Professional Documents
Culture Documents
PCG-GRT35F/GRT240G/GRT260G/GRT270G
PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP
SERVICE MANUAL
Ver 3-2003J
Revision History
t i a l
n
Area Model Line up
Japanese Japanese
PCG-GRT55E/B
PCG-GRT5xE*
PCG-GRT5xE/P*
[MA]
fi d e
n
PCG-GRT77E/P 1
PCG-GRT7xE*
o
PCG-GRT7xE/P*
C
Latin PCG-GRT35F 2 [MA]
S400
PCG-GRT230*
PCG-GRT240G 2 [MA]
American US PCG-GRT250*
Canadian PCG-GRT260G 2 [MA]
PCG-GRT270*
PCG-GRT270G 2 [MA]
PCG-GRT815E
PCG-GRT815M Illust : PCG-GRT55E/B
• Design and specifications are subject to
PCG-GRT816M
European AEP
PCG-GRT816S 2 [MA] change without notice.
UK PCG-GRT895MP
PCG-GRT896HP
PCG-GRT896SP 2 [MA]
* : CTO Model
NOTEBOOK COMPUTER
9-876-352-03
Information in this document is subject to Caution Markings for Lithium/Ion Battery - The Service and Inspection Precautions
change without notice. following or similar texts shall be provided on
battery pack of equipment or in both the operating 1. Obey precautionary markings and screws, components, and wiring have been
Sony, VAIO and CLIE are trademarks or
and the service instructions. instructions returned to their original condition. Also check
the area around the repair location to ensure that
registered trademarks of Sony. Microsoft, Labels and stamps on the cabinet, chassis, and
CAUTION: Danger of explosion if battery is repair work has caused no damage, and confirm
Windows, Windows Media, Outlook, Bookshelf components identify areas requiring special
safety.
incorrectly replaced. Replace only with the same precautions. Be sure to observe these precautions,
and other Microsoft products are trademarks or
or equivalent type recommended by the as well as all precautions listed in the operating 5. When replacing chip components...
registered trademarks manual and other associated documents.
manufacturer. Discard used batteries according Never reuse components. Also remember that
of Microsoft Corporation in the United States and
to the manufacturer’s instructions. 2. Use designated parts only the negative side of tantalum capacitors is easily
other countries.
The word Bluetooth and the Bluetooth logo are damaged by heat.
The set’s components possess important safety
trademarks of Bluetooth SIG, Inc. AMD, AMD CAUTION: The battery pack used in this device characteristics, such as noncombustibility and the 6. When handling flexible print
may present a fire or chemical burn hazard if ability to tolerate large voltages. Be sure that
logo, AMD Duron and combinations thereof, boards...
mistreated. Do not disassemble, heat above replacement parts possess the same safety
3DNow!, are trademarks of Advanced Micro characteristics as the originals. Also remember • The temperature of the soldering-iron tip should
Devices, Inc. Intel Inside logo, Pentium and 100°C (212°F) or incinerate.
that the 0 mark, which appears in circuit be about 270C.
Celeron are trademarks or registered trademarks Dispose of used battery promptly. • Do not apply the tip more than three times to
diagrams and parts lists, denotes components that
of Intel Corporation. Transmeta, the Transmeta Keep away from children. have particularly important safety functions; be the same pattern.
extra sure to use only the designated components. • Handle patterns with care; never apply force.
logo, Crusoe Processor, the Crusoe logo and
combinations thereof are trademarks of CAUTION: Changing the back up battery.
• Overcharging, short circuiting, reverse charging,
3. Always follow the original design
Transmeta Corporation in the USA and other when mounting parts and routing Caution: Remember that hard disk drives are
countries. Graffiti, HotSync, PalmModem, and multilation or incineration of the cells must be wires easily damaged by vibration. Always handle
Palm OS are resistered trademarks, and the avoided to prevent one or more of the following with care.
The original layout includes various safety
Hotsync logo and Palm are trademarks of Palm, occurrences; release of toxic materials, release features, such as inclusion of insulating materials
Inc. or its subsidiaries. (M) and Motrola are of hydrogen and/or oxygen gas, rise in surface (tubes and tape) and the mounting of parts above ATTENTION AU COMPOSANT AYANT
temperature. the printer board. In addition, internal wiring has
trademarks of Motrora, Inc. Other Motrola RAPPORT
• If a cell has leaked or vented, it should be been routed and clamped so as to keep it away
products and services with (R) mark like À LA SÉCURITÉ!
replaced immediately while avoiding to touch from hot or high-voltage parts. When mounting
LES COMPOSANTS IDENTIFÉS PAR UNE
Dragomball are the trademarks of Motrola, Inc. parts or routing wires, therefore, be sure to
it without any protection. MARQUE 0 SUR LES DIAGRAMMES
duplicate the original layout.
SCHÉMATIQUES ET LA LISTE DES PIÈCES
All other names of systems, products and services SONT CRITIQUES POUR LA SÉCURITÉ DE
4. Inspect after completing service
in this manual are trademarks or registered FONCTIONNEMENT. NE REMPLACER CES
trademarks of their respective owners. After servicing, inspect to make sure that all COMPOSANTS QUE PAR DES PIÈSES SONY
DONT LES NUMÉROS SONT DONNÉS DANS
In this manual, the (TM) or (R) mark are not
CE MANUEL OU DANS LES SUPPÉMENTS
specified. PUBLIÉS PAR SONY.
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
—2— PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
TABLE OF CONTENTS
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
—3— PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
CHAPTER 1.
