Professional Documents
Culture Documents
May 2019
MARINE POWER
DISPLAY
36 Page,
S2F1-UP S2T1-UP
TTA1-UP S2W1-UP
TTB1-UP S2X1-UP
MKH1-UP S2Y1-UP
S2J1-UP TTD1-UP
S2K1-UP TTH1-UP
S2L1-UP TTJ1-UP
S2M1-UP E3Z1-UP
ECM TTC1-UP
TTE1-UP
MRG1-UP
RNE1-UP
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.
Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
T
the gauge of the temperature or pressure.
READY ECM 2
START E-STOP
STOP FAULT Plug Receptacle
Pin or Socket Number
5A
PUSH BUTTON PUSH BUTTON 1 Deutsch connector: Typical representation
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123
Component
Part Number
2 sockets and the receptacle contains all pins.
325-AG135 PK-14
1 Sure-Seal connector: Typical representation Harness identification code:
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2
PANEL INSIDE VIEW
contain both pins and sockets. wire 135 in harness "AG". Wire Color
©2019 Caterpillar CAT, CATERPILLAR, their respective logos, “Caterpillar Yellow”, and the POWER EDGE trade dress as well as
All Rights Reserved corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.
14 13 12 11 10 9 8 7 6 5 4 3 2 1
J J
(Dimensions: 48 inches x 35 inches)
UENR7494-01
I I
36 Page,
H H
G G
F F
E E
D D
C C
B B
A THIS SCHEMATIC IS FOR THE 3508B, 3508C, 3512B, 3512C, 3512C MAR PROP, 3516B, A
3516C, 3516C MAR PROP, 3518B, C32 AUX GS and C32 MAR GS MPD PILOT HOUSE
ELECTRICAL SYSTEM
MEDIA NUMBER: UENR7494-01
SCHEMATIC PART NUMBER: 249-6960 (MPD PILOT HOUSE), CHANGE: 03, VERSION: -
SCHEMATIC PART NUMBER: 250-0386 (INTERCONNECT), CHANGE: 03, VERSION: -
Components are shown installed on a fully operable engine in a non powered state.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
14 13 12 11 10 9 8 7 6 5 4 3 2 1