Professional Documents
Culture Documents
Service Manual: PCG-FXA47/ /FXA49
Service Manual: PCG-FXA47/ /FXA49
S400
Lineup : PCG-FXA47
PCG-FXA48
t i a l
PCG-FXA49 Illust : PCG-FXA49
i d e n
o n f
C
NOTEBOOK COMPUTER
9-874-507-04
Information in this document is subject to change without notice. Caution Markings for Lithium/Ion Battery - The following or similar
texts shall be provided on battery pack of equipment or in both the
Sony and VAIO are trademarks of Sony. Intel logo and Intel Inside operating and the service instructions.
logo are registered trademarks of Intel Corporation. Pentium MMX
is a trademark of Intel Corporation. Microsoft, MS-DOS, Windows, CAUTION: Danger of explosion if battery is incorrectly replaced.
the Windows 95 and Windows 98 logo are trademarks of Microsoft Replace only with the same or equivalent type recommended by
Corporation. the manufacturer. Discard used batteries according to the
manufacturer’s instructions.
All other trademarks are trademarks or registered trademarks of
their respective owners. Other trademarks and trade names may be CAUTION: The battery pack used in this device may present a fire
used in this document to refer to the entitles claiming the marks and or chemical burn hazard if mistreated. Do not disassemble, heat
names or their produces. Sony Corporation disclaims any proprietary above 100°C (212°F) or incinerate.
interest in trademarks and trade names other than its own. Dispose of used battery promptly.
Keep away from children.
Confidential
—2— PCG-FXA47/FXA48/FXA49 (AM)
TABLE OF CONTENTS
Confidential
—3— PCG-FXA47/FXA48/FXA49 (AM)
CHAPTER 1.
REMOVAL
ATTENTION
Please confirm disassembly method by “Repair Manual” which has been informed you
separately.
Confidential
1-1 PCG-FXA47/FXA48/FXA49 (AM)
(END)
CHAPTER 2.
SELF DIAGNOSTICS
ATTENTION
Please confirm “Self Diagnostics” method which will be informed you with distribution
of “Self Diagnostics” software.
Confidential
2-1 PCG-FXA47/FXA48/FXA49 (AM)
(END)
CHAPTER 3.
BLOCK DIAGRAM
CPU
AMD Mobile Athlon 4 PCG-FX Series
1000/1200MHz
(Cache:128KB L1 256KB L2) BLOCK DIAGRAM Rev.A
(FSB 200 MHz)
462 PIN PGA SOCKET A
LCD Panel w/ Port Replicator (PCGA-PRFX1) 2001/08/27
PC Card
Socket 1
PC Card
Socket 2
14.1"/15" TFT
Main Memory XGA Port Replicator
PC100 SO-DIMM 12 V IN
ADDRESS
SIGNAL
CTRL
CNX-126
DATA
256MB X1/256MB X2
(Max.512MB)
CPU CLOCK
Main System Board MBX-61
CLK GEN PCI CLOCK
3 VGA
PCI BUS
ICS9248BF-168 USB CLOCK
14M CLOCK
10
Serial
4
AC LINK DSUB-9
i.LINK PHY LAN
USB P0 TI TI Realtec
USB 0
TSB12LV26 TSB41LV01 RTL8139CL
USB P1
7
COM Parallel
20/30GB 5
SIGNAL DSUB-25
MAX3243 4
Ext. MIC
Secondary IDE Bus LPT
CN
Optical Parallel
Devices PS/2
D SUB-25 11 6
MDIN-6
5
ISA
7 USB 1
KBD
PCU
NS KBC 8 USB 2
BIOS
PC 87570 PS/2
Flash 6
4M bit
9 USB 3
VA V IN
Touch 7 4 11
1 12
Pad
CN CN CN
18-pin 2-pin 10-pin
CN
CN
CN
60-pin SP_L SP_R
BATTERY 0 POW
Serial
LID T/P BOARD USB 1 RJ-11
D SUB-9
DC/DC BOARD POWER SWITCH
CNX-129
BATTERY 1
PWS-14 I/O SUB BOARD CNX-150 BOARD SWX-74
Confidential
3-1 3-2 PCG-FXA47/FXA48/FXA49 (AM)
(END)
CHAPTER 4.
