Professional Documents
Culture Documents
Machine Shop
3rd year
b. Depth micrometer
a) 66.35 mm
b) 65.85 mm
c) 65.35 mm
d) 66.85 mm
4. Which formula using to find value of angle ϴ shown
a. tan (ϴ) = h / L
b. cos (ϴ) =h / L
c. Sec (ϴ) = h / L
d. Sin (ϴ) = h / L
a. Inside micrometer
b. Depth micrometer
c. Outside micrometer
a. Inside micrometer
b. Depth micrometer
c. Outside micrometer
a. Spirit Levels
b. Dial Indicators
d. Sine bar
8. The instrument used for measuring the gear pitch diameter is
a. Depth micrometer
b. Gear micrometer
c. Outside micrometer
d. Inside micrometer
a. 0.10 mm
b. 0.01 mm
c. 0.001 mm
d. 0.0001 mm
a. 15.80 mm
b. 18.85 mm
c. 18.30 mm
d. 18.80 mm
a. Chemical composition
b. Mechanical properties
c. Surface finish
d. Physical properties
12. The process of heating and cooling a steel to obtain desired properties is called
a. Heat Treatment
b. Cold treatment
c. Hardening
d. Tempering
13. In heat treatment process step (X) is
a. Holding Temperature
b. Cooling
c. Heating
d. Hardening
a. Normalization
b. Annealing
c. Hardening
d. Tempering
a. Normalization
b. Annealing
c. Hardening
d. tempering
16. The furnace that uses a heating coil for the purpose of heating is
a. Electric furnace
b. GAS FURNACES
d. Vacuum Furnace
a. Electric Furnace
c. GAS FURNACES
d. Vacuum Furnace
a. water
b. Sand
c. Dust
d. Powder