Professional Documents
Culture Documents
Service Manual: Conf Idential
Service Manual: Conf Idential
PCG-TR3A/TR3AP/TR3F
PCG-TR2MP
PCG-TR3/TR3CN/TR3S/TR3T
SERVICE MANUAL
Ver. 5 2004D
Revision History
t ia l
Area Model Lineup
PCG-TR3/B
PCG-TR3/P
fi d 1 [MA]
en
on
Japanese Japanese PCG-TR3/S∗
PCG-TR3/SP∗
PCG-TR3E/B
C
PCG-TR3A 1 [MA]
US Canadian
American PCG-TR3AP∗ 1 [MA]
Latin PCG-TR3F 3 [MA] S400
European AEP/UK PCG-TR2MP 2 [MA]
International PCG-TR3 3 [MA]
Asian/Oceania/ Chinese PCG-TR3CN 4 [MA]
South Africa Thai PCG-TR3S 3 [MA]
Taiwan PCG-TR3T 3 [MA]
∗ : CTO model • Design and specifications are subject to
change without notice.
• 本機の仕様および外観は、改良のため予告なく変更
することがありますが、ご了承ください。
NOTEBOOK COMPUTER
9-876-364-05
Information in this document is subject to Caution Markings for Lithium/Ion Battery - The Service and Inspection Precautions
change without notice. following or similar texts shall be provided on
battery pack of equipment or in both the operat- 1. Obey precautionary markings and 4. Inspect after completing service
Sony, VAIO and CLIE are trademarks or regis- ing and the service instructions.
instructions
tered trademarks of Sony. Microsoft,Windows, After servicing, inspect to make sure that all
Windows Media, Outlook, Bookshelf and other CAUTION: Danger of explosion if battery is in- screws, components, and wiring have been re-
Labels and stamps on the cabinet, chassis, and
Microsoft products are trademarks or registered correctly replaced. Replace only with the same components identify are as requiring special pre- turned to their original condition. Also check the
trademarks of Microsoft Corporation in the or equivalent type recommended by the manu- cautions. Be sure to observe these precautions, area around the repair location to ensure that re-
United States and other countries.The word facturer. Discard used batteries according to the as well as all precautions listed in the operating pair work has caused no damage, and confirm
Bluetooth and the Bluetooth logo are trademarks manufacturer’s instructions. manual and other associated documents. safety.
of Bluetooth SIG, Inc. AMD, AMD logo, AMD
2. Use designated parts only 5. When replacing chip components...
Duron and combinations there of, 3DNow!, are CAUTION: The battery pack used in this device
trademarks of Advanced Micro Devices, Inc. Intel may present a fire or chemical burn hazard if
The set’s components possess important safety Never reuse components. Also remember that
Inside logo, Pentium and Celeron are trademarks mistreated. Do not disassemble, heat above the negative side of tantalum capacitors is easily
or registered trademarks of Intel Corporation. 100ºC (212ºF) or incinerate. Dispose of used bat- characteristics, such as noncombustibility and the
ability to tolerate large voltages. Be sure that re- damaged by heat.
Transmeta, the Transmeta logo, Crusoe Proces- tery promptly. Keep away from children.
placement parts possess the same safety charac-
sor, the Crusoe logo and combinations there of teristics as the originals. Also remember that the 6. When handling flexible print
are trademarks of Transmeta Corporation in the CAUTION: Changing the back up battery. 0 mark, which appears in circuit diagrams and boards...
USA and other countries. Graffiti, HotSync, • Overcharging, short circuiting, reverse charg- parts lists, denotes components that have particu-
PalmModem, and Palm OS are resistered trade- ing, multilati on or incineration of the cells must larly important safety functions; be extra sure to • The temperature of the soldering-iron tip
marks, and the Hotsync logo and Palm are trade- be avoided to prevent one or more of the fol- use only the designated components. should be about 270ºC.
marks of Palm,Inc. or its subsidiaries. (M) and lowing occurrences; release of toxic materials, • Do not apply the tip more than three times to
3. A l w ay s f o l l o w t h e o r i g i n a l the same pattern.
Motrola are trademarks of Motrora, Inc. Other release of hydrogen and/or oxygen gas, rise in
designwhen mounting parts and • Handle patterns with care; never apply force.
Motrola products and services with (R) mark like surface temperature.