FRAME HARNESS DIAGRAM
DC-IN USB NETWORK MONITOR PRINTER SERIAL USB PHONE
Rear Panel
LCD
KEY BOARD
INVERTER
DC FAN
FFC LED
PL1
1
1
CON21 1
CON20
9
(Side-A)
JP1
2 50 1 CON15 25 10 2
18
CON4
2
CPU 50 26
18
1 CON4 49 1
99 1
CON19 4
1
100 50 2 CON23
2
VIDEO OUT CON5 1 49 CON9
CPU1 FPC
HEADPHONE CON17
CON2
MBX-61 Board
IEEE 1394 i.LINK
CON8
1 CON1 143 1 CON12 29
(Side-A) CARD MODEM
2 144 HARD DISK 2 30
J1
1 29
150
75
Side 1
1 3
143 2 30
1
2 144
CON2 CON14
CON10
FPC
Speaker L Speaker R
PC CARD
CONNECTOR
50
76 CON7
60 CON22 2
CON3 49
50
2
JP2
JP3
59 1
1
10 1
SWX-74
JP1
1
1
(Side-A)
2
1
2
COMBO DRIVE
60 2
RAM RAM
59 BCN1 1
PC100 SO-DIMM PC100 SO-DIMM
(FXA49 Model) 256MB FLOPPY DISK
256MB DRIVE
(FXA47/FXA48 Model)
OPTION
1
BCN4
BATTERY PACK
PWS-14 Board
(Side-B)
6
BCN2
7 1 From board to connector (direct connection)
8 2
6
JP1 JP2
Connectors soldered on board and appearing on the panel
TOUCH PAD
Confidential
4-1 4-2 PCG-FXA47/FXA48/FXA49 (AM)
(END)
CHAPTER 5.
EXPLODED VIEWS AND PARTS LIST
NOTE:
• The mechanical parts with no reference number in the The components identified by mark 0 or
exploded views are not supplied. dotted line with mark 0 are critical for safety.
Replace only with part number specified.
• Items marked “ * ” are not stocked since they are seldom
required for routine service. Some delay should be Les composants identifiés par une marque
anticipated when ordering these items. 0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
• When two or more parts are shown in parallel, use the
le numéro spécifié.
part described first as the main part.
• The indication [CH] is used for identification of part type.
• Regarding the boards of this model, the discrete parts
on the boards cannot be replaced. However, Some
connectors can be replaced.
Confidential
5-1 PCG-FXA47/FXA48/FXA49 (AM)
5-1. Main Section
Ref.No. Part No. Description Ref.No. Part No. Description
1 X-4623-848-2 [CH]...ASSY BOTTOM (Q) 155 4-651-701-01 DOOR MODEM
3 4-640-837-22 DOOR BATTERY 157 4-654-701-01 CUSHION (HD-M2)
*8 4-651-706-01 HEATSINK BOTTOM 161 4-654-019-01 GASKET (AV)
* 11 4-656-752-01 [CH]...INSULATOR HEATSINK BOTTOM 162 4-654-047-01 SHIELD (AV)
15 4-643-832-21 DUMMY CARD 163 4-653-936-01 GASKET (HB/M)
18 A-8049-276-A COMPLETE PWB SWX-74 164 A-8059-275-A COOLING UNIT-3
19 X-4623-389-1 ASSY HOOD KEYBOARD Z (P) 165 4-644-667-01 COVER RJ-11
20 1-529-287-11 SPEAKER UNIT 166 4-654-631-01 GUARD SPK
22 1-790-639-22 FPC 50PIN (FOR HDD) 180 4-656-486-01 TAPE CPU (A6)