SPECIFICATIONS
J AM EU
PCG-GRT55E/B PCG-GRT77E/P PCG-GRT270G PCG-GRT260G PCG-GRT240G PCG-GRT35F PCG-GRT896HP PCG-GRT816M PCG-GRT895MP PCG-GRT815E PCG-GRT815M PCG-GRT896SP PCG-GRT816S
CPU M-Cel 2.20GHz P4 2.66GHz P4 2.80GHz P4 2.80GHz P4 2.66GHz P4 2.80GHz P4 2.80GHz P4 2.80GHz P4 2.80GHz P4 2.80GHz P4 2.80GHz P4 2.80GHz P4 2.80GHz
LCD 15XGA 16.1SXGA+ 16.1UXGA 16.1SXGA+ 15XGA 15XGA 16.0SXGA 16.1SXGA+ 15XGA 15XGA 15XGA 16.1UXGA 16.1SXGA+
(Clear Black) (Clear Black) (Clear Black) (Clear Black) Clear Black (Clear Black) (Clear Black) (High Brightness) (High Brightness) (Clear Black) (Clear Black)
HDD 60GB 80GB 80GB 80GB 60GB 80GB 60GB 60GB 60GB 60GB 80GB 80GB 80GB
Graphic Ge Force4 Ge Force4 GeForce FX GeForce FX Ge Force4 Ge Force4 GeForce FX GeForce FX Ge Force4 GeForce FX GeForce FX GeForce FX GeForce FX
420Go(32MB) 420Go(32MB) Go5600(64MB) Go5600(64MB) 420Go(32MB) 420Go(32MB) Go5600(64MB) Go5600(64MB) 420Go(32MB) Go5600(64MB) Go5600(64MB) Go5600(64MB) Go5600(64MB)
DDR MEMORY 256MB X 1 256MB X 2 512MB X 1 256MB X 2 256MB X 2 256MB X 2 256MB X 2 256MB X 2 256MB X 2 256MB X 2 256MB X 2 512MB X 2 256MB X 2
QUANTITY
[STANDARD/MAX] 256MB / 1024MB 512MB / 1024MB 512MB / 1024MB 512MB / 1024MB 512MB / 1024MB 512MB / 1024MB 512MB / 1024MB 512MB / 1024MB 512MB / 1024MB 512MB / 1024MB 512MB / 1024MB 1024MB / 1024MB 512MB / 1024MB
OPT-DRIVE DVD+-RW DVD+-RW DVD+-RW DVD+-RW DVD+-RW DVD+-RW DVD+-RW CD-RW/ CD-RW/ DVD+-RW DVD+-RW DVD+-RW DVD+-RW
DVD-ROM DVD-ROM
TV tuner a a a a a X X X X X X X X
int. Wireless LAN X X a a a a a X a X X a X
AC adaptor PCGA-AC19V6 PCGA-AC19V6 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7 PCGA-AC19V7
Battery PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX PCGA-BP2NX
OS WinXP Home WinXP Pro WinXP Home WinXP Home WinXP Home WinXP Home WinXP Pro WinXP Home WinXP Pro WinXP Home WinXP Home WinXP Pro WinXP Home
Port replicator
CPU Socket
Docking CN 478uFCPGA
to Main Unit VIF-28/31
CNX-216
RGB RGB VIF-28: for NV31
RGB FSB 100MHz/133MHzx4
Gfx VIF-31: for SQ17
NV31/SQ17 DDR
LCD CLK CLK
CNX-218
SVIDEO 66MHz 1/2/4/8x AGP SiS 648 DDR M1 M2 GENERATOR BUFFER
M M ROMINFO
OUT S-VIDEO Out 333MHz DI DI
SO SO M24C02 ICS952003 ICS93722
AV OUT
AAh A8h AEh D2 or D3h D2h
AMP
LINE&VIDEO OUT
USB2.0 RICOH
Line In N PCI Slot
Multi Purpoase Bay Port0 USB0 LA CardBus&i.LINK
HC0 W-
to Opt Port1 USB3 R5C554
Port2 USB4 SVIDEO
USB2.0 HUB USB1 HC1
USB1
NEC_UPD720110 USB2 SiS963 IN
USB2 AGC-8EA i.LINK Card Bus
LAN(PHY) Ether
MS IFX-257 HC2 RTL8201BL to Port
Replicator ENX-23
USB5
MM Tuner AV IN
AC Link Board
RJ-45 RJ-11
DC IN (Ether} (MODEM) RF IN
MDC Hdr
AC'97 Choose Card Bus or
SPDIF SPD IF t
SigmaTel ar S Tuner which one
LPC 33MHz
STAC9750 Sm C 3
M
PS/2
PS/2 HITACHI BIOS ROM SmSC Debug
MIC HP
KBC 4Mb SIO
Serial H8S/2160B 32P TSOP LPC47N227
Serial
144P TQFP SST49LF040 100P TQFP
Parallel SMBUS1
Parallel
SMBUS0 TP Int Keyboard Parallel
Parallel
98h 92h Serial
RJ-45
MM Ether
LM86 LM75 16h 16h
PS/2
Batt1 Batt2
to Port to Port
FAN CPU FAN Replicator Replicator
to Port
Multi Purpoase Bay
Replicator
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
2-1 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
(END)
CHAPTER 3.
FRAME HARNESS DIAGRAM
Wireless LAN Model
ANTENNA ANTENNA
LCD
LCD Block
EXTERNAL MICROPHONE
12 8 INVERTER
4 HEADPHONE NETWORK
CN6002
1 1
1
USB PHONE USB USB Rear Panel PRINTER DC-IN AV OUT MONITOR
CN6001 CN6004
SPEAKER
SWX-155 Board
(Side-A)
CN1802 CN1404
CN3701 CN3703
NICKEL HYDROGEN CN1902 CN1901 CN1402
CN1803
CN1401 99 1
2
BATTERY CN2301 CN2101
CN1501 25
8
IEEE 1394 CN2202 100 2 VIF-28/31 Board
1
i.LINK
1
CN1801 12
11
CN3001 CN3101
(Side-A)
3
CN1403 1
29
30
CN1701
CN3702
J2
123
124
1
CN3501
1
J1
2
1
1
2
CARD, MODEM
CN301
20
2 1
PC CARD DC FAN 2
20
CONNECTOR CN801 CN3000 30
1
CN4101
29
30
200 CN701 2
1 1
1 CN3002
1 9 1 99 CN3301 1 76
MEMORY CN1502
1
CN3201 199 1
10 2 100 2 CN2402
STICK CN4602
200 2
2
24
10 CN303
CN4601
199 CN702 1 HARD DISK PWS-27 Board
CN2401
(Side-A)
1
1
1
IFX-257 Board CN302 29 CN4100 1
26
25
2
(Side-A) CN2302
CN3003 1 30 2
1
CN2201
CN4401
DC FAN
49
50
S VIDEO
1
60
ENX-23 Board
1
VIDEO CN500 1
IN
CN400
99 1
CN8001 BATTERY PACK
PAD, TOUCH 1 12
100 2
SWX 142 Board
TV Tune Model (Side-A)
CN1
1 12
From board to connector (direct connection)
RAM CARD, LEX-47 Board
Side Harness (connector at both end)
DDR SO-DIMM WIRELESS LAN (Side-A)
Harness (soldered at one end)
Wireless LAN Model
Connectors soldered on board and appearing on the panel
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
3-1 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
(END)
CHAPTER 4.
EXPLODED VIEWS AND PARTS LIST
Hood Keyboard
• The parts list is compiled by blocks of a palmrest and bottom etc. LCD
The sections of the parts list are different depending on the model.
Please refer to list of contents shown in the below.