Dragomball are the trademarks of Motrola, Inc. • If a cell has leaked or vented, it should be re- routing wires
placed immediately while avoiding to touch it Caution: Remember that hard disk drives
All other names of systems, products and without any protection. The original layout includes various safety fea-
areeasily damaged by vibration. Always
tures, such as inclusion of insulating materials
servicesin this manual are trademarks or regis- handlewith care.
(tubes and tape) and the mounting of parts above
tered trademarks of their respective owners. In the printer board. In addition, internal wiring has
this manual, the (TM) or (R) mark are not speci- been routed and clamped so as to keep it away
ATTENTION AU COMPOSANT AYANT
fied. from hot or high-voltage parts. When mounting RAPPORT
parts or routing wires, therefore, be sure À LA SÉCURITÉ!
toduplicate the original layout. LES COMPOSANTS IDENTIFÉS PAR UNE
M A R Q U E 0 S U R L E S D I AG R A M M E S
SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE
FONCTIONNEMENT. NE REMPLACER CES
COMPOSANTS QUE PAR DES PIÈSES SONY
D O N T L E S N U M É RO S S O N T D O N N É S
DA N S C E M A N U E L O U DA N S L E S
SUPPÉMENTS PUBLIÉS PAR SONY.
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
–2– PCG-TR3/TR3CN/TR3S/TR3T (AO)
TABLE OF CONTENTS
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
–3– PCG-TR3/TR3CN/TR3S/TR3T (AO)
CHAPTER 1.
SPECIFICATIONS
1-1.Specifications
J AM
PCG-TR3/B PCG-TR3E/B PCG-TR3/P PCG-TR3/SP∗, TR3/S∗ PCG-TR3AP∗ PCG-TR3A PCG-TR3F
CPU ULV P-M 1GHz M-Cel 800MHz ULV P-M 1GHz ULV P-M 1GHz ULV P-M 1GHz ULV P-M 1GHz ULV P-M 1GHz
or M-Cel 800MHz
Graphic Intel 855GM Intel 855GM Intel 855GM Intel 855GM Intel 855GM Intel 855GM Intel 855GM
LCD 10.6 WXGA 10.6 WXGA 10.6 WXGA 10.6 WXGA 10.6 WXGA 10.6 WXGA 10.6 WXGA
HDD 40GB 40GB 40GB 40GB 40GB 40GB 40GB
CD-RW/DVD-ROM CD-RW/DVD-ROM
OPT-DRIVE CD-RW/DVD-ROM CD-RW/DVD-ROM CD-RW/DVD-ROM CD-RW/DVD-ROM CD-RW/DVD-ROM
or DVD-RW or DVD-RW
256MB × 1 or 512MB × 1 512MB × 1
MEMORY1 512MB × 1 256MB × 1 512MB × 1 512MB × 1 512MB × 1
or 512MB × 2 or 512MB × 2
QUANTITY
[MAX] 1024MB 1024MB 1024MB 1024MB 1024MB 1024MB 1024MB
AC adaptor PCGA-AC16V6 PCGA-AC16V6 PCGA-AC16V6 PCGA-AC16V6 PCGA-AC16V6 PCGA-AC16V6 PCGA-AC16V6
Battery PCGA-BP2T PCGA-BP2T PCGA-BP2T PCGA-BP2T PCGA-BP2T PCGA-BP2T PCGA-BP2T
internal W-LAN a a a a a a a
OS XP Home XP Home XP Pro XP Pro, XP Home XP Pro XP Home XP Home
1 [MA] 1 [MA] 1 [MA] 3 [MA]
EU AO
PCG-TR2MP PCG-TR3 PCG-TR3S PCG-TR3T PCG-TR3CN
CPU ULV P-M 1GHz ULV P-M 1GHz ULV P-M 1GHz ULV P-M 1GHz ULV P-M 1GHz
Graphic Intel 855GM Intel 855GM Intel 855GM Intel 855GM Intel 855GM
LCD 10.6 WXGA 10.6 WXGA 10.6 WXGA 10.6 WXGA 10.6 WXGA
HDD 40GB 40GB 40GB 40GB 40GB
