Professional Documents
Culture Documents
ED Assignment I 18
ED Assignment I 18
18
ENGINEERING DRAWING
I – B. Tech, CSE – II (2017-18)
ASSIGNMENT – I
1. A) Construct a scale of 1:4 to show decimeters and centimeters and long enough to measure up to 5 decimeters.
And mark on it a length of 3.7 dm.
b) Construct a scale of 1:40 to read meters, decimeters and centimeters and long enough to measure up to 6 m.
Mark a distance of 4.76 m on it.
2. A) A line AB, 50 mm long has its end A in both the H.P and the V.P. It is inclined at 30° to the H.P. and 45° to
the V.P. Draw its Projections.
B) A Point A is on the H.P and 40 mm infront of V.P another point B is on V.P and below H.P. The line joining
their front views makes an angle of 450 with xy. Find the horizontal distance between two point?
1. A) Two points A and B are in H.P. The point A is 30 mm in front of the V.P. while B is behind the V.P. The
distance between their projectors is 75 mm and the line joining their top views making an angle of 45° with xy.
Find the distance of the point B from the V.P.
b) A 70 mm long line PQ has its end P 20 mm above the H.P and 40 mm infornt of V.P. The other End Q is 60
mm above the H.P and 10 mm infront of the V.P. Draw its projections of PQ and determine its inclinations with
the reference planes
2. The top view of a 75mm long line AB measures 65mm, while the length of its front view is 50mm. Its one end
A is in the H.P. and 12mm in front of the V.P. Draw the projectors of AB and determines its inclinations with
the H.P. and the V.P. Also locate the traces.
8. a) The major axis of an ellipse is 160 mm long and the minor axis 90 mm long. Find the foci and draw the
ellipse by `Arcs of circles method'. Draw a tangent to the ellipse at a point on it 25 mm above the major axis.
b) Construct a hexagon of 50 mm side using general method