Other
Section Page
Optical Drive
D-1 ................................................................................... 4-2
Palmrest
Palmrest
P-1 (16-inch Model) ........................................................ 4-3
P-2 (15-inch Model) ........................................................ 4-4
Bottom
B-1 (16-inch Model) ........................................................ 4-5
B-2 (15-inch Model) ........................................................ 4-6
Main Board
Main Board
M-1 .................................................................................. 4-7 Other
Hood Keyboard
HK-1 ................................................................................ 4-8
Other Parts
O-1 ................................................................................... 4-9
LCD Optical
L-1 16-inch SXGA – Made by SH – ............................. 4-10 Drive
L-2 16-inch UXGA, SXGA (Clear Black)
– Made by HI – ....................................................... 4-11
L-3 15-inch XGA (Clear Black) – Made by HI – .......... 4-12
L-4 15-inch SXGA, XGA (Normal, High Brightness)
– Made by SH – ...................................................... 4-13
L-5 14-inch XGA – Made by HI – ................................ 4-14
Accessory
A-1 ................................................................................. 4-15 Other
DIP Switch ......................................................................... 4-16 Bottom
Optical Drive Palmrest Bottom Main Board Hood Keyboard Other LCD Accessory
NOTE: GRT77E/P D-1 P-1 B-1 M-1 HK-1 O-1 L-2 A-1 1 [MA]
GRT55E/B D-1 P-2 B-2 M-1 HK-1 O-1 L-3 A-1
• Items marked “ * ” are not stocked since they are seldom J
J-CTO (16) D-1 P-1 B-1 M-1 HK-1 O-1 L-2 A-1
required for routine service. Some delay should be
J-CTO (15) D-1 P-2 B-2 M-1 HK-1 O-1 L-3,4 A-1
anticipated when ordering these items.
U-CTO (16) D-1 P-1 B-1 M-1 HK-1 O-1 L-2 A-1
• The mechanical parts with no reference number in the
U-CTO (15) D-1 P-2 B-2 M-1 HK-1 O-1 L-3,4 A-1
exploded views are not supplied.
U-CTO (14) D-1 P-2 B-2 M-1 HK-1 O-1 L-5 A-1
• When two or more parts are shown, use the part described AM GRT270G [MA]
D-1 P-1 B-1 M-1 HK-1 O-1 L-2 A-1 2
first as the main part. [MA]
GRT260G D-1 P-1 B-1 M-1 HK-1 O-1 L-2 A-1 2
• The parts marked “ $ ” are the High Value Modules (HVM). [MA]
• The parts marked “ # ” are the parts on which GRT240G D-1 P-2 B-2 M-1 HK-1 O-1 L-3 A-1 2
GRT35F D-1 P-2 B-2 M-1 HK-1 O-1 L-3 A-1 2 [MA]
barcode label is attached.
GRT896HP D-1 P-1 B-1 M-1 HK-1 O-1 L-1 A-1
For the barcode label, refer to CHAPTER 5.
• The parts marked “ & ” are the “Customer Replacable GRT816M D-1 P-1 B-1 M-1 HK-1 O-1 L-2 A-1
Parts (CRP)” that can be replaced by Field Customer GRT895MP D-1 P-2 B-2 M-1 HK-1 O-1 L-4 A-1
Support. EU GRT815E D-1 P-2 B-2 M-1 HK-1 O-1 L-4 A-1
Especially the parts with the <&> mark require the special GRT815M D-1 P-2 B-2 M-1 HK-1 O-1 L-4 A-1
attention to use them. Here fore, check first whether the GRT896SP D-1 P-1 B-1 M-1 HK-1 O-1 L-2 A-1 2 [MA]
desired part is one of the targetted parts of the Customer GRT816S D-1 P-1 B-1 M-1 HK-1 O-1 L-2 A-1 2 [MA]
Replaceable Parts(CRP), or the non-targetted parts by
referring to the exploded view.
• Regarding the boards of this model, the discrete parts
on the boards cannot be replaced. However, Some
connectors can be replaced.
the So type parts for the So type optical drive. B2 4-641-726-11 & SCREW (M2), SPECIAL HEAD
B6 4-656-703-01 & SCREW M2
Replace the peripheral parts of optical drive with the same type in the same way.
(Type So)
J AM EU
6
GRT7xE/P *
GRT5xE/P *
GRT895MP
GRT896HP
GRT896SP
GRT77E/P
GRT55E/B
GRT7xE *
GRT5xE *
GRT270 *
GRT250 *
GRT230 *
GRT816M
GRT815M
GRT270G
GRT260G
GRT240G
GRT815E
GRT816S
GRT35F
Ref.No. Part No. Description
2 2 X-4625-936-1 ASSY SO DVD+-RW BEZEL (So)
X-4626-141-1 ASSY PIONEER DVR BEZEL (Pi)
X-4626-392-1 ASSY SONY CRX830 BEZEL (So)
4 8-457-509-03 $ # DVD DRIVE, DW-U50A-VN/T (So)
1-796-834-11 $ # W-DVD (DVR-K12D)(Pi)
8-457-270-10 $ # RW DRIVE CRX830E-VN (So)
4 6 B25 4-679-805-01 SCREW M1.7X2.5 (B) TAPPING BLK
1 2 2 2 2 2 2
B6
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
1
1 • This parts list contains two different types of parts.
5 B6 The first type is the parts that are common to all models.
B25 The other type is the parts that are different depending on each model.
4
5 • The model that is accompanied by asterisk (*) is the CTO model.
B2 (Type Pi)
B6 B6
3 B2
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-2 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
P-1
P-1. Palmrest (16-inch Model) Ref.No.
101
Part No.
1-796-319-41
Description
PAD, TOUCH
102 9-885-033-60 PWB (H), FLEXIBLE PRINT
103 4-676-871-01 ADHESIVE TP FPC
104 X-4625-918-1 ASSY LATCH DETECTOR
* 105 X-4625-912-1 ASSY TP BRACKET
B5
M O-1
126 B5
130
125
110 124
I O-1
131 O
119 H M-1
109
102
J AM EU
118 G
GRT7xE/P *
GRT896HP
GRT896SP
GRT77E/P
GRT7xE *
GRT270 *
GRT816M
GRT270G
GRT260G
GRT816S
M-1 B2
132
B2
E 103 Ref.No. Part No. Description
114 104 111 C M-1 116 X-4625-906-1 ASSY PALMREST HOUSING
M-1 H 106
D X-4626-046-1 ASSY PALMREST HOUSING (TV)
O-1 125 4-673-722-01 SLIDE WIRELESS KNOB (W)
126 4-673-719-01 ESCUSHION W/O WIRELESS (TV)(16)
105 X-4625-908-1 ASSY ESCUSHION (TV)(16)
B5
4-673-719-11 ESCUSHION W/O WIRELESS (16)
B5 Supplied X-4626-219-1 ASSY ESCUSHION N-TV (16) (W)
101 with 105 1 2 2 2 2
[MA]
[MA]
[MA]
[MA]
[MA]
115 B2
• This parts list contains two different types of parts.
B2 The first type is the parts that are common to all models.
The other type is the parts that are different depending on each model.