OPT-DRIVE CD-RW/DVD-ROM CD-RW/DVD-ROM CD-RW/DVD-ROM CD-RW/DVD-ROM CD-RW/DVD-ROM
MEMORY1 512MB × 1 512MB × 1 + 256MB × 1 512MB × 1 + 256MB × 1 512MB × 1 + 256MB × 1 512MB × 1 + 256MB × 1
QUANTITY
[MAX] 1024MB 1024MB 1024MB 1024MB 1024MB
AC adaptor PCGA-AC16V6 PCGA-AC16V6 PCGA-AC16V6 PCGA-AC16V6 PCGA-AC16V6
Battery PCGA-BP2T PCGA-BP2T PCGA-BP2T PCGA-BP2T PCGA-BP2T
internal W-LAN a a a a ×
OS XP Pro XP Home XP Home XP Home XP Home
2 [MA] 3 [MA] 3 [MA] 3 [MA] 4 [MA]
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
1-1 PCG-TR3/TR3CN/TR3S/TR3T (AO)
1-2. CTO Information
Productsname : PCG-TR3/SP(For Japaese Area) Products name : PCG-TR3/S(For Japaese Area)
Model name : PCG-4A1N Model name : PCG-4A1N
OS : WinXP Pro OS : XP Home
Ver.1.0 Ver.1.0
CPU:ULV P-M 1GHz CPU:M-Cel 800MHz CPU:ULV P-M 1GHz CPU:M-Cel 800MHz
M/B A-8068-352-A A-8068-353-A M/B A-8068-352-A A-8068-353-A
COMPLETED MBX-81(P1000) COMPLETED MBX-81(C800)(S) COMPLETED MBX-81(P1000) COMPLETED MBX-81(C800)(S)
40GB 40GB
HDD A-8117-809-A or A-8130-165-A HDD A-8117-809-A or A-8130-165-A
ASSY HDD 40GB (H,40) (S) or ASSY HDD 40GB (T,40) (S) ASSY HDD 40GB (H,40) (S) or ASSY HDD 40GB (T,40) (S)
802.11a/b/g 802.11a/b/g
W-LAN 1-761-864-11 W-LAN 1-761-864-11
CARD, WIRELESS LAN CARD, WIRELESS LAN
HeadPhone HeadPhone
HeadPhone 8-954-048-93 HeadPhone 8-954-048-93
HEADPHONE MDR-Q22LP/S2 SET HEADPHONE MDR-Q22LP/S2 SET
SMBUS2
i.LINK
Primary Secondary i.LINK0
Headphone
Daughter
Card)
Speaker
Line-Out
Line-in
Card)
MIC
Module PS/2
Module
Battery
Power
Power
Circuit
Circuit
IntMic Phone ExtMic Speaker
in Out in L&R
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
2-1 PCG-TR3/TR3CN/TR3S/TR3T (AO)
(END)
CHAPTER 3.
FRAME HARNESS DIAGRAM
CAMERA UNIT
BCX-U7 CAPTURE SWX-135
From board to connector
S6103 BOARD
INVERTER UNIT
SIDE A (direct connection)
Harness
SPEAKER LITHIUM ION (with connectors on both ends)
L ch BATTERY PACK Harness (soldering on either end)
CN6052 S6100
1 2 1 2 1 8 VOL Side R
CN6051 CN6050 S6101 DC IN CN4051
ZOOM Rear
LCD SPEAKER 1 A Y
S6102 1
8 1 MODULAR
R ch JACK
5 CN701
CN6100 1 2 CN801
Side L
LCD HARNESS LEX-46 BOARD SIDE A 173 172 NETWORK
RJ-45/11 HARNESS
MODULE KEY BOARD 44 45
(WITH FPC)
172 173 23 24 2 1 CN1402
CN2800 44 45
CN6200 1
45 1 45 1
10 CN6301
DRIVE
FFC
44 2 44 2 2 1 FPC-3 USB
30 29
2 1 CN1201 TOUCH PAD CN1602 CN1601 CN1202
50 49
FPC-2 J2150
BLUE HDD MIC IN
TOOTH 30 29 FLEXIBLE 4 [MA]
CN5900 PRINT 2 1
MODULE WIRELESS LAN MODEL J2250
14 PWB (HDD) HEADPHONE
DC-10L
CN2190
2 1
IFX-292 BOARD LEFT BUTTON RIGHT BUTTON 2
BLUE DC-9R
SIDE A 1 CN5901 WIRELESS
1
TOOTH FLEXIBLE
20 19
MODEL CN5601 PRNT LAN CARD ELECTRET CAP
PWB (LED) MICROPHONE
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
3-1 PCG-TR3/TR3CN/TR3S/TR3T (AO)
(END)
CHAPTER 4.
