Professional Documents
Culture Documents
PULAU PINANG
MAINTENANCE PRACTICE
(DEB4315)
REPORT
EQUIPMENT MAINTENANCE & CALIBRATION
ID : E12218125
Analog Digital
Brand Pro'sKit
Model MT-2017
Product Multimeter
EAN []
Language English, Chinese
Productgroup Multimeters
Filetype PDF
Technical details
Weight 390
Power
Batteries included ✗
Display
Display Analog
The Calibration Method Of Pro’skit Mt-2017
1. Set the multimeter to its ohmmeter function. It is located at lower right portion
of selector knob.We can see that there are multipliers. Multipliers are used to
increase or change the scaling of ohmmeter for better resolution.
3. To start calibrating, short the test probes of the multimeter. The pointer must
point to zero scale because there is nothing to measure.
4. If it is not pointing to zero, we must calibrate it to set to zero. Locate the zero
ohm adjuster and rotate the knob until it point to zero.
5.
6. Now, pointer is pointing at zero scale. It means that it is ready to use. When
you are using another multiplier like x10 or x100, repeat the procedure to
calibrate again.
Possible Failure and Solution
1. Power check
- After checking all batteries there is a battery in the low state of 0.4V less than the
proper state of 1.5V.
2. Sensory Check
- Check fuse, wire connectivity and all components in good condition. No odor burns,
and no wire connection is broken.
3.Component Replacement
- 1 battery replacement is performed.
4. Test Multimeter.
- Multimeter testing is done by taking Volt, Ohm and amp readings. And find the
Multimeter in good working condition.
MONTH ROUTINE
JAN Check Battery , Connection Cable and Power Check
Digital Analog
Specification of Analog Oscilloscope SS-7802A
2% accuracy
3. Set the VOLTS/DIV control to 1. This sets the scope to display one volt per vertical
division. Depending on the signal you’re displaying, you may need to increase or
decrease this setting, but one volt is a good starting point.
4. Set the TIME/DIV control to 1 ms. This control determines the time interval
represented by each horizontal division on the display. Try turning this dial to its
slowest setting. Then, turn the dial one notch at a time and watch the dot speed up
until it becomes a solid line.
5. Set the Trigger switch to Auto. The Auto position enables the oscilloscope to
stabilize the trace on a common trigger point in the waveform. If the trigger mode
isn’t set to Auto, the waveform may drift across the screen, making it difficult to
watch.
6. Connect a probe to the input connector. If your scope has more than one input
connector, connect the probe to the one labeled A.
Oscilloscope probes include a probe point, which you connect to the input signal and
a separate ground lead. The ground lead usually has an alligator clip. When testing a
circuit, this clip can be connected to any common ground point within the circuit. In
some probes, the ground lead is detachable, so you can remove it when it isn’t needed.
Possible Failure and Solution
1. Probe problem
- try buy or using another probe and testing using oscilloscope.
MONTH ROUTINE
JAN Connection Cable and Power Check