Professional Documents
Culture Documents
Greenguard certification is a certificate that shows the effects of our products on indoor air quality
Using less material for
the same coverage
Projection Gypsum Plaster
APPLICATION
Before application, clean
off all dust and dirt as it
may cause poor bonding.
Fix battens at
approximately 150 – 200
cm intervals.
Use a plastering machine
to mix and spray ALÇITEK
GOLD in the bays between
battens.
After spraying, use a
gauge or a smoothing
board to smoothen the
surfaces. Repeat after
15-20 minutes.
Spray water onto the
surface 50 – 70 minutes
after the commencement
of work and float-finish Dry and warm surfaces Technical Specifications of ALÇITEK GOLD
the surface using a must be wetted prior to
Water / Gypsum ratio 6 litres of water added to 10 kg ALÇITEK GOLD
TİRFİLTEK rubber trowel. application.
Time taken to start setting >50 minutes (According to TS EN 13279-1)
Approximately 10 minutes All tools, including the Setting time 180 minutes
later, polish the surface plastering machine, must Coverage 7.5 – 8 kg /m2 per 1 cm thickness
using a steel trowel. be clean.
Pressure strength (minimum) ≥20 kg/cm2 (4x4 block)
Approximately 60 minutes Fracture strength in Bending Test (minimum) ≥10 kg/cm2 (4x4x16 block)
after the first float STORAGE CONDITIONS -2000 micron sieve %100
finishing, float finish a ALÇITEK GOLD bags can -150 micron sieve (minimum) %60
second time to obtain a be stacked to maximum 20 Loose density (powder) 650 - 700 kg / m3
shiny, hard and glazed layers high. Dry density 880 - 980 kg / m3
surface.
Thermal conductivity 0.43 W/Mk (According to TS 825)
Use ALÇITEK within 1 year
RECOMMENDATIONS of the date of manufacture
Fire Response classification A1