EXPLODED VIEWS AND PARTS LIST
• The parts list is compiled by blocks of a palmrest and bottom etc.The • 分解図と部品表は,パームレスト,ボトムなどのブロックごとに分かれてい
sections of the parts list are different depending on the model.Please ます。機種によって部品表のセクションが異なりますので,詳細は右下の一
refer to list of contents shown in the below. 覧表を参照してください。
Palmrest
Section Page
Palmrest
Palmrest LCD
P-1 ............................................................................................. 4-2
Main Board
M-1 ........................................................................................... 4-3
Bottom
B-1 ............................................................................................ 4-4
HDD HDD
H-1 ............................................................................................ 4-5
LCD
L-1 ............................................................................................. 4-6
Accessory Main board
A-1 ............................................................................................ 4-7
Bottom
Bottom
1 [MA]
120 J AM EU AO
4 [MA] PCG- TR3/B, TR3/P,
TR3/SP∗
TR3AP∗
TR3E/B
TR3CN
TR2MP
TR3/S∗
TR3/B
TR3/P
TR3A
TR3S
TR3F
TR3T
TR3/S, TR3/SP,
TR3
PCG-TR3CN
TR3E/B J
122 116 M-1 Ref. No. Part No. Description
104 1-827-266-31 CABLE, COAXIAL (WITH U. F. L CONNECTOR) z z z z z z
117 105 1-234-803-21 BLUETOOTH MODULE z z z z z z
4 [MA] 114 X-4625-889-4 ASSY (PALMREST) z z z z z z z z z z z z
Bluetooth model B4 4 [MA] X-2021-413-1 ASSY PALMREST (NO WL) z
115 X-4626-163-5 ASSY (LENS) (LED) (F) z z z z z z
118 115 114 X-4626-164-5 ASSY (LENS) (LED) (F) (BT) z z z z z z
4 [MA] X-2021-414-1 ASSY LENS LED F (NO WL) z
105 116 4-643-124-01 LABEL, SEAL z z z z z
qg 117 4-682-148-01 LABEL ID z
M-1 qh ql 4-682-148-11 LABEL ID z
104 B-1 4-682-148-91 LABEL ID z
B-1
4-682-148-21 LABEL ID z
4 [MA] 4-682-148-31 LABEL ID z
qk 4-682-150-11 LABEL ID z
M-1 w; 4-682-150-01 LABEL ID z
121
124 PCG-TR3CN B-1 4-682-150-21 LABEL ID z
EXCEPT qa 4-682-150-31 LABEL ID z
PCG-TR3CN H-1qs 4-682-148-41 LABEL ID z
H-1 wa 4-682-148-81 LABEL ID z
4 [MA] B-1 4-682-148-71 LABEL ID z
113 4 [MA] 4-682-150-41 LABEL ID z
B3 119 1-478-035-11 $ KEY BOARD UNIT (JP) z z z z z
103 1-478-035-21 $ KEY BOARD UNIT (US) z z z z z
1-478-036-71 KEY BOARD UNIT (LA) z
7 112
1-478-036-11 (UK, EFTA)...KEY BOARD UNIT (GB) z
B-1 B3
1-478-036-21 (German)...KEY BOARD UNIT (DE) z
B3 qd 1-478-036-31 (Swiss)...KEY BOARD UNIT (CH) z
B 109 B-1 1-478-036-51 (Italian)...KEY BOARD UNIT (IT) z
106 110 1-478-036-61 (Spanish)...KEY BOARD UNIT (ES) z
M-1 123 1-478-036-81 (French)...KEY BOARD UNIT (FR) z
108 111 1-478-035-41 KEY BOARD UNIT (TH) z
1-478-035-51 KEY BOARD UNIT (TW) z
121 4 [MA] 121 4-677-907-01 SPACER A z z z z z z z z z z z z
EXCEPT 122 4-679-811-01 CUSHION VGA P z
PCG-TR3CN 4 [MA] 124 4-672-236-01 TAPE COAXIAL CABLE z
B3
107 1 1 1 3 2 3 3 3 4
101 9 4 [MA]
102
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
0 B-1
H-1
• This parts list contains two different types of parts.
The first type is the parts that are common to all models.
The other type is the parts that are different depending on each model.
