Professional Documents
Culture Documents
DESCRIPTION
FCC.
FEATURES
BLOCK DIAGRAM
(Continued)
PIN CONFIGURATION
PIN DESCRIPTION
(Continued)
FUNCTION DESCRIPTION
Application note:
1. AM low-cut circuit
When pin3 is open, no AF signal can pass through the AMP stage because of the common mode.
When the value of C3 that connected to pin3 is over 1uF, all AF signal can pass through the AMP stage.
The cut-off frequency fL is determined by the internal resistance 22kΩ (Typ.) and the external capacitor C3 as
below:
1
fL = (Hz)
3
2x x 22 x 10 x C3
It is possible to reduce the recovered output level at AM mode, by additional resistance between the pin (3)
and GND line.
2. FM detection circuit
The detection coil can take replace the ceramic discriminator in the FM detection circuit. Recommended circuit
and recommended coil are as follows. In this case, please take care that Vin (lim) falls a little.
COIL DATA
SW1
VC101-E
AM
FM
VC101-F
AM
FM
ST
VC101-B
VC101-A
PACKAGE OUTLINE
SDIP-24-300-1.778 UNIT: mm
SSOP-24-300-0.65 UNIT: mm
SOP-24-375-1.27 UNIT: mm
0.25±0.05
1.27 3.10MAX
0.40
15.34±0.25
13.97
SSOP-24-300-1.0 UNIT: mm
0.525±0.2
6.0±0.2
7.9±0.3
7.62
0.1+0.1 1.8±0.2
2.2MAX
-0.05