Professional Documents
Culture Documents
Auraton 2005 TX Plus PDF
Auraton 2005 TX Plus PDF
2005
2005 TX RX Plus
29 EN
0 I
AURATON AURATON
2005 TX Plus 2005 RX Plus
150cm
To ensure proper operation, the thermostat should
be installed at an inside wall with freely circulating
air. Find a place where your family usually
occupied.
właściwe usytuowanie
PROPERLY sterownika
INSTALLED THERMOSTAT
. AURATON 2005
31 EN AURATON 2005 - Installation
1.2 Wiring AURATON 2005 Fix the thermostat by putting it over the screwhead
Wiring terminals are at the back of the thermostat. and slide it rightward (note the keyhole like opening
Press down the terminal cover, you can find three at the back of the thermostat). Tighten the remain
terminals which labelled COM, NO and NC. It is a screw to lock it in place.
typical single-pole, double throw (SPDT) contact. In Note:
most COM and NO are used. If the wall is made of wood, there is no need to use the
wall anchors. Drill two Ø2.7mm holes instead of
Ø6mm.
NO
NO
COM COM
NC
NC
PROG
Temp. economy or defrost temperature instead of numeric
0 6 12 18 24
Prog.
values.
Prog.#
2.3 Dip switches
+ -
Reset
ON
DELAY 5 MIN.
OK 1 2 3
If you remove the front cover, you can find three 2.5 LCD
small switches (dip switches). These three switches 1
are used to control the span, output-on delay and
3
heat/cool system. Span is the temperature (1OC or 2
0,5OC) difference between the turn on temperature c
0
possible.
PROG
2.6 Start 0 6 12 18 24
6
Wt
12
Śr
18
Cz Pt
PROG
24
So
c
0
NC NO COM
COM connectors.
2 5
NC
NC
NO NO 3
COM
COM
4 6
front back
AURATON 2005 TX RX Plus - Turning on for the first time EN 40
NO
COM
NC
HEATING
DEVICE
AURATON 2005
43 EN AURATON 2005 - How to connect
NO
COM
NC
HEATING
DEVICE AURATON 2005
POWER
SUPPLY
max ~220V
AURATON 2005 - How to connect EN 44
THREE PHASE
CONNECTOR
NO
COM
NC
HEATING
DEVICE AURATON 2005
RST
max ~220V
45 EN AURATON 2005 - How to connect
NO
COM
NC
GAS
WATER
DEVICE
AURATON-2005
max ~220V 5A
~220V
CIRCULATING PUMP
AURATON 2005 TX RX Plus - How to connect EN 46
NC Ni Po Wt Śr Cz Pt So
NO c
0
PROG
COM 0 6 12 18 24
HEATING
DEVICE 1 2
9. Specification 9. Switching
230VAC 50Hz 5A resistive
1. Temperature measurement range
0-34.75OC (0,25OC step) 10. Dimensions
154 x 80 x 30 (mm) (W x H x D)
2. Temperature control range
5-30OC (0,25OC step) 11. Operation temperature
0 - 45OC
3. Temperature accuracy
+/- 1OC 12. Storage temperature
-20 - 60OC
4. Clock accuracy
+/- 70 seconds/month 13. Operating humidity
5 - 90% non-condensing
5. Program
6 preset, 3 user-define
6. Switching span
0,5OC or 1OC
7. Control mode
Heating or Cooling system
8. Minimum air-con. cycle time
5 minutes
DEKLARACJA ZGODNOŚCI WE
EC DECLARATION OF CONFORMITY
NR: 04146
Oznaczenie roku, w którym naniesiono znak CE / Year in which the CE marking was
affixed : 04
Miejscowość, data / Place, date: Poznań, 01.09.2006
NR: 04145
niniejszym deklaruję z pełną odpowiedzialnością, że wyroby / herewith declares under our sole
responsibility that the products:
Oznaczenie roku, w którym naniesiono znak CE / Year in which the CE marking was affixed : 04
Miejscowość, data / Place, date: Poznań, 01.09.2006
Takie oznakowanie informuje, że sprzęt ten, po okresie jego użytkowania nie może być
umieszczany łącznie z innymi odpadami pochodzącymi z gospodarstwa domowego.
Użytkownik jest zobowiązany do oddania go prowadzącym zbieranie zużytego sprzętu
elektrycznego i elektronicznego. Prowadzący zbieranie, w tym lokalne punkty zbiórki, sklepy oraz
gminne jednostki, tworzą odpowiedni system umożliwiający oddanie tego sprzętu.
AURATON 2005
Warunki Gwarancji:
AURATON 2005 TX RX Plus
1. Gwarancji udziela się na okres 36 miesięcy od daty
sprzedaży.
2. Reklamowany regulator wraz z kartą gwarancyjną,
należy dostarczyć do punktu sprzedaży za
pośrednictwem poczty (w przypadku sterownika
bezprzewodowego TX RX należy dostarczyć odbiornik
i nadajnik).
3. Termin wykonania naprawy wynosi 14 dni roboczych od
daty zgłoszenia reklamacji.
4.Gwarancja traci ważność w przypadku uszkodzenia
mechanicznego, niewłaściwej eksploatacji i dokonania
napraw przez osoby nieuprawnione.
5. Wszystkie zmiany i poprawki w treści karty
gwarancyjnej są ważne jedynie wtedy gdy są dokonane
przez uprawnioną osobę, opatrzone podpisem i
stemplem.