• この部品表は,機種共通の部品と,機種によって使い分けが必要な部品に分かれています。
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
4-2 PCG-TR3/TR3CN/TR3S/TR3T (AO)
M-1
M-1.Main Board
Ref. No. Part No. Description
TR3/SP∗
TR3AP∗
TR3E/B
BP-1
TR2MP
TR3CN
TR3/S∗
TR3/B
TR3/P
TR3A
TR3S
TR3F
TR3T
TR3
r; 304 J eh 317
H-1 P-1 5 Ref. No. Part No. Description
B-1 302 A-8068-352-A $ # COMPLETED MBX-81 (P1000) (S) z z z z z z z z z z z z
308 B-1 123 B2 A-8068-353-A $ # COMPLETED MBX-81 (C800) (S) z z z
el 303 320 A-8067-932-A COMPLETE PWB MM-9 z z z z z z z z z z z z
H-1 wl A-8068-457-A COMPLETE PWB MM-11G z z z z z z z
IH-1 B-1 K 1 1 1 3 2 3 3 3 4
1 B-1
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
302 A
B-1 B-1
ws HB-1 • This parts list contains two different types of parts.
B-1 wd
ef The first type is the parts that are common to all models.
B-1 B-1 GB-1
307 The other type is the parts that are different depending on each model.
Memory x2 model F
B-1 215
• この部品表は,機種共通の部品と,機種によって使い分けが必要な部品に分かれています。
307 C
wf 306 B-1
320 B-1 H-1 319
wh
B-1 wj
wg B-1 ek
B-1 B-1
301 320
B4
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
4-3 PCG-TR3/TR3CN/TR3S/TR3T (AO)
B-1
B-1. Bottom
Ref. No. Part No. Description
TR3/SP∗
TR3AP∗
TR3E/B
TR2MP
TR3CN
TR3/S∗
240 M-1 216
TR3/B
TR3/P
TR3A
TR3S
TR3F
TR3T
230
TR3
eg B2
A ek
M-1 M-1 208 Ref. No. Part No. Description
M-1
B4 qh ed 202 1-761-660-23 CARD, WIRELESS LAN (CLX11B 14CH) z z
244 P-1 M-1 213 1-761-660-31 CARD, WIRELESS LAN (CLX11B 11CH) z
243 es z
B5 1-761-784-11 CARD, WIRELESS LAN
206 214 1-761-786-11 CARD, WIRELESS LAN z z z z
215 ea
1-761-864-11 WIRELESS LAN CARD z z z
ws w; 1-761-864-31 WIRELESS LAN CARD z
201 P-1 208
M-1 wd 4 [MA] 203 A-8068-207-A COMPLETED FPC FPC-2 (S) z z z z z z z z z z z z
B4 M-1 wl e; 213
M-1 4 [MA] 204 4-676-895-01 TAPE HDD FPC S z z z z z z z z z z z z
[MA] 205 4-673-437-01 HOLDER (MINIPCI) z z z z z z z z z z z z
B5 4
231 4-673-433-01 ESCUTCHEON (L) z z z z z z z z z z z z
wg wa X-4626-443-1 ASSY ESCUTCHEON L z
wf M-1 P-1 233 X-4625-895-2 ASSY (BEZEL) (OPT) (M) z z z z z z z z z z z z z
M-1 wj qd 210 X-4626-530-1 ASSY BEZEL OPT DVDRW (M) z z z
wh M-1 P-1 235 1-796-822-11 $ # COMBO DRIVE (UJDA755, 9.5MM) z z z z z z z z z z z z z
206 B2 M-1 1-796-892-12 $ # DVDRW (UJ-812, 9.5MM) z z z
B4 211 245 4-679-812-01 COVER KENJINTON z
205 wk
204 B4 2 [MA] 246 2-024-295-01 GASKET W-LAN z
B2 B4 8 247 4-677-810-01 TAPE BTM z
212 2 [MA]
D B5 206
2 [MA] E 205 208 1 1 1 3 2 3 3 3 4
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
203 B4 209 • This parts list contains two different types of parts.
The first type is the parts that are common to all models.