117 • The model that is accompanied by asterisk (*) is the CTO model.
B4
• The parts to which (W) is added after the part Description are used in the models in which the Wireless LAN is installed.
• The parts to which (TV) is added after the part Description are used in the models in which the TV Tuner is installed.
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-3 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
P-2
P-2. Palmrest (15-inch Model) Ref.No.
101
Part No.
1-796-319-41
Description
PAD, TOUCH
104 X-4625-918-1 ASSY LATCH DETECTOR
107 4-668-288-11 & CUSHION PALM
114 A-8067-971-A $ COMPLETE PWB LEX-47
115 A-8067-972-A $ COMPLETE PWB SWX-142
Supplied
with 166
B5 107 O-1
M
B5
172
O-1
130 I F B-2
175
160
176 M-1 O
G B4
131 159 B-2
172 152
J AM EU
119
GRT5xE/P *
GRT895MP
GRT55E/B
GRT5xE *
GRT250 *
GRT230 *
GRT815M
GRT240G
GRT815E
GRT35F
104 C Ref.No. Part No. Description
M-1 D O-1 166 X-4625-914-1 ASSY PALMREST HOUSING
B4
X-4625-945-1 ASSY PALMREST HOU (TV)
E M-1
167 175 4-673-683-01 SLIDE WIRELESS KNOB (W)
176 4-673-701-01 ESCUSHION W/O WIRELESS (TV)(15)
X-4625-923-1 ASSY ESCUSHION (TV)(15)
4-673-701-11 ESCUSHION W/O WIRELESS (15)
X-4626-225-1 ASSY ESCUSHION N-TV (15) (W)
114 170
101 Supplied 2 2
with 155
[MA]
[MA]
B5 115 155
• This parts list contains two different types of parts.
The first type is the parts that are common to all models.
B2 B2 The other type is the parts that are different depending on each model.
• The model that is accompanied by asterisk (*) is the CTO model.
153
• The parts to which (W) is added after the part Description are used in the models in which the Wireless LAN is installed.
• The parts to which (TV) is added after the part Description are used in the models in which the TV Tuner is installed.
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-4 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
B-1
B-1. Bottom (16-inch Model) Ref.No.
202
Part No.
4-668-294-11
Description
B5 211 207
221
M-1 209
L
201 B1
O
P-1
Supplied 223
with 201 M-1 R B5
205
B5 B2 212
M-1
A 208
204 202
B2
203
210
202 J AM EU
GRT7xE/P *
GRT896HP
GRT896SP
GRT77E/P
GRT7xE *
GRT270 *
GRT816M
GRT270G
GRT260G
B2
GRT816S
B5
Ref.No. Part No. Description
201 X-4626-447-1 ASSY HOUSING BOTTOM (16) (TV)
214 216 X-4626-445-1 ASSY HOUSING BOTTOM (16)
222 206 4-673-748-01 BRACKET IO LEFT
B4 4-641-726-81 SCREW (M2), SPECIAL HEAD
Supplied 1 2 2 2 2
with 213 B9
[MA]
[MA]
[MA]
[MA]
[MA]
220 • This parts list contains two different types of parts.
The first type is the parts that are common to all models.
213
B24 The other type is the parts that are different depending on each model.
• The model that is accompanied by asterisk (*) is the CTO model.
*1 For the BRACKET IO LEFT of the Tuner model, refer to the Main Board.
• The parts to which (TV) is added after the part Description are used in the models in which the TV Tuner is installed.
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-5 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
B-2
B-2. Bottom (15-inch Model) Ref.No.
202
Part No.
4-668-294-11
Description
B2
203
202
210
B5 J AM EU
B2
GRT5xE/P *
GRT895MP
GRT55E/B
GRT5xE *
GRT250 *
GRT230 *
GRT815M
GRT240G
GRT815E
GRT35F
214 Ref.No. Part No. Description
251 X-4626-444-1 ASSY HOUSING BOTTOM (T)(15)
222 X-4626-405-1 ASSY HOUSING BOTTOM (15)
B9 272 256 4-673-804-01 BRACKET IO LEFT
269 B4 4-641-726-81 SCREW (M2), SPECIAL HEAD
Supplied 2 2
[MA]
[MA]
with 213 • This parts list contains two different types of parts.
The first type is the parts that are common to all models.
213 The other type is the parts that are different depending on each model.
B24 • The model that is accompanied by asterisk (*) is the CTO model.
*1 For the BRACKET IO LEFT of the Tuner model, refer to the Main Board.
• The parts to which (TV) is added after the part Description are used in the models in which the TV Tuner is installed.
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-6 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
M-1
M-1. Main Board Ref.No.
211
Part No.
4-673-986-01
Description
CAP ETHERNET
Ref.No.
321
Part No.
4-674-005-01
Description
CMOS PAD L
221 4-676-461-01 LAN GASKET 20X5X5X 322 4-674-007-01 SHEET PWS 1
P-1/ 301 9-885-033-67 BATTERY, LITHIUM STORAGE 323 4-674-008-01 SHEET PWS 2
K 302 4-642-711-11 SHEET (BATTERY), ADHESIVE 329 4-677-674-02 SPONGE CRYSTAL
P-2 303 4-668-307-01 SHEET DIMM 341 4-677-183-01 FIN GASKET
B5
304 4-668-308-01 SHEET MINI PCI 342 4-677-668-01 FIN MYLAR
343 306 4-673-997-01 SHEET PC CARD 343 A-8115-390-A $ ASSY FAN UNIT
307 4-673-999-01 SHEET PORT 345 4-671-241-01 SHEET THERMAL (STH)
346 308 4-674-000-01 SHEET DIMM SIDE 346 4-677-182-01 FAN PLATE MYLAR
Supplied 309 4-674-001-01 SHEET HDD 347 4-680-129-01 MB HEAT FOIL MYLAR
322 with 343
310 4-676-421-01 SHEET DRIVE B2 4-641-726-11 SCREW (M2), SPECIAL HEAD
* 312 4-673-982-01 NORTH BRIDGE HEATSINK B4 4-641-726-81 SCREW (M2), SPECIAL HEAD
* 313 4-673-811-01 DC IN HOLDER B5 4-641-726-41 SCREW (M2), SPECIAL HEAD
* 314 X-4625-932-1 CPU BACK PLATE ASSY B7 4-645-214-71 GRIP, M2
315 9-885-033-65 HARNESS (2P) B8 4-635-966-01 SCREW (HEX)
B4 323
P-1/ 316 9-885-033-63 DC, HARNESS B10 4-654-386-01 SPACER (PWS)
324 B4 P-2 B2
317 A-8067-969-A $ COMPLETE PWB PWS-27 B11 4-654-387-01 SCREW (MBX)
318 9-885-033-72 CABLE (30P), FLEXIBLE FLAT B12 4-676-485-01 SPACER (CPU), H=5
TV TUNE Model(*1) 318 E 344 319 1-761-606-13 $ # CARD, MODEM B13 4-677-686-01 SPACER (PWS) H=8.0
341
B2 320 4-674-004-01 CMOS PAD U B15 4-654-385-01 SPACER (VIF)
O-1
X 326 342 Supplied B16 7-622-205-05 NUT (M2 TYPE2), HEXAGON
with 344
B2 305
B2
Y
B13
B-1/ 345 J AM EU
B-2 B13 317
GRT7xE/P *
GRT5xE/P *
GRT895MP
GRT896HP
GRT896SP
B10
GRT77E/P
GRT55E/B
GRT7xE *
GRT5xE *
GRT270 *
GRT250 *
GRT230 *
GRT816M
GRT815M
GRT270G
GRT260G
GRT240G
GRT815E
GRT816S
GRT35F
301 329 L
B4 B-1/ O-1/ T
Ref.No. Part No. Description
B-2 P-1 305 4-674-003-01 TUNER BD MYLAR
328 B2 324 9-885-033-66 CONNECTOR PC CARD (1 SLOT) (TV)
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
B4
A
B-1/ 330 • This parts list contains two different types of parts.
