Professional Documents
Culture Documents
In order to find a certain product quickly, you may proceed in two ways.
Table of contents
The table of contents on the very first page of the catalog will help you find out which group the
designated product belongs to. Then refer to the index page of the respective group where you will
find illustrations showing the full index content. The indicated page number will guide you to the
desired product.
The colors of the pricelists may also aid your search. They were selected according to the material
groups:
hardened, tempered steel blue
steel white
brass, bronze, Kuprodur (copper) yellow
aluminium, polyamide (nylon) gray
stainless steel red
Index
According to designation or standard you will find the group and page number of the
required product in the
DIN-standards index (pages 011–015)
ISO-standards index (pages 016–018)
SNV-standards index (pages 019–020)
Kyburz special products index (page 021-022)
alphabetical index (pages 023–034)
The products listed in these indexes have, again, been classified by the material respectivel. by
colors to facilitate working with this catalog.
Please note:
Small-lot quantities are usually rounded up to full packages. Only if explicitly agreed upon, or in case
of large, expensive dimensions, we supply a specific number of pieces differing to full package
quantity.
In this case, a small-lot surcharge of $5.00 net per dimension is charged.
However, we recommend to avoid ordering small quantities of surface-treated fasteners not listed in
the catalog, because small-lot surcharges will be invoiced per position and may, depending on the
plating, by far exceed the price per kilogram.
Cost saving
For most of our customers fasteners are C-items, which need to be handled with smallest effort.
Not so for us - fasteners are our principal business.
As an expert in fasteners and as a supplier of services, we offer you proven know-how in
order to support you in optimizing the movement and assembly of fasteners. Important cost saving
factors are found in:
l development of new products (streamlining of fastener range,
multifunctional items)
l purchasing administration (simplifying business transactions)
l gain on information (market research, statistics)
l warehousing (just in time shipments)
l quality assurance (warranty by the supplier)
Requirements
A close cooperation is shaped by many parameters, e.g. possibility of prediction of the use,
required range or quantity of use. Since there are so many influencing factors, we do not
propose “off-the-shelf” solutions. Rather, we invite you to discuss your specific requirements
with our experts.
Basis for each close cooperation must be confidence in the efficiency and willingness of the
supplier. There are many well-known national and international companies which fully trust in
us and it is our most distinguished duty to justify their confidence every day.
Zinc plating of high-strength fasteners (class 10.9 or higher) and fasteners made of
spring steel - refer to page page T79
Reduced tightening and loads of socket screws with low heads - refer to page page T25
Copyright 2000/2003 for the whole catalogue by Maryland Metrics/KYBURZ, ZUG / Switzerland
URL: http://mdmetric.com E-mail: sales@mdmetric.com
002