. C
7. C
8. A
9. A
10. A
11. C
12. B
13. B
14. B
15. B
16. C
17. A
18. C
19. C
20. D