B16 R B-2 309
304 The first type is the parts that are common to all models.
B-1/
303 314 The other type is the parts that are different depending on each model.
B-2
308 • The model that is accompanied by asterisk (*) is the CTO model.
347
*1 For the BRACKET IO LEFT of the model without Tuner, refer to the Bottom.
333
B
B-1/ • The parts to which (TV) is added after the part Description are used in the models in which the TV Tuner is installed.
B-2
333
[For CTO]
*2 The FIN MODULE in use is different depending on the CPU.
O-1 For the parts of Ref. 332 and Ref. 344, select a combination of the same type (either type a or type b) of Ref. 332 and Ref. 344.
331 F
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
W-LAN Model PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-7 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
HK-1
HK-1. Hood Keyboard Ref.No.
52
Part No.
4-671-590-01
Description
B2
P-1
W
55
52
58
60
61
60
B23 51
56 53
V 59
M-1
B23
U 54
M-1 57 B23
B23 J AM EU
GRT7xE/P *
GRT5xE/P *
GRT895MP
GRT896HP
GRT896SP
GRT77E/P
GRT55E/B
GRT7xE *
GRT5xE *
GRT270 *
GRT250 *
GRT230 *
GRT816M
GRT815M
GRT270G
GRT260G
GRT240G
GRT815E
GRT816S
GRT35F
Z
M-1 62 Ref.No. Part No. Description
51 A-8116-871-A SPEAKER UNIT (FO-2+)(16)
A-8116-869-A SPEAKER UNIT FO-2 (15)
54 4-679-084-01 SPEAKER HOLDER R (16)
4-679-081-01 SPEAKER HOLDER R (15)
55 X-4626-394-1 ASSY HOOD KEYBOARD (16)
X-4626-393-1 ASSY HOOD KEYBOARD (15)
1 2 2 2 2 2 2
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
• This parts list contains two different types of parts.
The first type is the parts that are common to all models.
The other type is the parts that are different depending on each model.
• The model that is accompanied by asterisk (*) is the CTO model.
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-8 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
O-1
O-1.Other Parts Ref.No.
108
Part No.
4-676-948-01
Description
RUBBER STOPPER
352 X-4625-931-2 VGA HEAT PLATE ASSY
353 4-670-461-01 SHEET BLIND (PLATE HEATSINK)
354 4-673-987-01 VGA PLATE MYLAR
355 4-676-423-01 VGA THERMAL PAD
B26
B26
16 inch LCD Model 15 inch LCD Model 357 4-677-667-01 VGA PAD
358 4-677-943-01 VGA MYLAR
362 4-676-418-01 BRACKET HDD
364 4-653-801-01 SHEET HDD
B26 B26 B1 4-654-811-41 & SCREW M3
B2 4-641-726-11 & SCREW (M2), SPECIAL HEAD
B3 4-656-703-01 SCREW (M2), SPECIAL HEAD
B4 4-641-726-81 SCREW (M2), SPECIAL HEAD
B5 4-641-726-41 SCREW (M2), SPECIAL HEAD
N N B20 4-635-301-11 SCREW M3X4
P-1 X P-2 B22 4-654-811-01 SCREW M3
M-1 B26 4-644-637-01 GRIP, M2 EG
P-2
M P-1 M
380 380
B3
352
P-1/ 353 F F
P-2 D M-1 M-1
W-LAN Model W-LAN Model
Supplied
with 352 J AM EU
GRT7xE/P *
GRT5xE/P *
354
GRT895MP
GRT896HP
GRT896SP
GRT77E/P
GRT55E/B
GRT7xE *
GRT5xE *
GRT270 *
GRT250 *
GRT230 *
GRT816M
GRT815M
GRT270G
GRT260G
GRT240G
GRT815E
GRT816S
GRT35F
355
Ref.No. Part No. Description
351 1-478-018-11 $ # KEY BOARD UNIT (JP)
B4 1-478-018-21 $ # KEY BOARD UNIT (US)
1-478-023-11 $ # (UK/Dutch)...KEY BOARD UNIT (GB)
1-478-023-21 $ # (German)...KEY BOARD UNIT (DE)
351 1-478-023-31 $ # (Swiss)...KEY BOARD UNIT (CH)
358 1-478-023-41 $ # (French)...KEY BOARD UNIT (FR)
1-478-023-51 $ # (Italian)...KEY BOARD UNIT (IT)
357 2 [MA] 1-478-023-61 $ # KEY BOARD UNIT (LA)
1-478-023-81 $ # (Spanish)...KEY BOARD UNIT (ES)
Q VIF-31 Board 1-478-023-91 $ # (Swedish)...KEY BOARD UNIT (SE)
356 A-8068-276-A $ COMPLETE PWB VIF-31
M-1 A-8068-509-A $ COMPLETE PWB VIF-28
361 A-8116-404-A $ # HDD (40GB,IC25N040ATMR04)
A-8116-402-A $ # HDD (60GB,IC25N060ATMR04)
A-8067-943-A $ # ASSY HDD 80GB (I,40)(S)
356 A-8113-860-A $ # ASSY HDD 30GB(H)(S)
A-8117-059-A $ # HDD (DK23FA-40,40G)
A-8117-585-A $ # HDD (DK23FA-60,60G)
A-8117-058-A $ # ASSY HDD 80GB (H,40)(S)
J M-1 363 X-4626-446-1 ASSY DOOR HDD
365 4-673-686-01 DOOR HDD(15)
I 365 X-4626-407-1 HEAT PLATE
371 X-4625-916-1 ASSY DISPLAY BASE
358 P-1/ 380 1-400-255-21 FERRITE CORE
357 P-2
358 1 2 2 2 2 2 2
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
Q VIF-28 Board
M-1
361
• This parts list contains two different types of parts.
