You are on page 1of 6

Designed by: Won Park

Diagrammed by: Márcio Noguchi

1 2 3

Fold and unfold. Fold and unfold top 1/4. Fold and unfold top 1/8 and the 5/8
line.

4 5 6

Fold and unfold, aligning the first 1/8 The reference point is the intersection Fold and unfold, on top of the
horizontal crease line on top of the of the diagonal crease made on the reference point, parallel to the vertical
vertical center one, on both sides. See previous step, and the horizontal center crease line, on both sides.
the reference point. crease at 5/8 from the top. Fold and
unfold parallel to the vertical center
crease line, on both sides.

7 8 9

Mountain fold along the existing


diagonal crease.
Mountain fold along the existing Turn over.
diagonal crease symmetrically to the
previous step. Valley fold flap to the
side.

10 11 12 (in progress)

Use existing creases to flip one layer Fold on existing creases squashing Partially open the model, to allow the
to the left and squash the top. the left side. paper to flip to the back. Reverse the
valley crease to mountain.

Dollar Bat by Won Park Page 1 of 6


13 14 15

11-13

Fold on existing creases, squashing Repeat steps 11 to 13 on the right. Turn over.
the bottom.

16 17 18

Fold the edges along the center line Using the creases made on the previous
Valley fold top layer only. You may (horizontal and vertical) creating an angle two steps, collapse into something that
have to move the flaps bellow out of bisector. Crease only from the corner to resembles an upside-down bird-base.
the way. Unfold. the intersection with the diagonal crease
created on the previous step.

(Back view)
19 20 21

Fold the top flap down. Pull out one layer of paper (indicated with Turn over.
the dot). The model will not lie flat.

22 (in progress) 23 24

Pull out one layer of paper (indicated Turn over. Inside reverse fold.
with the dot). Reverse one of the
creases from valley to mountain. At
that point, the model will lie flat again.

25 26 27

Inside reverse fold. Insert the flap Turn over. Fold the entire top flap down. You will
under the folded edge. have to open the model partially to
allow the raw edge to switch sides and
stay on the outside of the model.

Dollar Bat by Won Park Page 2 of 6


28 29 30

Hinge the raw edge. Valley fold top layer only, aligning the Mountain fold top layer only, from where
first crease line parallel to the raw the crease created on the previous step
edge on top of the vertical center meets the horizontal top folded edge, to
folded edge. Unfold. the raw edge at a point where it makes a
right angle. (See next picture) Unfold.

(in progress)
31 32

Note about previous step:


Pre-creasing for future step: Mountain Pre-creasing for future step: Valley fold
The raw edges align on top of each other,
fold top layer only between the right all layers aligning the horizontal on top
with the mountain fold meeting at the
corner of what looks like the bird-base, of the crease created on the previous
intersection of the diagonal created on the
to the point where the fold line end on step, bisecting the angle. Unfold.
previous step and the horizontal folded edge.
the raw edge. Unfold.

33 34 35

Note:
This reference point
Note: Don’t worry to is an approximation.
Note: New crease. flatten this part. You may skip this
crease. See Note on
Pre-creasing for future step: Swivel Flatten the model just enough to create step 36.
using the valley crease created on the the new mountain crease. Don’t worry Mountain fold from the same reference
previous step and the crease of step 29, to flatten the bottom part. Unfold. point indicated on step 32 (intersection of
creating a new mountain crease to Turn over. diagonal crease with folded edge) to the
flatten the model. See next picture. intersection of the diagonal close to the
raw edge. Turn over.

36 37 29-36 38

Squash using the creases created in the Repeat steps 29 to 36 on the left side. Use Mountain crease created on step 31,
steps 29, 30 and 35. Note: if you Next steps are showed in magnified to open partially what it will become the
skipped step 35, make the crease it view. wings of the model. The model will not lie
now, to make the model flat. See next flat.
picture.

39 40 41 38-40

Create mountain crease on the top layer Valley fold along the vertical center line, Repeat steps 38 to 40 on the left side.
following the folded edge right bellow it. squashing the bottom.

Dollar Bat by Won Park Page 3 of 6


42 43 44

Hinge what is going to become the head Bisect angle created between the crease Open the wings, and fold using crease
all the way to the top along the horizontal of previous step and step ??. Crease until created on step 32 (the one from the back
line of the bird-base, and as you flatten, it intersects the diagonal line created on side).
extend the crease to the left and right step 33, used on the previous step. Undo.
until it intersects to the diagonal line
created on step 33. Undo.

45 46 47

Collapse the head, neck and wings, using Move the top layer indicated in the picture Open sink.
existing creases. At this point, the model one level bellow, without creating any
should lie flat. new folds.

48 49 50

Move back the layer to the original Tuck inside the pocket bellow it without Fold the top layer along the raw edge
position of picture 46. No new creases. any new folds. bellow, and tuck it inside.

51 52 53

Mountain fold the base of the wing, Fold the raw edge along the horizontal Fold the crease created on the previous
horizontally, starting from the base of folded edge, bisecting the angle. Unfold. step along the horizontal folded edge,
what is going to become the neck of the bisecting the angle.
bat.

Dollar Bat by Won Park Page 4 of 6


54 55 56

Valley fold on the horizontal crease line. Valley fold the raw edge, and Mountain fold the raw edge, tucking it
simultaneously squash to flatten the under.
model so that the folded edge aligns with
the horizontal line.

57 58 59

Valley fold the folded edge tucking inside Turn over. Valley fold the bottom layer underneath,
the body. Magnified view of tail. starting from where the vertical center line
ends on the horizontal raw edge to the
left corner, sliding the extra paper to the
right. Model will not lie flat.

60 61 62

Valley fold on the center vertical line. At Fold the corners inside the model. Mountain fold from top corner to the
this point, the raw edges should align with extreme bottom corner of the wings.
the folded edge. Tuck the excess paper Unfold.
around the middle of the body under
flattening the model.

63 64 65

Mountain fold by aligning the folded edge Mountain fold by aligning the folded edge Shape the wings by adding more volume.
on top of the crease created on the on top of the crease created on the Round the wings using the creases
previous step, bisecting the angle. previous step, bisecting the angle. created on steps 62-64.
Unfold. Unfold.

Dollar Bat by Won Park Page 5 of 6


66 67 68

Next steps magnified for the details of the Mountain fold the tip horizontally, to Valley fold from the end of the folded
head. create the nose of the bat. edge (created in the previous step) to
where the top folded edge overlaps the
layer under it.

69 70 71

Valley fold horizontally, to create the face Open the ears by using the tip of a Turn over.
of the bat. pen or pencil, rounding it slightly.

72 73

Rabbit ear slightly, creating the neck and Dollar Bat complete.
a tri-dimensional shape.

Dollar Bat by Won Park Page 6 of 6

You might also like