24 1-796-184-11 (FXA47)...HDD (DK23CA-20F-20G) * 181 4-654-398-01 PLATE GROUND (SH)
24 1-796-172-11 (FXA48/FXA49)...HDD (DK23CA-30F-30G) 182 4-657-164-03 BRACKET WIRE 2
25 1-476-647-12 KEY BOARD UNIT (US) 183 4-655-511-01 GASCKET (DRIVE)
26 X-4623-849-2 [CH]...ASSY PALMREST (Q) 184 4-654-776-01 INSULATOR (SCREW)
27 1-772-529-72 PAD, TOUCH 185 4-654-783-01 SHIELD TAPE (HDD)
28 A-8049-275-A COMPLETE PWB CNX-129 186 4-655-042-01 SHIELD SHEET (FAN)
* 29 4-651-699-01 BRACKET PAD 187 4-658-711-01 SHIELD TAPE (FAN)2
* 30 4-651-708-12 BRACKET (HDD) 188 4-658-542-01 SPACER (KEY BOARD)
31 4-640-861-04 BRACKET CD-ROM R 190 4-657-629-01 SPRING DRIVE (PA)
32 1-796-264-11 COMBO DRIVE (UJDA720) 191 4-657-049-01 SPRING DRIVE (PA-R)
33 X-4623-436-2 ASSY DOOR DVD-RW (PA) 192 4-658-470-01 [CH]...GASKET (DOCK)
* 34 4-640-860-03 BRACKET (CD-ROM L) 193 4-659-640-01 TAPE (DOCK) J
38 4-656-727-01 [CH]...DOOR I/O 194 4-659-641-01 SHIELD TAPE (USB) 2J
39 4-656-735-01 [CH]...FOOT REAR 195 9-885-020-01 CABLE ASSY (RJ-45-CONN)
40 4-651-714-01 DOOR DOCKING CONNECTOR 196 4-653-151-01 SPACER (KBF)
41 4-656-736-01 [CH]...FOOT FRONT
B1 4-641-726-41 SCREW (M2), SPECIAL HEAD
46 A-8049-270-A COMPLETE PWB PWS-14 B3 4-644-899-01 SCREW (M2), 0 NUMBER P3 KIND
48 1-761-380-23 CARD, MODEM B4 4-639-112-01 SCREW M2X4
52 1-790-640-11 FPC 50PIN (FOR CD-ROM) B7 4-644-402-12 SCREW (MBX)
55 4-640-845-11 BUTTON BAY B8 4-641-726-11 SCREW (M2), SPECIAL HEAD
56 4-644-349-01 LATCH BAY
B10 4-652-498-01 +B M2 (NOJI)
* 57 4-640-854-01 SPRING BAY B12 4-645-177-01 SCREW (M1.7X3.5)
* 58 4-651-850-01 BRACKET BOTTOM B14 4-645-497-01 SCREW (M2.6), CROSS (HOLE) BIND
* 59 4-640-857-01 DOOR BATTERY SPRING B15 4-635-301-01 SCREW M3X4
60 4-651-698-01 DISPLAY BASE B17 7-622-205-05 NUT M2 TYPE2
63 4-651-928-02 COVER BATTERY CONNECTOR
B31 4-645-214-11 GRIP, M2
67 4-656-756-01 [CH]...LABEL I/O B32 7-621-772-68 SCREW +B 2X12
* 71 4-641-851-02 SPRING (FDD), PLATE B33 4-642-852-21 +B M2
72 4-657-283-01 [CH]...BRACKET IO B38 4-651-989-01 SPACER (MBX)
74 4-651-702-01 DOOR DIMM
* 76 4-644-361-01 BRACKET SPK 800 Refer to section “5-2.FDD Section”
* 78 4-644-362-11 PLATE PALMREST
81 6-600-065-01 IC MT8LSDT3264HG-10EB1
(PC-100 SO-DIMM (256MB CL2)) ∗1 When replacing the LCD or the MBX-61 board,
81 6-600-097-01 IC HYS64V32220GDL-8-C2
(PC-100 SO-DIMM (256MB CL2)) confirm the DIP switch position beforehand.
84 1-960-827-21 HARNESS (2 PIN) (Refer to LCD Section.)