B20
356 The first type is the parts that are common to all models.
108
The other type is the parts that are different depending on each model.
• The model that is accompanied by asterisk (*) is the CTO model.
B2
362
B20
15inch Model 16inch Model
364
363 363
B4
371
108
T
M-1 B2
B22 B1
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-9 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
L-1
404
L-1. LCD 16-inch SXGA 403 B5 405
Ref.No.
221
Part No.
4-676-461-01
Description
– Made by SH – 406 B5
401
402
4-674-542-01
A-8115-904-A
& COVER SCREW LOWER
ASSY HOUSING BEZEL/SH
401 403 4-673-716-01 & COVER HINGE
402 407 404 4-674-540-01 & COVER SCREW UPPER
B29 404
405 4-674-541-01 & COVER SCREW MIDDLE
406 4-672-201-11 & CUSHION BEZEL
B5 407 4-674-539-01 & CUSHION LATCH
408 4-679-379-11 LABEL ID GRT896HP
409 4-673-753-01 BRACKET LCD SH L
413
414 G
H
428
B2 415 416
432
D
417
221 432
421 W-LAN Model
441
430
B2 432
426
• This parts list contains two different types of parts.
The first type is the parts that are common to all models.
425 G B2
427 D The other type is the parts that are different depending on each model.
H
• The model that is accompanied by asterisk (*) is the CTO model.
432
423
FE
A
424
420
418
Supplied
with 425 Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-10 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
L-2
404
L-2. LCD 16-inch 403 B5
Ref.No.
401
Part No.
4-674-542-01 &
Description
B19 404
407 4-674-539-01 & CUSHION LATCH
–Made by HI – B5
412
414
4-676-870-01
4-677-679-01
SHIELD DISPLAY
FOIL LCD HARNESS
415 4-673-727-01 LATCH HONTAI
416 4-673-728-01 LATCH BUTTON
F
535 511
E B30
412 J AM EU
513
GRT7xE/P *
GRT896SP
GRT77E/P
GRT7xE *
GRT270 *
GRT816M
GRT270G
GRT260G
GRT816S
414 G Ref.No. Part No. Description
424 4-672-196-01 TUBE WL CABLE
H 430 1-754-295-11 ANTENNA, FILM (L AND R)
432 FILAMENT TAPE
428 415 416 1 [MA] 508 4-678-549-01 LABEL ID
B2 4-679-379-21 LABEL ID
2 [MA] 4-679-379-61 LABEL ID
2 [MA] 4-679-379-71 LABEL ID
432 [MA] 4-679-392-11 LABEL ID
417 2
525 D 2 [MA] 4-679-392-21 LABEL ID
510 A-8115-722-A $ # LCD UNIT (16TFT-UXGA-HI)(S)
432 A-8115-721-A $ # LCD UNIT (16TFT-SXGA+-HI)(S)
421 W-LAN Model 537 4-680-580-01 BUSTERAID W-LAN
536
1 2 2 2 2
430
[MA]
[MA]
[MA]
[MA]
[MA]
B2
526 432
• This parts list contains two different types of parts.
The first type is the parts that are common to all models.
G B2 D The other type is the parts that are different depending on each model.
H 526
• The model that is accompanied by asterisk (*) is the CTO model.
432
523
I FE
A 424
420
418
Supplied
with 525 Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-11 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
L-3
L-3. LCD 15-inch XGA (Clear Black) 705
Ref.No.
406
Part No.
4-672-201-11
Description
–Made by HI – 703
705 414
428
4-677-679-01
4-672-403-01
FOIL LCD HARNESS
COPPER TAPE LCD ED
B17 702 431 4-680-130-01 CU-FOIL WITH MYLAR
523 1-478-040-11 INVERTER UNIT
B17
701
406 701 4-672-197-11 & COVER SCREW LOWER
722 702 A-8115-900-A ASSY HOUSING BEZEL 15 HIT
703 4-667-073-11 & COVER HINGE
B18 705 4-672-198-11 & COVER SCREW UPPER
706 4-673-710-01 LATCH HONTAI
712
713 G
A
733 Supplied
414 with 712
428
431
729 C
706 J AM
714 F
B17
GRT5xE/P *
GRT55E/B
GRT5xE *
GRT250 *
GRT240G
E
GRT35F
B4
D
432
708
Ref.No. Part No. Description
W-LAN Model 432 FILAMENT TAPE
432 432 537 4-680-580-01 BUSTERAID W-LAN
740 740 2 [MA] 725 4-679-188-11 LABEL ID
2 [MA] 4-679-392-31 LABEL ID
715 719 4-678-549-11 LABEL ID
740 1-754-295-21 ANTENNA, FILM (L AND R)
730 Supplied
2 2
with 718
[MA]
[MA]
D
• This parts list contains two different types of parts.
432
The first type is the parts that are common to all models.
The other type is the parts that are different depending on each model.
E • The model that is accompanied by asterisk (*) is the CTO model.
F
523
727
G 717
726 A 727
728
731 718
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-12 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
L-4
705
L-4. LCD 15-inch SXGA, XGA 705
Ref.No.
406
Part No.
4-672-201-11
Description
813 A
414
806 714
826
428 431 C
F
826 E 812 B4
J AM EU
B17
GRT5xE/P *
GRT895MP
GRT5xE *
GRT250 *
GRT815M
708
GRT815E
835
Ref.No. Part No. Description
432 FILAMENT TAPE
G 811 A-8115-790-A $ # ASSY LCD 15XGA (SH)(S)
A-8113-853-A $ # ASSY LCD 15 (SH) GT2 (S)
813 9-885-031-28 15XGA N/B HARNESS
715 H
9-885-031-27 15XGA N/B/L HARNESS
825 4-679-379-31 LABEL ID
4-679-379-41 LABEL ID
836 4-679-379-51 LABEL ID
432 830 1-754-295-31 ANTENNA, FILM (L AND R)
W-LAN Model
818
G D 432 • This parts list contains two different types of parts.
H The first type is the parts that are common to all models.
432 830
The other type is the parts that are different depending on each model.
423
• The model that is accompanied by asterisk (*) is the CTO model.
D
A E
F
717
834
Supplied
with 818
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-13 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
L-5
905
L-5. LCD 14-inch XGA 905
Ref.No.
406
Part No.