206
246 The other type is the parts that are different depending on each model.
247 202 207
EXCEPT B5
PCG-TR2MP 4 [MA] PCG-TR3CN 206 • この部品表は,機種共通の部品と,機種によって使い分けが必要な部品に分かれています。
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
4-4 PCG-TR3/TR3CN/TR3S/TR3T (AO)
H-1
H-1. HDD (Type Hi)
Ref. No. Part No. Description
123 4-658-789-02 TAPE (HARNESS)
How to Use Parts Differently. 123 401 A-8117-809-A $ # ASSY HDD 40GB (H, 40) (S)
qa 402 1-689-155-11 PWB, FLEXIBLE PRINT (HDD_H) (Hi)
This series of product uses the two different types of HDD (To type and Hi type). P-1 403 4-674-939-01 SHEET (HDD) (H) (Hi)
404 4-676-896-01 CUSHION HDD (H) (Hi)
When replacing the HDD, use the To type parts for the To type HDD, and use the Hi type parts 401 403
B7
r; * 406 4-673-629-01 BRACKET (HDD) (R) (H)
for the Hi type HDD. M-1 * 407 4-673-628-01 BRACKET (HDD) (L) (H)
B2 408 4-676-894-01 TAPE HDD FPC L
Replace the peripheral parts of HDD with the same type in the same way. 409 4-676-895-01 TAPE HDD FPC S
407 404
[ How to identify the To and Hi types of parts ] el B2 4-672-836-11 SCREW, M2 SPECIAL HEAD, EG GRIP (M2X4)
402 B7 4-679-325-01 PS SCREW M2.5
B7
MODEL NO. HTC424040F9AT00 MODEL NO. MK3004GAH
I
M-1 406
409
408
(Type To)
Ref. No. Part No. Description
qa
P-1 411 A-8130-165-A $ # ASSY HDD 40GB (T, 40) (S)
412 1-688-245-11 PWB, FLEXIBLE PRINT (HDD) (To)
B2 416 413 4-674-940-02 SHEET (HDD) (T) (To)
414 4-677-703-01 CUSHION HDD (C) (To)
(Type Hi) (Type To) 0 * 416 4-673-430-02 # BRACKET (HDD) (T)
P-1
el B2 4-672-836-11 SCREW, M2 SPECIAL HEAD, EG GRIP (M2X4)
M-1
qs 4
411 P-1 B-1
413 414
414
414
Type Hi Type To 412
TR3/B z z
TR3E/B z z
J TR3/P z z 1 [MA] 414 I
2 M-1
TR3/SP∗ z z r;
M-1
B-1
TR3/S∗ z z
TR3AP∗ z z 1 [MA]
AM TR3A z z 1 [MA]
TR3F z z 3 [MA]
EU TR2MP z z 2 [MA]
TR3 z z 3 [MA]
TR3S z 3 [MA]
AO
TR3T z 3 [MA]
TR3CN z z 4 [MA]
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
4-5 PCG-TR3/TR3CN/TR3S/TR3T (AO)
L-1
L-1. LCD (10.6-inch WXGA) (High Brightness)
– Made by SH – Ref. No. Part No. Description
TR3/SP∗
TR3AP∗
TR3E/B
TR2MP
TR3CN
TR3/S∗
TR3/B
TR3/P
TR3A
TR3S
TR3F
TR3T
TR3
215 215 Ref. No. Part No. Description
638 215 640 4 [MA] 625 1-754-288-11 ANTENNA (2.4/5G) z z z z z z z z z z z z
4 [MA] 639 1-400-255-11 FERRITE CORE z z z z z z z z z z z z
N 4
rs 627
B2
[MA]
215
637 625
B10 639
M
619 EXCEPT
PCG-TR3CN
N 215 4 [MA]
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
4-6 PCG-TR3/TR3CN/TR3S/TR3T (AO)
A-1
A-1. Accessories
Ref. No. Part No. Description
TR3/SP∗
TR3AP∗
TR3E/B
TR3CN
TR2MP
TR3/S∗
TR3/B
TR3/P
TR3S
TR3A
TR3F
TR3T
TR3
AC Adaptor Power Cord Power Cord
Ref. No. Part No. Description
1002 A-8068-793-A $ & BATTERY PACK BP2T (U) (S) z z
A-8068-794-A $ & BATTERY PACK BP2T (J) (S) z z z z z
A-8068-795-A $ & BATTERY PACK BP2T (E/I) (S) z z z z z z
1003 8-954-048-93 & HEADPHONE MDR-Q22LP/S2 SET z z z z z z
0 1004 1-790-732-32 & CORD, POWER z z z z z
0 1005 1-757-562-21 & CORD, POWER z z z z
0 1006 1-555-074-32 & CORD, POWER z
