Soal Plan and schedule How does the maximum oil film Specific weight of water in S.I.
operation pressure in a white metal journal units is equal to
bearing operating A. 9.81 xlO3 N/m3 A perfect gas under full fluid film conditions A. Has constant viscosity compare with the pressure of the Surface tension has the units of lubricating oil A. Newtons/m A vessel is scheduled to enter a supply system? SECA during a forthcoming The pressure is less than the The value of mass density in voyage? What pressure in the lubricating system kgsecvm4 for water at 0°C is additional considerations must a and varies with the journal load.. A. 101.9 Chief Engineer take into account when planning If no resistance is encountered by The cold room temperature is for this voyage? displacement, such a substance is almost at the cut out point in a A. The availability of low sulphur known as vapour-compression fuel IdealFluid refrigeration system. What should and the change over time required the refrigerant state be just after to ensure the system is clear of Increase in pressure at the outer the evaporator if normal fuel prior to entry into the edge of a drum of radius R due to the system is correctly set up? SECA. rotation at A. Slightly superheated low corad/sec, full of liquid of density p pressure gas. A fluid in equilibrium can't sustain will be A. Tensile stress A. Pco2/?2/2 The pressure at a point in a fluid will not be same in all the A balloon lifting in air follows the If mercury in a barometer is directions when the following principle replaced by water, the height of fluid is Newton law of viscosity 3.75 cm of mercury A. Viscous and moving will be following cm of water A vessel which normally operates A. 51 cm The bulk modulus of elasticity with with the engine room in UMS increase in pressure mode is unable to In a static fluid A. Increases do so because of defects to some A. Only normal stress can exist of the critical alarm functions. The tendency of a liquid surface to What are the main Kinematic viscosity is dependent contract is due to the following considerations that the Chief upon property Engineer must take into account A. Density A. Surface tension when planning alternative arrangements to cover Mercury does not wet glass. This The value of the coefficient of the engine room requirements is due to property of liquid known compressibility for water at until the defects as ordinary pressure and are cleared? A. Surface tension temperature in kg/cm is equal to A. A work rota is established to A. 21000 ensure full One of the Main Engine cooling coverage of engine room pumps is down for maintenance. Viscosity of water in comparison to watchkeeping The rest of the mercury is duties and adequate rest periods cooling pumps are operating near A. Higher for the full capacity with minimum engineering staff. margins on the Which of the following meters is maximum temperature limit. What not associated with viscosity Choose the wrong statement. should be the correct action to Orsat Alcohol is used in manometer, take with regard because to UMS operation? What would the results of a TAN A. Its vapour pressure is low A. Operate the engine room on test, carried out on lubricating oil manual mode until the samples from a Choose the correct relationship maintenance is completed and the diesel engine, indicate? A. Specific gravity = gravity x cooling pump is A. A measure of acid density operational and switched to stand- concentration by mode. For manometer, a better liquid Which of the following terms is combination is one having Property of a fluid by which its own used to describe a thermodynamic A. Higher surface tension molecules are attracted is called process in which A. Cohesion no heat transfer into or out of the system occurs? A. Adiabatic.