4-672-201-11
Description
913 A
414
806 714
826
428 431 C
826 F
E 912 B4
B17
708
835
715 H
836
432
W-LAN Model
818
G D 432
H
432 830
916
A E
F
717
834
Supplied
with 818
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-14 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
A-1
A-1. Accessory
1003
Battery Pack 2 [MA]
1014
FILTER CLAMP *1
J AM EU
GRT7xE/P *
GRT5xE/P *
1009
GRT895MP
GRT896HP
GRT896SP
GRT77E/P
GRT55E/B
GRT7xE *
GRT5xE *
GRT270 *
GRT250 *
GRT230 *
GRT816M
GRT815M
GRT270G
GRT260G
GRT240G
GRT815E
GRT816S
GRT35F
1004 Attenuator
Ref.No. Part No. Description
Power Cord *10 1001 1-478-037-32 $ & ADAPTOR, AC
0 1-478-038-12 $ & ADAPTOR, AC
1003 A-8067-763-A $ # & BP2NX SNT(J)ASSY(S)
A-8112-427-A $ # & BP2NX SNT(U)ASSY(S)
1-756-269-42 $ # & BATTERY PACK, LITHIUM ION
0 1004 1-575-131-61 & CORD, POWER
0 1005 1-757-562-01 & CORD, POWER
1-757-562-21 & CORD, POWER
1010 0 1006 1-790-732-32 & CORD, POWER
Combo Dummy 1007
1008
1-783-801-22
1-770-019-12
&
&
CORD, CONNECTION
ADAPTOR, CONVERSION PLUG 3P
1009 1-417-422-11 & CABLE, RF ATTENUATOR (TV)
1010 4-673-694-01 & COMBO DUMMY
1005 [MA]
1011 1-823-959-11 & CORD, COAXIAL CONNECTOR WITH (TV)
2 1012 1-477-556-21 & REMOTE COMMANDER (TV)
Power Cord 1-477-900-11 & REMOTE COMMANDER
1013 1-477-218-41 & RAY-CATCHER UNIT (TV)
*1 1014 1-400-636-11 & FILTER, CLAMP (FERRITE CORE)
1-400-255-21 & FERRITE CORE
4-679-420-01 & GETTING STARTED BOOKLET
1011 4-679-074-01 & Instruction Manual (XP)
4-679-028-01 & QUICK START
Antena Cable 4-679-038-01 & QUICK START
4-679-144-01 & QUICK START
4-679-143-01 & SPEC SHEET
1 2 2 2 2 2 2
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
1006
Power Cord
*1 For the AC adaptor shown by the reference No. 1001 of the GRT270G, GRT260G and GRT240G, be sure to install the FILTER
1012 CLAMP shown by reference No. 1014.
Remote Commander
FILTER CLAMP
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-15 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
DIP Switch [FOR CTO MODEL]
O
N
The DIP switch setting is following table. Not Mobile CPU Mobile CPU
CPU Type
O
N
N
1 : Not Mobile CPU
0 : Mobile CPU
1
2
3
4
5
6
7
8
1 [MA]
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
PCG-GRT55E/B PCG-GRT77E/P
O
O
N
N
Reserved
O
N
J
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
2 [MA] 2 [MA] 2 [MA]
PCG-GRT270G PCG-GRT260G PCG-GRT240G LCD Size 16inch LCD 15/14inch LCD
O
N
N
1 : 16inch LCD
O
O
N
N
0 : 15/14inch LCD
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
AM 2 [MA] LCD Type VIF-28 board VIF-31 board
PCG-GRT35F VIF-28 board XGA XGA
O
N
N
01101 : XGA
O
N
10101 : SXGA
00101 : SXGA+
11001 : UXGA
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
VIF-31 board
SXGA SXGA
01111 : XGA
O
N
N
10111 : SXGA
PCG-GRT896HP PCG-GRT816M PCG-GRT895MP
00111 : SXGA+
O
O
N
11011 : UXGA
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
0 : ON 1: OFF
SXGA+ SXGA+
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
O
N
N
EU 2 [MA] 2 [MA]
PCG-GRT815E,GRT815M PCG-GRT896SP PCG-GRT816S
O
O
N
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
UXGA UXGA
O
N
N
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
The DIP switch setting is different depending the types of LCD, CPU and VIF board.
Set the DIP switch of the CTO model in accordance with the above table.
For the method of identifying the types of the VIF board, see the illustration shown below.
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
4-16 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
(END)
CHAPTER 5.
OTHERS
[ LCD Unit (16-inch UXGA Clear Black) (HI) ] [ LCD Unit (15-inch XGA) (SH) ] (Rear)
(Rear)
E
5-1. The barcode label
B
The hatched portion of the barcode label is used as the repair data.
B
[ MBX-86 Board ] (Side A) [ HDD ] (Made by I) (Top) [ DVD+-RW Drive ] (Made by So) (Top) [ LCD Unit (15-inch SXGA) (SH) ] (Rear)
[ LCD Unit (16-inch SXGA Clear Black) (HI) ]
(Rear)
C1
C
C2
E
F C3
B
B, D B, D
G
[ HDD ] (Made by Hi) (Top)
[ DVD-RW Drive ] (Made by Pi) (Top) B
[ MBX-86 Board ] (Side B) D2
A, B [ LCD Unit (16-inch SXGA) (SH) ] (Rear) [ LCD Unit (15-inch XGA Clear Black) (HI) ]
D1 B, D (Rear)
B, C
[ HDD ] (Made by Fu) (Top)
C
[ Combination Drive ] (Made by So) (Top)
B
[ Wireless LAN Card ]
D [ LCD Unit (14-inch XGA) (HI) ] (Rear)
G
C
B, D B
[ Modem Card ]
C
A : Parts No.
B : Serial No.
C : Revision No.
D : Product code
B, D
E : Maker Barcode
F : Global User ID (iLink)
G : Mac Address
: Barcode
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270G/GRT270* (AM)
5-1 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
5-2. Replacing the CPU
1. Removing the CPU 2. Installing the CPU
1 Insert a flat-blade screwdriver into the notch as shown in the illustration 1 Align the triangle reference mark of the CPU with that of the CPU socket and
and rotate it so that the protrusion comes to the lock release position. insert all the pins of the CPU to the corresponding holes of the CPU socket.
2 Pull the CPU gently upward to lift it out of the CPU socket. 2 Insert a flat-blade screwdriver into the notch as shown in the illustration and rotate
it so that the protrusion comes to the lock position.
1 2
1 2
CPU
CPU
CPU socket
CPU socket Lock position
Lock release position
NOTE:
Rotate a flat-blade screwdriver to the lock position securely. If not, the operation of the
CPU may become unstable.