88 A-8058-677-A MAIN BOARD ASSY (∗1)
105 4-641-630-11 COVER BAY HOLE
123 1-790-711-21 FFC (PPK)
124 1-757-767-11 FFC (TP-CNX)
125 1-790-710-11 FFC (SWX-PWS)
* 134 4-645-433-01 BRACKET BAY CONNECTOR
136 4-644-357-01 CUSHION SPK
147 6-701-607-01 (FXA47)...
IC AHM1000AVS3B (Athlon4 1.0GHz)
147 6-702-162-01 (FXA48/FXA49)...
IC AHM1200AJS3B (Athlon4 1.2GHz)
148 X-4623-561-2 ASSY LATCH DETECTOR
149 1-756-148-11 SECONDARY BATTERY, LITHIUM
Confidential
5-2 PCG-FXA47/FXA48/FXA49 (AM)
B8
B1
B33 B33 J I
187
181 B1 J
185 B1
22
186 B1 30
B32 A
N B15 N
25
K
M
B1 B15 B1 B8
60
188 19
24
Supplied C
with 19
164 27
B14 26
B1 136
180
20
15 147 125
166 124
B17
182 18
76 H
B8
Supplied 136 28
88 with 88 Supplied
196 B8 29
63 M with 88 B4 123
B4 20
B8 I 194
K 195 76
H
B8 149 162
72 B4
148 157 B8 B1
L
L C 71
46 B7 B10
F 78 31 B10
B38 D B8
193 Supplied 161
165 B12
with 88
192 191
B8 57 58
84 161 163
52 48
81 162
134 B10 32 33
B31 B8 56 B14
E 184 190
B3 B 38 34
183 B12
A 59
11
B 67
184
3 D B14
E
800 (Refer to Page 5-5.)
Supplied F
with 1
1
39
8
B3 B3
105
155 701
(Refer to Page 5-10.)
74 41
55
B8 B8
40
Confidential
5-3 5-4 PCG-FXA47/FXA48/FXA49 (AM)
5-2. FDD Section MEMO
How to use properly the FDD repair parts.
Types of service to be provided are different depending on the serial No. of the FDD in use.
Label FD
X-XXX-XXX-XX
Serial No.
The service types are shown below depending on the serial No. that is printed in the bottom right of the FD label.
800
806
807
804
801
805
802
B1
803
B1
Confidential
5-5 5-6 PCG-FXA47/FXA48/FXA49 (AM)
5-3. LCD Section (FXA48/FXA49 Model) – Made by NE – Ref.No.
201
Part No.
1-476-316-11
Description
INVERTER UNIT
Ref.No.
B8
Part No.
4-641-726-11
Description
SCREW (M2), SPECIAL HEAD
202 X-4623-380-1 HINGE LEFT 15 B22 4-641-726-81 SCREW (M2), SPECIAL HEAD
203 X-4623-448-2 ASSY HOU, BEZEL 15SA-Z B23 4-644-165-01 SCREW (M2.6X4), 0 PLATE P1 MAIN
224 206 4-637-902-31 LATCH B30 4-643-550-01 +P 2.6X6 LOCK PRECISION TYPE3
207 A-8023-519-A ASSY LCD XGA 15NE (S)
226
B22
208 4-637-903-01 SPRING LATCH
234
203 212 X-4624-622-1 ASSY HOU, DISPLAY 15SA-Z
B30 213 4-642-762-31 COVER HINGE (15)
235 214 4-660-598-11 (FXA49)...LABEL ID (U)
214 4-660-598-41 (FXA48)...LABEL ID (U)
206 219 1-757-604-11 PWB, FLEXIBLE PRINT (SINGLE)
234 208
220 4-642-755-01 BRACKET LCD (DL) 15
221 221 4-642-756-01 BRACKET LCD (BL) 15
222 4-642-757-01 BRACKET LCD (DR) 15
223 4-642-758-01 BRACKET LCD (BR) 15
224 4-646-217-11 COVER SCREW SIDE (15)
Supplied 225 4-635-277-22 COVER SCREW LOWER
B22 226 4-643-549-12 COVER SCREW SHAFT
with 203 224
228 X-4623-381-1 HINGE RIGHT 15
229 4-643-366-11 EDGE GUARD HINGE (15)
223
231 4-643-837-01 SHIELD (LCD)
234 4-635-276-22 COVER SCREW UPPER
235 4-642-760-12 CUSHION CENTER
236 4-658-280-01 SHIELD TAPE (LCD)
207 237 1-961-018-81 HARNESS,LCD (XGA-F-N)
202
231
238
B8 231 NOTE :
236
220 Set the DIP switch on the MBX-61 board (Main board) to match
with the LCD (A-8023-519-A) that is used in this computer.
