Professional Documents
Culture Documents
comp)
Answer: the tank during the underground work , it have a certain slope, and after the underground , your
tank not make the tank volume table calibration ,so the tank volume table also not the exactly one ,so the tank volume
table have some error ,in order to make sure the accuracy ,so we need to adjust the console oil Compensation.
Detail as follow:
1
input password 822267 ,then enter probe data :
2
Then you will find the original value as follow picture , the 0.0 is the
original value
Then click the red place 0.0 ,you will find the follow picture,this data
3
For example ,the console show your oil height is 1735.5 mm ,but you check
manual height is 1741.5mm ( from the tank gauge hatch checking it ). So this
probe ,the oil compensation value is : 1741.5 mm-1735.5 mm+ (0.0mm) = 6.0
then click Enter ,then you will heard one sound ,then click Home to
check,
you will check , the display will show you data is : 1741.5 mm
4
If value is - 6.0 ,then you need to input – 6.0 ,then click Enter .
Mark :
1. if the data is 6 ,then you need to input 6.0 , not 6 ,must be 6.0
2. If your data is -6 ,then you need to input -6.0 ,not -6 .must be - 6.0 .
3. Others number is the same !
If you have many tanks ,then do the same way one by one !
After this work ,then console display fuel height = manual height