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270G/GRT270* (AM)
5-2 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
5-3. CTO Information
1. PCG-GRT7xE
DVD+-RW
Optical 8-457-509-03
DVD DRIVE, DW-U50A-VN/T
PCGA-BP2NX
Battery A-8067-763-A
BP2NX SNT(J)ASSY(S)
NV31(VIF-28)
GFX A-8068-509-A
COMPLETE PWB VIF-28(IN)
Gigapo a X
W-LAN X
DVD+-RW
Optical 8-457-509-03
DVD DRIVE, DW-U50A-VN/T
PCGA-BP2NX
Battery A-8067-763-A
BP2NX SNT(J)ASSY(S)
NV31(VIF-28)
GFX A-8068-509-A
COMPLETE PWB VIF-28(IN)
Gigapo a X
W-LAN X
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270G/GRT270* (AM)
5-3 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
2. PCG-GRT5xE
DVD+-RW CD-RW/DVD-ROM
Optical 8-457-509-03 8-457-270-10
DVD DRIVE, DW-U50A-VN/T RW DRIVE CRX830E-VN
BP2NX
Battery A-8067-763-A
BP2NX SNT(J)ASSY(S)
SQ17(VIF-31)
GFX A-8068-276-A
COMPLETE PWB VIF-31
Gigapo a X
✱❑❅M X
DVD+-RW CD-RW/DVD-ROM
Optical 8-457-509-03 8-457-270-10
DVD DRIVE, DW-U50A-VN/T RW DRIVE CRX830E-VN
BP2NX
Battery A-8067-763-A
BP2NX SNT(J)ASSY(S)
SQ17(VIF-31)
GFX A-8068-276-A
COMPLETE PWB VIF-31
Gigapo a X
✱❑❅M X
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270G/GRT270* (AM)
5-4 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
3. PCG-GRT270
Model name : PCG-GRT270P
Model number :
OS : WindowsXP Pro
Ver.1.0
16.1 UXGA(Clear Black)
LCD A-8115-722-A
LCD UNIT(16TFT-UXGA-HI)(S)
DVD+-RW CD-RW/DVD-ROM
Optical 8-457-509-03 8-457-270-10
DVD DRIVE, DW-U50A-VN/T RW DRIVE CRX830E-VN
PCGA-BP2NX
Battery A-8112-427-A
BP2NX SNT(U)ASSY(S)
NV31(VIF-28)
GFX A-8068-509-A
COMPLETE PWB VIF-28(IN)
W-LAN a X
Gigapo X
DVD+-RW CD-RW/DVD-ROM
Optical 8-457-509-03 8-457-270-10
DVD DRIVE, DW-U50A-VN/T RW DRIVE CRX830E-VN
PCGA-BP2NX
Battery A-8112-427-A
BP2NX SNT(U)ASSY(S)
NV31(VIF-28)
GFX A-8068-509-A
COMPLETE PWB VIF-28(IN)
W-LAN a X
Gigapo X
DVD+-RW CD-RW/DVD-ROM
Optical 8-457-509-03 8-457-270-10
DVD DRIVE, DW-U50A-VN/T RW DRIVE CRX830E-VN
PCGA-BP2NX
Battery A-8112-427-A
BP2NX SNT(U)ASSY(S)
NV31(VIF-28)
GFX A-8068-509-A
COMPLETE PWB VIF-28(IN)
W-LAN X
Gigapo X
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270G/GRT270* (AM)
5-5 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
4. PCG-GRT250
Model name : PCG-GRT250P
Model number :
OS : WindowsXP Pro
Ver.1.0
15 XGA(Clear Black) 15 XGA
LCD A-8115-792-A A-8113-853-A
ASSY LCD 15XGA(HI)(S) ASSY LCD 15(SH) GT2 (S)
P4-M2.6GHz P4-M2.4GHz P4-M2.2GHz M-CEL 2.0GHz P4-2.8GHz P4-2.66 GHz P4 2.4BGHz
CPU 6-705-187-01 6-704-615-01 6-704-614-01 6-704-652-01 6-704-133-01 6-704-666-01 6-704-668-01
IC RH80532GC064512SL6WZ IC RH80532GC056512SL6VC IC RH80532GC049512SL6VB IC RH80532NC041256SL6VJ IC RK80532PE072512SL6S4 IC RK80532PE067512SL6PE IC RK80532PE056512SL6PC
DVD+-RW CD-RW/DVD-ROM
Optical 8-457-509-03 8-457-270-10
DVD DRIVE, DW-U50A-VN/T RW DRIVE CRX830E-VN
PCGA-BP2NX
Battery A-8112-427-A
BP2NX SNT(U)ASSY(S)
SQ17(VIF-31)
GFX A-8068-276-A
COMPLETE PWB VIF-31
W-LAN a X
Gigapo X
DVD+-RW CD-RW/DVD-ROM
Optical 8-457-509-03 8-457-270-10
DVD DRIVE, DW-U50A-VN/T RW DRIVE CRX830E-VN
PCGA-BP2NX
Battery A-8112-427-A
BP2NX SNT(U)ASSY(S)
SQ17(VIF-31)
GFX A-8068-276-A
COMPLETE PWB VIF-31
W-LAN a X
Gigapo X
DVD+-RW CD-RW/DVD-ROM
Optical 8-457-509-03 8-457-270-10
DVD DRIVE, DW-U50A-VN/T RW DRIVE CRX830E-VN
PCGA-BP2NX
Battery A-8112-427-A
BP2NX SNT(U)ASSY(S)
SQ17(VIF-31)
GFX A-8068-276-A
COMPLETE PWB VIF-31
W-LAN X
Gigapo X
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270G/GRT270* (AM)
5-6 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
5. PCG-GRT230
512MB(512MBx1) 256MB(256MBx1)
Memory A-8068-348-A 6-704-094-01
COMPLETE PWB MM-10A IC MT8VDDT3264HDG-265C3
CD-RW/DVD-ROM
Optical 8-457-270-10
RW DRIVE CRX830E-VN
PCGA-BP2NX
Battery A-8112-427-A
BP2NX SNT(U)ASSY(S)
SQ17(VIF-31)
GFX A-8068-276-A
COMPLETE PWB VIF-31
W-LAN X
Gigapo X
Confidential
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270G/GRT270* (AM)
5-7 PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
(END)
PCG-GRT55E/GRT77E (J)
PCG-GRT35F/GRT240G/GRT260G/GRT270G (AM)
PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)
* : CTO Model
: Additional Models
English/Japanese
2003J1600-1
9-876-352-03 Sony Corporation © 2003 Sony Corporation
— 30 — Published by Sony EMCS VAIO-GSC [SNT]
Revision History
-03 Ver. 3 2003/10/27 Front Page (Model Line Up), Page 1-1, Page 4-1 - 4-9, Page 4-11 - 4-12, N2003_085AK
[Confidential]
PCG-GRT55E/GRT5xE*/GRT77E/GRT7xE* (J)
PCG-GRT35F/GRT230*/GRT240G/GRT250*/GRT260G/GRT270*/GRT270G (AM)
PCG-GRT815E/GRT815M/GRT816M/GRT816S/GRT895MP/GRT896HP/GRT896SP (EU)