237 ON
222
229
B23 1 2 3 4
225 212
213
Confidential
5-7 5-8 PCG-FXA47/FXA48/FXA49 (AM)
5-4. LCD Section (FXA47 Model) – Made by AC – Ref.No.
301
Part No.
1-476-318-21
Description
INVERTER UNIT
Ref.No. Part No. Description
ACCESSORIES
302 X-4623-378-1 HINGE LEFT MV ************
303 X-4623-409-3 ASSY HOU, BEZEL 14SA-Z
304 4-635-277-22 COVER SCREW LOWER 701 A-8048-965-A ASSY WEIGHT SAVER (Z)
303 305 4-635-276-22 COVER SCREW UPPER (Refer to Page 5-4.)
325 0702 1-476-342-22 ADAPTOR, AC
304 305 306 4-637-902-31 LATCH 703 1-528-934-21 BATTERY PACK, LITHIUM ION
B8 307 A-8023-466-A ASSY LCD XGA 14AU (S) (∗1) 704 1-575-875-51 CORD, CONNECTION
308 4-637-903-01 SPRING LATCH 0 1-757-562-21 CORD, POWER
B8 309 X-4623-379-1 HINGE RIGHT MV
312 X-4623-458-1 ASSY HOU, DISPLAY 14FV-Z 4-661-889-11 (FXA47/FXA49)...QUICK START, AMSTEL
4-661-889-12 (FXA48)...QUICK START, AMSTEL
313 4-642-762-31 COVER HINGE (15) 4-661-884-11 SPECIFICATIONS SHEET
314 4-660-598-21 LABEL ID (U)
317 1-757-605-11 PWB, FLEXIBLE PRINT (SINGLE) 2 [CHG] 1-476-342-31
319 4-654-966-01 SHEET (BEZEL), ADHESIVE
* 322 4-644-163-11 BRACKET LCD LEFT 14 (SA)
Supplied
with 303 * 323 4-644-164-11 BRACKET LCD RIGHT 14 (SA)
319
325 4-642-760-12 CUSHION CENTER 701 703
306
B22
326 1-961-018-81 HARNESS, LCD (XGA-F-N) Weight saver (1) Battery pack (1)
327 4-650-831-01 SHIELD TAPE (SK)
314 B8 4-641-726-11 SCREW (M2), SPECIAL HEAD
B8 B20 7-628-254-00 SCREW +PS 2.6X5
B22 4-658-316-01 ACE (M2), +B LOCK
308
322 307
B8
B20 702 704
AC adaptor (1) Video cable (1)
NOTE :
∗1 When replacing the LCD or the MBX-61 board, confirm
the DIP switch position beforehand.
Set the DIP switch on the MBX-61 board (Main board) to match
302 with the LCD (A-8023-466-A) that is used in this computer.
327 323
ON
B8
B8 B8 1 2 3 4
313
312
313
Confidential
5-9 5-10 PCG-FXA47/FXA48/FXA49 (AM)
5-5. Connector Section (CH Type only) Ref.No. Fig. Part No. Description
∗ Among the parts that are used on the boards of this model, only the connectors
that are show in the list can be replaced.
(The parts other that the specified connectors cannot be replaced.)
903
903
902
901
903 901
902
Confidential
5-11 5-12 PCG-FXA47/FXA48/FXA49 (AM)
(END)
PCG-FXA47/FXA48/FXA49 (AM)
English
2002A1600-1
9-874-507-04 Sony Corporation © 2002 Sony Corporation
— 32 — Published by Sony EMCS VAIO-GSC [SNT]
Revision History
[Confidential]
PCG-FXA47/FXA48/FXA49(AM)