0 1007 1-575-131-61 & CORD, POWER z
3 [MA] 3 [MA] 0 1009 1-770-019-12 & (UK)...ADAPTOR, CONVERSION PLUG 3P z
0 1010 1-782-476-22 & CORD, POWER z
0 1011 1-575-131-72 & CORD, POWER z
1007 1012 0 1012 1-823-935-51 & CORD, AC POWER z
- 1-816-429-12 & (UK)PHONE PLUG (GB) z
1002 Power Cord AC Power Cord - 4-682-324-01 & Instruction Manual (XP) z z z z z
- 4-682-268-11 & Instruction Manual (XP) z z
z
Battery Pack - 4-682-268-41
- 4-682-269-31
&
&
Instruction Manual (XP)
Instruction Manual (XP) z
- 4-681-653-01 & QUICK START z z
- 4-681-839-01 & QUICK START z
- 4-681-497-11 & (UK, EFTA)HW SPECS z
- 4-681-497-21 & (German, Swiss)HW SPECS z
- 4-681-497-31 & (French, Swiss)HW SPECS z
- 4-681-497-41 & (Italian)HW SPECS z
- 4-681-497-51 & (EFTA)HW SPECS z
- 4-681-497-61 & (Spanish)HW SPECS z
1008 - 4-681-921-01 & GETTING STARTED z
Power Cord 1 1 1 3 2 3 3 3 4
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
[MA]
1003
Headphone • This parts list contains two different types of parts.
The first type is the parts that are common to all models.
The other type is the parts that are different depending on each model.
2 [MA] • この部品表は,機種共通の部品と,機種によって使い分けが必要な部品に分かれています。
1009
Conversion Plug
3P Adaptor
1004
Power Cord
1 [MA]
4 [MA]
1005
Power Cord 1010
Power Cord
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
4-7 PCG-TR3/TR3CN/TR3S/TR3T (AO)
(END)
CHAPTER 5.
OTHER
5-1.The Barcode Label
The hatched portion of the barcode is used as the repair data.
バーコードラベルの網掛け部は,修理データとして使用いたします。
[ MBX-81 Board ] [ COMBO Drive ] (Made by PA) [ HDD (40GB) ] (Made by TO)
(Side A) (Top) (Top)
E E
G
A, B
E
C
[ Bracket (OPT) ]
(Top)
[ LCD (10.6 inch WXGA) Unit ] (Made by SH)
(Rear) E
A, B
A, B
E A, B
A : Part No.
B : Serial No.
C : Revision No.
D : Product Code
E : Maker Barcode
F : Global User ID (iLink)
G : Mac Address
: Barcode
Confidential
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
5-1 PCG-TR3/TR3CN/TR3S/TR3T (AO)
(END)
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
PCG-TR3/TR3CN/TR3S/TR3T (AO)
∗ : CTO Model
* : Additional Models This manual and the constituent data may not be
replicated, copied nor reprinted in whole or in part
without prior written authorization of Sony Corporation.
本マニュアルの一部,または全部について,無断で
データの複製,複写,転載することを禁じます。
English/Japanese
2004D0500-1
9-876-364-05 Sony Corporation © 2004 Sony Corporation
– 16 – Published by Sony EMCS VAIO-GSC [N]
Revision History
-02 Ver. 2 2004.02.04 1 Front Page (Model Lineup), Page 1-1, Page 1-2, Page 4-1 to 4-5, Page 4-7, Back Cover N2004_014AK
-03 Ver. 3 2004.02.16 2 Front Page (Model Lineup), Page 1-1, Page 4-1 to 4-5, Page 4-7, Back Cover N2004_017AK
-04 Ver. 4 2004.03.25 3 Front Page (Model Lineup), Page 1-1, Page 4-1 to 4-5, Page 4-7, Back Cover N2004_042AK
-05 Ver. 5 2004.04.26 4 Front Page (Model Lineup), Page 1-1, Page 3-1, Page 4-1 to 4-7, Back Cover N2004_049AK
<Remarks>
[Confidential]
PCG-TR3/TR3E (J)
PCG-TR3A/TR3AP/TR3F (AM)
PCG-TR2MP (EU)
PCG-TR3/TR3CN/TR3S/TR3T (AO)